Ford F 350 2021: Retiros, Quejas y Ley de Limón de California

The contact owns a 2021 Ford F-350. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle failed to accelerate as intended. The vehicle was driven to the shoulder of the road, where it lost motive power. The message "Reduced Engine Power" was displayed, and the check engine warning light was illuminated. The contact stated that the failure occurred while a fifth wheel RV was hitched to the vehicle. The vehicle was towed to the dealer, where it was diagnosed that the high-pressure fuel pump had failed and needed to be replaced. The vehicle was not repaired. The contact was informed that the manufacturer denied covering the repair under NHTSA Campaign Number: 24V957000 (Fuel System, Diesel) due to a contaminated fuel system; however, the dealer confirmed that the fuel system was not contaminated. The dealer submitted information to the manufacturer advising that the fuel system was not contaminated. Additionally, a case was filed; however, the contact was denied coverage. The failure mileage was approximately 195,000.

NHTSA #11743498

The contact owns a 2021 Ford F-350. The contact stated that while driving approximately 65 MPH, the vehicle lost automotive power. The low power mode warning light was illuminated. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The vehicle was taken to a dealer, where it was diagnosed, and determined that a software update was needed; however, the software update was not available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and stated that there was no estimate for when the remedy would be available. The failure mileage was approximately 125,000.

NHTSA #11720003

The contact owns a 2021 Ford F-350. The contact received a recall letter related to NHTSA Campaign Number: 24V957000 (Fuel System, Diesel). The contact was concerned about being involved in a crash. The local dealer was contacted and confirmed that the software fix was not available. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The contact did not experience a failure.

NHTSA #11704259

Vehicle Safety Complaint – 2021 Ford F-350 I am submitting this complaint regarding a safety-related failure involving my 2021 Ford F-350. While driving under normal conditions, the vehicle suddenly entered “limp mode,” resulting in a significant and immediate loss of power. Approximately 20 miles later, the vehicle completely shut down, leaving me stranded and requiring the truck to be towed to Gene Messer Ford for diagnosis and repair. The failure created a potentially dangerous situation, as the loss of power limited my ability to maintain safe speeds and respond to surrounding traffic conditions. After the vehicle was delivered to the dealership, it took approximately one week for inspection and an additional two weeks to complete repairs. During the repair process, I was informed that newly installed components—including the fuel rail and two fuel injectors—were defective and required replacement again. This raises concerns about whether the root cause of the failure was properly identified and whether contamination or systemic failure within the fuel system was present. I am also aware of widely reported issues involving high-pressure fuel pump (HPFP) failures in Ford diesel engines, which can result in catastrophic damage to the entire fuel system, including injectors, fuel rails, and lines. Given the nature of my vehicle’s failure and the components involved, I am concerned that this incident may be related to a broader, known defect. This type of failure—sudden loss of power followed by complete shutdown—poses a serious safety risk, particularly if it occurs at highway speeds or in high-traