Kia Telluride 2022: Retiros, Quejas y Ley de Limón de California

Standard opening of sunroof, the a part of the wind deflector snapped, without any abnormal incident or misuse. This caused the glass to be misaligned and other damage to the sunroof track. Estimated cost $6000. No warning and no prior damage for causation.

NHTSA #11734103

I was driving down the highway at 73 MPH and the sunroof shattered sending glass into the interior of the car, onto me, and into my clothes. It sounded like a gunshot and was terrifying.

NHTSA #11727759

Front sunroof suddenly shattered while going down highway. Remaining glass was pushed outward and no sign of impact was seen.

NHTSA #11718295

Sunroof exploded while driving in the 540 expressway.

NHTSA #11741664

Windshield cracks so easily, slightest road debris creates a chip then crack

NHTSA #11732381

We were driving in the left hand lane on i75 south about 15 miles south of [XXX] and about 10 miles from [XXX] . We were traveling about 75 mph with air conditioning on low. We heard a loud bang and pulled off at exit 328 to investigate. We pulled over at Myers carpet on dug gap road. We looked at the sunroof and it looked like it had exploded upward. 1/3 of the glass was gone and a cone like upward shattering appears in the edges of the blowout area. We had to go to the nearby tractor supply to find duct tape and plastic sheeting to tape over the whole sunroof to drive home to [XXX] . It just happened on 3/15/2026 at approximately 4pm. We have not yet been to a Kia dealer or called consumer affairs at Kia corporate yet. I am filing a ticket with Kia now. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11724471

While attempting to operate the sunroof on my Kia Telluride, the sunroof mechanism failed and became completely stuck in the open position. The sunroof will not close, bypass, or reset, leaving the cabin fully exposed. Upon inspection, it appears the internal mechanism arms or wind deflector components have failed/broken, which prevents the glass from sliding forward back into its sealed, closed position.

NHTSA #11740476

Subject: Safety Concern – Backup Camera Failure Causing Complete Safety System Malfunction (2022 Kia Telluride) I am reporting a safety concern regarding a 2022 Kia Telluride related to the rear backup camera assembly. The backup camera failed due to water infiltration through the camera seal, which entered the camera housing and caused an electrical short. When this occurred, the failure did not only disable the backup camera but caused the entire vehicle safety system to malfunction, disabling multiple safety features until the issue was repaired. When we brought the vehicle to the dealership, they stated that this was not the first Kia Telluride they had seen with the same issue. The quoted repair cost from the dealership was approximately $1,200. I ultimately replaced the camera myself, which restored the safety systems to normal operation. I have retained the failed camera assembly, which clearly shows the location where the seal failed and water entered the unit. Because the failure of this component disables multiple vehicle safety systems, I believe this may represent a broader safety concern if it is occurring in other vehicles. I am submitting this report so the issue can be reviewed for potential defects affecting other vehicles. Vehicle information and additional details can be provided if needed. Thank you. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11721912

Driver LCD screen went blank

NHTSA #11712584

Was driving heard a noise and then lost power to gas peddle and bunch of smoke and then flames coming from front of car got out and there were flames coming from hood eventually flames died down and was just smoking police &fire department were called. Piston blew through engine block these engine have a known oil consumption issue and I have kept up with oil .

NHTSA #11711813

Plastic oil filter housing cracked after oil change around 100k miles.

NHTSA #11704070

This is a very well known issue among all model years of the Kia Telluride. The plastic filter housing is made out of plastic and over time it ends up failing causing an oil leak. I ended up having to pay out of pocket for a aftermarket housing that was metal and not plastic that won’t fail.

NHTSA #11702907

Clear coat on pillar trim around windows on all four doors is oxidizing.

NHTSA #11743966

While driving our 2022 Kia Telluride under normal operating conditions, the panoramic sunroof glass suddenly and spontaneously shattered outward with a loud explosion-like noise. The sunroof was fully closed at the time of the explosion. There was no impact with any object, no debris strike, no road hazard, and no external cause observed. Weather conditions were clear, traffic was normal, and the vehicle was traveling at a normal speed. The failure occurred without warning. There were no prior cracks, chips, noises, warning lights, or messages before the incident. A large hole immediately formed in the sunroof glass, and glass fragments fell into the vehicle and were caught by the shade. The sudden shattering and loud noise scared the driver and passengers and created an immediate safety hazard, requiring us to pull over right away. Occupants were placed at risk of injury from falling glass and sudden driver distraction. For safety reasons, loose and hanging glass was removed after stopping the vehicle. At the time of this report, the vehicle has not yet been inspected by a Kia dealer, manufacturer representative, or independent service center, as the incident occurred recently (we have an appointment in two days). The remaining sunroof components and vehicle are available for inspection upon request. This appears to be a sudden and spontaneous glass failure occurring during normal vehicle operation.

NHTSA #11706913

White Paint Chipping prematurely

NHTSA #11693747

Catastrophic rear differential failure at highway speed following recent warranty repair. Vehicle previously brought to Kia dealership for rear differential knocking noise. Warranty repair performed and vehicle returned. Within one week, original noise returned with additional whirling/ grinding sound.While traveling approximately 70 mph on the highway, vehicle experienced a sudden loud bang and immediate abrupt stop in traffic. At the time of failure, wife and two children were in the vehicle. Incident posed a severe and life-threatening safety risk.Visual inspection indicates complete rear differential mechanical failure, with fluid and component debris present underneath vehicle. Vehicle is currently unsafe to operate.Failure occurred immediately following manufacturer-authorized warranty repair.

NHTSA #11726106

The Telluride has developed a shimmy. At first, the shimmy was noted at lower speeds, around 35 to 45 mph while under minimal load such as going uphill and slightly accelerating. The car was taken to the dealership. The tires were balanced. We were told no other problems. A month later, same thing, same result. We just took a 2700 mile trip. The shimmy is apparent at higher speeds and in all transmission modes of operation.

NHTSA #11693102

The contact owns a 2022 Kia Telluride. The contact stated that after his wife had parked the vehicle and left the front driver's side door opened while there were two passengers in the rear seats. The contact stated that his wife unloaded the vehicle and walked towards the front door. The contact's mother-in-law and daughter who were in the residence noticed that the vehicle was rolling back and alerted the contact's wife, who turned around and ran after the vehicle. The vehicle crashed into the rear passenger's side of another parked unoccupied vehicle. The vehicle continued to roll back until it crashed into a palm tree. The contact stated that none of the passengers occupying the rear seats sustained injuries. The vehicle was driven back to the driveway. The contact stated that the front driver's side door which was opened at the time of the incident, became bent and damaged. Additionally, the rear of the vehicle was damaged. The contact stated that the incident was recorded by his front door camera. No police report was filed. The vehicle was then towed to an autobody repair shop to be repaired. The contact stated that the recall of NHTSA Campaign Number: 24V214000(Power Train) was previously completed on the vehicle; however, the recall remedy failed to fix the failure. The dealer was notified of the failure, but no assistance was provided. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a case was filed. The contact sent a recording of the incident to the manufacturer, but the manufacturer denied assistance. The failure mileage was approximately 36,000.

NHTSA #11639037

The oil filter housing cracked on the car, causing all the oil to leak out. In researching this, I have found that this is a common problem with the Kia Telluride and Kia Sorrento. The problem is that the oil filter housing is made of cheap plastic and not durable material such as aluminum or steel. This allows the oil filter housing to easily crack under stress. In speaking with the dealership, this is not an uncommon problem. I feel that this should be covered under the Powertrain warranty or through a recall. A quick Google search will show that the problem is widespread in the Sorrento and Telluride models. This repair cost me a total of $425. If I had not replaced or repaired oil filter housing, the engine would have locked up as all the oil at escaped onto the pavement.

NHTSA #11709092

Borescope inspection of the engine shows multiple signs of internal mechanical failure involving oil control, piston ring integrity, coolant intrusion, and cylinder wall damage. Excessive oil buildup is visible above the oil control ring, far beyond what is expected at 59k miles. Cylinder walls show heavy polishing where cross-hatching should be visible, indicating loss of lubrication and abnormal wear. Carbon deposits are extremely thick; in several areas carbon has flaked off and been pulled downward into the cylinder, creating scoring. Straight vertical scoring marks cut through the normal diagonal honing pattern, confirming blow-by and damage to the cylinder sleeves. Evidence of coolant intrusion is present, including orange discoloration consistent with rust/coolant contamination, excessive moisture, and steam-cleaned areas of the combustion chamber. The intake valve and combustion surfaces appear abnormally clean, consistent with coolant steam-washing. This suggests head-gasket failure, a block or head casting defect, or ring damage (possible cracked scraper ring). Coolant in the cylinders can wash away oil from the bore, leading to rusted pistons and accelerated scoring. Multiple pictures show severe scoring and loss of lubrication. This compromises the ability of new pistons or rings to seal, meaning the cylinder walls would continue to allow blow-by, oil burning, coolant intrusion, and friction. Even attempting to polish or recondition these bores would enlarge them, causing piston flutter, noise, and long-term failure. Based on the level of damage, the engine is no longer safe or reliable. A seized piston could cause sudden loss of power at highway speeds, creating a safety risk. The observed defects indicate a potential manufacturing or casting issue that may affect other engines. The dealership and KIA Consumer Affairs have been notified but there has been no replacement or resolution after 3 months of ongoing issues, and 8 weeks of holding my vehicle.

NHTSA #11700897

The vigils when turning left or right makes a grumbling sound from the rear or transmission. Took the car to Kia in Huntsville. Al and they keep saying they don’t hear anything. You can clearly hear it. I have video recording. Seem like they don’t want to cover what is broken. It could possibly be the transmission case/ coupler because it’s an AWD. Next I will be filing a law suite.

NHTSA #11610730

Noise over bumps from the rear

NHTSA #11703472

The contact owns a 2022 Kia Telluride. The contact stated that while driving at various speeds, there was a clanking sound coming from the rear of the vehicle. The cause of the failure was not yet determined. The local dealer and manufacturer was not yet notified of the failure. The failure mileage was 46,000.

NHTSA #11672840

Car sways between 60-80 mph and the shocks didn’t fix it

NHTSA #11580320

As part of the fix to address a recall related to a a drivetrain defect and potential rolling issues, Kia installed software that would automatically apply the emergency brake when the car was put into park and the door was opened, and/or turned off. The problem with this fix is that once the car is off, the driver can not disengage the parking brake, thus creating an issue related to towing or moving the vehicle out of the road after an accident. This also makes it impossible to perform a rear brake replacement as the parking brake cannot be released. This software update needs to be amended so the the driver can disengage the parking brake when needed.

NHTSA #11646637

Received a software "fix" that engages my parking brake every time I turn off the engine. I don't want the parking brake engaged each time I stop - the potential for freezing in place due to cold or rust is too much. Not even sure what this "fix" was supposed to resolve.

NHTSA #11617929

A Kia dealership documented they performed the voluntary service recall SC252 HECU Inspection and determined my vehicle was within the guidelines and did not need replacement. 6 months later my vehicle experienced the symptoms of the HECU issue. The EPB, Auto Hold, and the ABS lights appeared on the console. We took the vehicle in for service, we were told they didn't have someone available to look at the issue and told us to reschedule, that is a separate issue. Weeks later when we took it and asked someone to look at it, since their next appointment wasn't for almost a month. The mechanic said immediately we can't let you leave with this car it is not safe. The brake fluid had leaked into the HECU box. So either the voluntary recall is inadequate or dealerships are not properly doing the inspection. I can not find detailed information on the risk associated with this but this is similar to the fire risk Kia has had in the past. In any case leaking brake fluid into the Hydraulic Electronic Control Unit can't be safe. If this is a know issue why is this still a voluntary recall. My family was put in danger and Kia continues to ignore this is an issue.

NHTSA #11555324

After a long winter in northern ILLINOIS, we had a 70’ afternoon and I tried to open my sunroof and it stopped working. I heard a crunching sound and tried to reverse it and that may have made it worse. It had been working fine in the fall months September and October when I last used it. It did not cause a safety issue. No one was at risk. I’ve taken the car to the closest KIA dealer to me . Castle KIA in McHenry IL. The Kia dealer gave me an estimate on cost . There was no warning signs of it being broken until it actually happened.

NHTSA #11727329

While driving at low speed through neighborhood streets, the front sunroof exploded out of nowhere. Safety was put at risk because of tempered glass falling on driver and passengers. Luckily the shade was closed. Has not yet been inspected by anyone. No warnings of the failure. Kia said they would not cover under warranty.

NHTSA #11606929

The vehicle is available for inspection. The vehicle windshield just cracked while the vehicle was parked in a driveway. Something must be defective in the manufacturing process. Windshield that just crack for no reason can cause safety concerns while driving for the passengers and other vehicles. The car was not being driven but simply the windshield cracked. We have not yet got it inspected by the dealer or other party/agency. The issue has not been recreated yet. Since it was parked it is unknown if any indicator lights or other warning occurred. This happened in the City of Orange California July 1, 2023. I would like a response from your agency about if others have reported this problem because Kia Motors was not very helpful. Where else can I get information about this issue? What else should we do? Please help.

NHTSA #11535808

The contact owns a 2022 Kia Telluride. The contact stated that while the vehicle was parked, the contact noticed that while entering the vehicle, the front passenger's seat had a burned spot, and the front passenger side visor was melted. In addition, the contact noticed brown residue throughout the interior of the vehicle. The fire had appeared to self-extinguish. No warning lights were illuminated prior to the failure. The vehicle was unoccupied. The vehicle was towed to an independent mechanic, but the inspection had not been completed. The fire department was scheduled to inspect the vehicle within the next few days. The contact stated that the inspection was ongoing. In addition, the contact stated that the NHTSA Campaign Number: 24V407000 (Seats) was completed on 10/15/2024. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 77,000.

NHTSA #11722230

My daughter was trying to get into the backseat of our Kia Telluride. She had one leg raised with her knee resting on the stepping area inside the rear passenger door. While in this position, she pressed the handle to fold the rear seat. The lower portion of the seat suddenly swung forward and closed with fast, strong force onto her folded knee joint, pinning it between the moving seat and the vehicle floor. She screamed immediately in pain and could not free her leg. I had to run around to the opposite side of the vehicle (the rear passenger side) and physically lift the seat off her knee to release her. The impact left a noticeable bruise just above her left knee. The folding seat mechanism appeared to move too quickly and with excessive force, and it did not stop or slow down once it encountered her knee. This presents a potential safety hazard, especially for children or passengers entering the vehicle who may accidentally activate the seat handle.

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11701376

The contact owns a 2022 Kia Telluride The contact received notification of NHTSA Campaign Number: 24V407000 (Seats); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at an undisclosed speed, the contact noticed that the front power seat became inoperable. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed and determined that the power seat slide knob had failed and needed to be replaced. The vehicle was not repaired due to the parts not being available. The manufacturer was not made aware of the failure. The failure mileage was approximately 16,000. Parts distribution disconnect.

NHTSA #11611123

I am reporting a safety issue with my vehicle’s electronic door locking system. Vehicle: 2022 Kia Telluride SX Prestige with Nightfall Edition Issue: The door locks randomly unlock on their own multiple times without any input. This behavior happens specifically when the child safety lock is enabled. While driving or after locking the vehicle, the locks will unexpectedly unlock, creating a serious safety and security concern. Safety Concern: This issue poses a risk to passengers, especially children, because doors may unlock unexpectedly while the vehicle is in motion. It also creates a security risk when the vehicle is parked, as the car cannot be reliably kept locked. Additional Notes: I have seen multiple similar complaints from other Telluride owners reporting the same behavior. This appears to be a recurring defect rather than an isolated incident. I am requesting that this issue be investigated for a potential defect and safety recall.

NHTSA #11710797

Sunroof is stuck in an open position unable to be closed. Upon attempting to open the sunroof, the deflector snapped off the assembly and the sunroof track broke. Took car to dealership (Raceway Kia, 4044 US-9, Freehold, NJ 07728) for service. Dealership indicated the sunroof is beyond repair and requires installation of an entirely brand new sunroof assembly at a cost of $5730 because it occurred outside the warranty (warranty expired at 60,000 miles and the car had 70,463 miles when sunroof broke). They were unable to manually close the sunroof as a temporary solution. Therefore, the sunroof remains open due to the broken track and is covered with plastic to avoid the elements. There were no prior symptoms indicating that the sunroof would break in this way. In fact, in three years of ownership, the sunroof was rarely used and only opened a handful of times before breaking. At this time of this writing, the sunroof is available for inspection while I look for more economical means of repair versus the dealership's plan to replace the entire assembly.

NHTSA #11622002

The sunroof broke while being opened which required immediate repair since it was propped open. The only fix according to the dealer was to replace the entire unit which cost more than $5k with parts and labor

NHTSA #11621374

The contact owns a 2022 Kia Telluride. The contact stated that while driving at 66 MPH, the sunroof unexpectedly exploded. There was no impact on the sunroof to cause the failure. The sunroof cover was closed during the failure. There were no injuries sustained. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was 21,178.

NHTSA #11734250

The contact owns a 2022 Kia Telluride. The contact stated that while driving at an undisclosed speed, the rear windshield inadvertently shattered. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who was unable to diagnose the failure. The contact was informed that the manufacturer was aware of the issue. The vehicle was repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was 37,000.

NHTSA #11632666

The vehicle began showing serious safety related symptoms before the engine failed. These included engine knocking, repeated sensor failures, the speedometer and odometer blacking out while driving, the navigation screen going dark, and the entire instrument cluster malfunctioning. These issues caused loss of speed information, loss of vehicle status, and loss of navigation visibility, creating unsafe driving conditions. Despite these warning signs, the engine later failed suddenly at around 71,399 miles with no warning lights, no oil pressure alerts, and no overheating indicators. The sudden loss of power created a highway safety hazard due to loss of propulsion and reduced steering and braking assist. The manufacturer and dealership also provided conflicting and misleading information about warranty coverage, including a claim of “no warranty on engine,” which contradicts the official warranty coverage documents. This has delayed proper repair of a safety related defect.

NHTSA #11739200

This is supplemental evidence for NHTSA Safety Complaint #11739200 UNIFIED SUPPLEMENTAL EVIDENCE PACKET SEE UPLOADED FILE

NHTSA #11739546

Vehicle Information • Make: Kia • Model: Telluride • Year: 2022 • Approx. Mileage: 30k 2. System Involved • Component/System: Forward Collision Avoidance, Automatic Emergency Braking, Brakes, or Electronic Stability Control 3. Incident Description On 6/7/25 while driving my 2022 Kia Telluride on neighborhood street in Windsor Park austin Texas at approximately 25-30 mph the vehicle suddenly and forcefully braked on its own with no warning and no visible obstacle or vehicle in front of me. This unexpected braking occurred under normal driving conditions, with clear weather and dry pavement, and almost caused a collision with the vehicle behind me. No warning lights appeared on the dashboard, and no manual braking was applied by me. I believe this may be related to known technical service bulletins SC243 and SC252 concerning faulty automatic braking logic and the hydraulic electronic control unit (HECU). This is a serious safety concern, and I am submitting this complaint in the hope that Kia will address this potential defect through recall or repair. There are reports similar to mine at highway speeds which would be deadly. 4. What Happened Next? I have contacted my local Kia dealership for inspection and plan to request that they document and diagnose the incident fully. Their online scheduler is showing next service appt not for over a week out which is not soon enough. I will call them first thing in the morning. I am also submitting this report to NHTSA to ensure that this is recorded as part of any ongoing safety investigation. Our vehicle was serviced within the last few months and we were assured there were no safety recalls on our vehicle. We would like this reevaluated.

NHTSA #11665558

I’ve had numerous incidents where we were driving with adaptive cruise on and the vehicle will inexplicably engage the FCA system and slam on the brakes. This has occurred with no vehicles in front of me in clear conditions And had nearly caused a rear end collision.

NHTSA #11538285

My Kia Telluride backup camera and screen has become unusable with random colors, screen dark spots, blacking out, and pixelation. This is becoming a widespread problem according to multiple message board posts for Tellurides. I cannot use the backup camera. Most users are reporting Kia refuses to cover as a safety issues and is charging over $8000 to replace the entire infotainment system. There were no warnings, just starting happening randomly and is now seemingly permanent.

NHTSA #11659723

The gauge center behind the steering wheel will freeze every couple of weeks and will stay frozen until the car is shut off. After a few hours I can turn the car back on and it will work correctly. The speedometer analogue gauge will work but the digital screen will freeze. For instance, yesterday it was frozen on 23 MPH and I was in park! The issue this causes is that I cannot use the cruise control, change the display to view other info, the blind spot cameras don't work, or any other info displayed there. I have video and pics.

NHTSA #11539066

A deer ran into my vehicle while I’m traveling at 55MPH and my airbags did not deploy. My vehicle is leaking fluids and smoking.

NHTSA #11624291

Vehicle struck drivers side rear passenger door going at least 30mph and side air bags did not deploy. Upon inspection and door removal for repair, it was found that in the crash, the air bag sensor was struck and broke. The door and everything in it has to be replaced as well as the unibody sections surrounding each side door. This was a significant impact where the side air bags should have deployed.

NHTSA #11569222

Driving on highway in Dallas in high heat with no cars in front of me. Nothing appeared to hit Windshield or fly up but windshield cracked at very edge of drivers side and cracked at least 12 inches across within 5-10 minutes.

NHTSA #11543457

A small rock hit my window recently causing a small indent. The next morning three other cracks (each over a foot long), appeared. The new cracks didn’t come from the rock indent. Just started at random spots and within a couple hours connected. Doesn’t seem very safe and seems like the glass wouldn’t protect my family and I in a collision. Seems like it would just collapse in on us. It also makes it unsafe to drive by impeding our vision. Vehicle component has not been inspected but is available to upon request. No warning signs have been transmitted. Problem with faulty windshields has not been confirmed by dealer.

NHTSA #11519530

The vehicle experiences a recurring mechanical failure where the electronic AWD coupling/rear axle locks up and binds when accelerating through turns. This creates an immediate safety hazard by altering steering dynamics and causing vehicle hesitation or severe wheel hop in intersection turns. A certified Kia dealership has already fully replaced the entire factory AWD Coupling assembly twice: first under the original warranty on July 16, 2024 at 48,054 miles, and again under warranty on May 2, 2025 at 59,350 miles. Following a preliminary check-in for the same symptom on April 9, 2025, this identical component failure has now recurred for a third time at approximately 77,000 miles.

NHTSA #11743123

I was driving the vehicle and came to a stop sign. When I accelerated to turn and drive what was a steep windy downhill Road my car jerked some and the check engine light battery light and oil light came on the dash when I went to push the brakes they went all the way to the floor and the car did not stop. I continued to try the brakes and had to use the emergency break to pull up and down to stop and drive up on a hill to not crash into other vehicles I have my vehicle at Kia and they are claiming there is absolutely nothing wrong with the vehicle and I am to pick it up and leave the lot. They have not offered a loaner car or shown any concerns of my safety leaving the lot. I have asked for it to be in writing, but my car is safe to leave and they are not doing so this has caused major anxiety and PTSD to even begin to drive myself and my children are very shook up over this.

Reportado presuntamente: 2 lesiones (según lo reportado a NHTSA). NHTSA #11737637

While operating my Kia vehicle, the vehicle experienced a sudden loss of braking capability and loss of acceleration/power while traveling downhill. Multiple warning lights reportedly illuminated during the event, including the battery light, oil light, and check engine light. The incident created a serious safety concern due to inability to properly control vehicle speed and operation. The vehicle was taken to an authorized Kia dealership for inspection. However, the dealership has refused to provide written confirmation that the vehicle is safe to drive and stated they would not assume liability regarding operation of the vehicle. The dealership further recommended towing the vehicle if I feel unsafe operating it. I am requesting investigation into the safety-related condition involving braking/drivability failure and related warning systems.

NHTSA #11738609

The contact owns a 2022 Kia Telluride. The contact stated that while driving at an undisclosed speed at night, the side view mirror's blind-spot system generated phantom alerts while there was no object nearby. Additionally, the headlights inadvertently fluctuated between dim (low beam) and extremely bright (high beam) settings. The instrument cluster displayed that the vehicle unintendedly switched to Smart Drive Mode but failed to display the transmission gears. The trunk button intermittently failed to operate as needed. The back over prevention sensing system failed to alert that there was an object behind the vehicle while reversing. There were several unknown warning lights illuminated. The vehicle was towed to the dealer, who was unable to duplicate the failure, but twenty-six history trouble codes were retrieved, indicating the power steering, ABS, air bags, blind spot collision, front radar, and Integrated Charging Control Unit (ICCU) malfunctions. The contact stated that prior to the failure, a Voluntary Emissions Service Campaign: SC357 Engine Control Unit (ECU) was performed on the vehicle; however, the dealer informed the contact that the failure was not related. The dealer recalibrated the front radar, but the failure recurred at night while driving. The vehicle was towed back to the dealer, but the failure could not be duplicated. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 71,000.

NHTSA #11742649

On three different occasions this car’s engine shuts off on me sometimes at highway speeds. It is terrifying being in the left lane and losing all propulsion and power steering. I have to quickly put the car in park (in the middle of the highway) and then restart the car to go again. When it starts failing it keeps shutting off when we come to a stop in stop and go traffic. It’s like the auto shutoff option shuts off the car abut won’t turn it back on. I took it to DCH Kia of Temecula to get to the bottom of this issue. They are saying because there are no check engine lights and they cannot replicate the problem they can’t do anything and want to return the car to us. We fought that and they started a techline report for engineering to help troubleshooting. Kia customer care was involved, but I was told I had 48 hours to pick my car up as is. Driving this car on long trips is now terrifying for me and my family, if you look online, nationwide Kia tellurides are having this same issue I’ve seen from the 2020 models to 2026. I am not the only person having this issue with a Kia telluride. Something needs to be done NATION WIDE before loss of life happens. I would venture to use the fall of the “Saturn” car company as an example of knowing there’s an issue and not fixing it. I want a solution to this issue and I do not feel that “just trade it in” is an acceptable answer.

NHTSA #11736782

The contact owns a 2022 Kia Telluride. The contact stated that while driving 70 MPH, the steering wheel failed to turn in the intended direction. The auto cold error message was displayed. The contact stated that the steering wheel violently jerked back and forth three times. The vehicle was driven to the shoulder of the road and turned off. The contact stated that while attempting to start the vehicle, the vehicle started. The contact stated that the error code "Auto Cold" was displayed. The vehicle was taken to the dealer; however, the failure was not duplicated. The vehicle remained at the dealer for three weeks for a diagnostic test. The contact stated that in 2024, there was an unknown recall for the front drive shaft. The recall repair was performed in 2024, and the vehicle was inspected at the time and passed the inspection. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 61,000.

NHTSA #11720877

On January 28, 2026, I brought my vehicle to Kia of Fayetteville for brake pads, rotor replacement, and brake fluid service. I paid approximately $900 for these services and was provided a dealership loaner vehicle. Upon entering the loaner vehicle, I discovered a loaded firearm inside the vehicle as I was gathering my items. The firearm’s serial numbers appeared to be scratched off. Law enforcement was immediately notified. No apology, acknowledgment, or remedial action was taken by dealership management. During this incident, the service manager, Alex Prat, acted in an aggressive, disrespectful, and unprofessional manner. Shortly after retrieving my vehicle, my husband who was driving the vehicle experienced a complete loss of braking ability. The vehicle was towed to another authorized Kia dealership, Southern Pines Kia, where technicians documented that multiple brake system components were improperly installed and/or unsecured, including missing or improperly fastened hardware. The vehicle was deemed unsafe to operate.

NHTSA #11716073

The contact owns a 2022 Kia Telluride. The contact stated that while operating the vehicle, the front driver's side seat belt buckle failed latch immediately, causing the seat belt warning to activate. The contact also stated that while driving at an undisclosed speed, the front driver’s side seat belt buckle unlatched unintendedly, causing the seat belt warning to activate. The vehicle was taken to the local dealer, who diagnosed that the seat belt buckle was inoperable and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The manufacturer was notified of the failure. The failure mileage was 68,000.

NHTSA #11714466

My 2022 Kia Telluride is experiencing several serious safety-related defects. The backup camera does not work, the second-row bucket seats fold up on their own while driving, and the electronic parking brake becomes stuck on and will not disengage. The transmission hesitates and shifts harshly, creating a risk during acceleration and lane changes. The engine is consuming oil between changes. The heating and air conditioning stop working when the vehicle is idling at stoplights, and electrical components including the front phone charger and heated passenger seat have failed. The exterior window trim is deteriorating. These issues are ongoing and have not been resolved by Kia. Several of these failures match known defect and recall categories. These create a significant crash and safety risk for my family. I am requesting investigation and manufacturer action.

NHTSA #11702636

2022 Kia Telluride Issues: 1. **Sunroof:** Completely broken. 2. **Exterior Window Moldings:** Fading and discoloration. 3. **Axel Boots:** Need replacement with less than 60,000 miles on the odometer. 4. **Child Lock:** Malfunctioning. -

NHTSA #11698684

We went to get the vehicle serviced at a dealership we did not buy the vehicle from. we told them to knock out the open decals and when we came to pick up the vehicle they said that the recalls had already been completed. We have owned the vehicle for over 2 years and not had any of the completed. They printed off a form with all of the recalls and it showed the dealership we bought the vehicle from in Missouri as completing the recalls. It’s not possible for them to complete them as we have lived in Texas for the last 2 years. I called the dealership multiple times with no reply. I contacted Kia corporate and they were told by the dealership in Missouri that they had completed them on a different vehicle but marked them as complete on ours. After months of not hearing back with a way forward from the dealership or corporate. I do not know where else to go to get this corrected. It is in very poor taste to have to fight to get an error on the dealerships side fixed. The recalls are for safety issues with the vehicle.

NHTSA #11691815

—-Engine problem, I was driving then dash board screen show up the red light of overheat suddenly, I pullover my car to see what’s going on, I don’t see no smoke no fire or leak. Very strange issue. I keep driving the car and everything is fine for the moment. This happens in the other Kia telluride that I had, that’s why I change it for this one 2022. And did the same thing of over heating. I took the car to the dealer but they prefer to sell me this 2022 Kia telluride like I said it did have the same problem. No solution. —-Suspension, the car bounce too much and it hit the floor hard, The car feels like don’t have suspension, I have to change the road system to get comfortable way and dont feel that situation, when I park the car move side to side that happen when a another car pass in certain speed, very uncomfortable situation.

NHTSA #11653028

My wife must use a cushion or pillow to sit in the passenger seat. This causes the Passenger Occupancy Seat Sensor to fail. The seat does not recognize that she is there. The seat belt alert does not chime and the air bag is turned off. I have called KIA and they have no fix. I have talked to the dealer and they have no fix. I can not override the air bag and turn it on manually. We have tried multiple cushions and pillows. It does work without the cushion but this is not an option for her body. How can this be safe??

NHTSA #11710877

Went to the carwash and the sunroof exploded

NHTSA #11637084

My Wife was driving 37mph in town at 1:40pm on a 31* afternoon. When she hears an apparent "gunshot", it was not a gunshot. Her forward sunroof had exploded. She had the sunshade closed thankfully so she did not get hit with any glass. Her vehicle was not hit by anything. The glass looks like it was forced from the inside, blowing the glass outwards. We took her vehicle to our local dealership. They vacuumed up the glass shards, and then taped the remaining glass on both sides, and also covered the roof until repairs can be made. Dealership is filing for warranty, but awaiting approval.

NHTSA #11634825

While driving approximately 40mph down straight roadway without anything around, the vehicle has unexpectedly slammed on the brakes. This has happened four times to date (11/13/24 - 12/25/24). During two of the instance's lights flashed on the dashboard and indicated the front right corner sensor of vehicle. During the other two occurrences, lights flashed on the dashboard and indicated the sensor at the rear right corner of vehicle, even though the vehicle was again traveling forward at approx. 40mph. In each case the brakes were unexpectedly applied very hard for several seconds before returning to normal. There were no other vehicles around and no dirt or other obstructions to the sensors. Vehicle was brought into dealer for diagnostics and was told they could not duplicate the concern. I asked the dealership to contact Kia for support and they refused. I then contacted Kia directly asking for assistance in getting this resolved. They responded that they rely on diagnostics from the dealership and only if the dealership can duplicate the issue will anything be done. This is an extremely dangerous drivability issue of which the dealer agrees. But since they have not witnessed it firsthand, no further action is being taken to attempt to find and/or replace whatever part is malfunctioning. In searching the NHTSA website, I see several complaints where individuals have experienced strikingly similar complaints (NHTSA # 11538285, 11485486, 11457515, 11457281, 11589381) with this vehicle.

NHTSA #11635067

Subject: Urgent Safety Complaint Regarding Recall Delays for My Kia Vehicle Dear National Highway Traffic Safety Administration, I am reaching out to file a safety complaint regarding an ongoing recall issue with my Kia vehicle that has not been addressed, despite multiple attempts to have it resolved. Kia has been aware of the necessary recall for several months, and I recently scheduled an appointment with my local dealership to address these recalls. Unfortunately, the dealership canceled my appointment the day before, citing that they still do not have the necessary parts to complete the repair. This situation has escalated to a serious safety hazard, not only for my family and me but for others around us. Recently, while my vehicle was parked at my child’s school, I experienced a malfunction that caused the vehicle to roll forward while still in park. I was momentarily unaware of the movement and was horrified to realize it almost struck a mother and her child who were exiting the school. This has been a frightening and deeply disappointing experience, and I am concerned about the lack of urgency from Kia in addressing this issue. I urge NHTSA to look into this matter and take action as needed to ensure that Kia expedites the resolution of these critical safety recalls. This issue cannot wait any longer, as it poses a serious risk to public safety. Thank you for your attention to this matter. Sincerely, [XXX] Phone: [XXX] Email: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11625378

The passenger side headlight randomly goes off. An alert comes on on the dashboard to check the headlight. The headlight comes back on randomly. I made several appointments to get it checked, but would be back on again when at the appointment. Diagnostic check showed no issues. The dealer replaced the bulb (not under warranty) and it worked for 1 year. The issue started again, another diagnostic was done, and a found no issues because the headlight came back on. A few weeks later it was out again and the whole lamp assembly was replaced. Not covered by warranty.

NHTSA #11700902

I was rear ended at a high rate of speed, causing me to fly down a 15 foot embankment, where I sideswiped a telephone pole. The latter causing damage to the passenger side front quarter panel. The airbag did not deploy after either impact, nor did the seatbelt stop me from hitting the steering wheel multiple times.

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11634875

The vehicle intermittently fails to shift gears and loses acceleration without warning, creating a serious safety hazard. The problem began in October 2024 when the check-engine light first appeared and has continued since. Despite multiple repair attempts by the Kia dealership—including replacement of the fuel pump, fuel pressure sensors, and ECU—the root cause remains undiagnosed, and the defect persists. When the vehicle was brought back in August 2025, the dealer’s latest recommendation on 9/30/25 was to replace the injector harnesses and front wire assembly, but they cannot guarantee this will resolve the issue.

NHTSA #11701231

Recall repairs done at original dealership(bought new). Passenger seat components that were repaired started an electrical fire under the passenger seat while vehicle was driving. There was a horrible smell inside the car and coming thru the air vents so I turned the ac off and smoke started billowing from under the seat. Immediately pulled over and removed children from car. Vehicle is available. Incident happened with 1 adult 3 kids in car driving. Dealership towed from side of road and kept in service for 54 days(rental provided) and returned with over 1600 new miles on it with no usage of the vehicle told to me and now the affected seat is not connected into the electrical system of the vehicle. Manufacturer did not choose to inspect. No warnings prior.

NHTSA #11635856

The contact owns a 2022 Kia Telluride. The contact stated that while the vehicle was idle and in park(P) in the driveway, the vehicle jerked forward while his wife was in the front driver seat. As the contact's wife checked the gear shifter, the vehicle suddenly accelerated and crashed into the contact's garage door without warning. The garage door, garage rail, and garage opener were all damaged as a result of the crash. The air bags did not deploy upon impact; there were no injuries and a police report was not filed. The manufacturer was immediately notified of the failure and a case was filed. The vehicle was not repaired. The failure mileage was approximately 46,000.

NHTSA #11609976

Infotainment screen is blank most of the time. Backup camera works intermittently. Dealer confirmed head unit failure and stated software updates cannot be performed. Quoted approximately $7,500 for full replacement. Issue has been occurring for over two years, beginning while vehicle was still relatively new. Creates unsafe reversing conditions due to unreliable federally required backup camera display. Dealer classified as infotainment module failure. No recall issued despite widespread owner reports of similar failures.

NHTSA #11714734

The contact owns a 2022 Kia Telluride. The contact stated that the vehicle was previously taken to the local dealer for a software update of the electronic braking system (EBS). The contact stated that while shifted to drive(D), the parking brake warning light illuminated and engaged. The brake light illuminated while reversing. While idling at a stop, the symbol was yellow. There was an abnormal zooming noise detected, and an unknown message was displayed. The contact's son, who is an engineer, informed her that there was a glitch in the system. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 27,258.

NHTSA #11598546

I have an ongoing problem with this vehicle that KIA will not address. My alternator was replaced under warranty last April 30 and when I got it back, the CV boot was leaking grease all over the underside of the car. It took 6 weeks to get them to replace the cv boot (June 14). After that it continued to spray grease all over the underside of my car and there is an increasing amount of vibration going down the road. KIA said they didn't notice a problem when I took it back in August. I took my vehicle to an independent shop who said that at a minimum the front passenger cv axle needed replacement but that there is also a lot of play with the lower center motor mount. KIA did ended up replacing both cv axles when I took it back because at that point I had a significant wobble in the front end when I drive at speeds of 40-60mph. When I got my car back from cv axle replacement the problem was improved but there was still a vibration that has been increasingly worse. I returned my vehicle to KIA in January and they said they don't feel anything in the drive train but that now my tires have worn unevenly and need replacement. My tires were rotated every 6,000 miles and the vibration/wobble contributed to their uneven wear. I have replaced the tires and an alignment has been done, but it the symptoms are worse. Searching through social media and various sources show that the front passenger cv axles are a common issue for the Tellurides and a lot of people are experiencing similar problems. My suspension checks out. All of the obvious things have been ruled out and the required maintenance has been performed. I have had 3 occasions where there was a noise that sounded like something coming apart going down the road. I have concerns that this vehicle is unsafe to drive. I feel that KIA is not going to address this problem unless there is a recall requiring them to do it.

NHTSA #11646482

The contact owns a 2022 Kia Telluride. The contact stated that the tailgate safety sensor failed causing an inadvertent closing of a liftgate on the contact. As a result, the contact received a head concussion and injuries to the neck and spine. The contact received medical attention was the Emergency Room and currently visits a spine interventional pain doctor for neck injections. A dealer was contacted. The manufacturer was made aware of the failure. The failure mileage was 20,000.

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11604224

The LCD screen in the instrument cluster/combimeter went blank. The LCD display contains information such as digital speedometer, gear selection, odometer, distance-to-empty, and all ADAS information. Problem cannot be reproduced. The phenomena has only presented itseld twice (11/2023 and 3/2024). Certified Kia dealer stated there weren't any signs of failure. Service proceeded to perform a hard restart on the system. There is a similar recall for this phenomena (21V577000).

NHTSA #11578658

The contact owns a 2020 Kia Telluride. The contact stated that while reversing, after releasing the brake pedal, the vehicle unintendedly accelerated to 4 MPH. While driving, after releasing the brake pedal, the vehicle independently accelerated. There were no warning lights illuminated. The vehicle was taken to the local dealer, who informed the contact that the vehicle was working as designed. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 38,300.

NHTSA #11614467

About a year ago I was having issues with my windshield wiper fluid working. When I took my car in for repair they told me a rodent had chewed though it and needed to be replace. This was not going to be covered under warranty. About 2 months ago my engine light turned on. I took it to the dealership and they said rodents has chewed through my knock sensor wiring. This is also not covered under warranty. Replacement is going to cost about $900.00. While researching his on online seems like this is a big issues with thousands reporting the same thing. Kia North Austin knows this is a problem and works on many cars a day with these same issues. This needs to be looked into and the car companies need to take responsibility. I never had this issues with my Ford Explorer which I had for 10 years parked in the same spot as my Telluride. I did not have a big rodent problem at my house. Any help would be appreciated.

NHTSA #11572746

Problem started 4-5 months ago and was very intermittent; about 2-3 occurences per month. Problem has become more frequent and become much more severe. When foot is on brake and just coming to stop, engine races to around 6000 rpm. Originally would return to normal rpm in a second or two. Most recent occurences were on Oct. 10 2023, problem manifested 9 times. At stop, engine raced to 6000 rpm and remained there. Some times returned to normal rpm after few seconds, other times shifting to neutral and back to drive caused rpm to normal; 3 times I had to turn off engine. Once when restarting, engine immediately raced back to 6000 rpm and I had to stop engine again. Problem is intermittent so dealer says cannot tackle problem until they can experience problem themselves despite my very detailed description. Vehicle is unsafe to drive. Fortunately so far problem occured with foot on brake pedal so instantly increased brake pressure prevented vehicle from lurching forward into an accident.

NHTSA #11549406

While waiting at signal, there are no visual or audible warnings when seatbelts disengage in the front. I'm concerned this might occur with the rear seats, which is haphazard for little ones in car seats.

NHTSA #11534349

Backed out of my driveway went about 100 yards down the street to make a left turn. I pushed on the brake and every possible warning went off. ABS light, traction control, collision warning, error messages kept coming on. The brake pedal went to the floor. I continued to pump the brakes. Tried to put the transmission into manual mode and downshift. That didn't slow us down. Still continued to pump the brakes. Had to make a right turn or jump the curb into a park. The steering was hard to turn. Pulled the adaptive electric parking brake. Nothing. We were going slightly down hill so had a little speed, but the car came to a rest and the brakes worked. All the other warning lights and error messages kept going off. Turned off the car and started it again. Drove home and it has set there for 3 days. The dealership is always closed on the weekends. I have lost complete trust in this vehicle and in the manufacture.

NHTSA #11527744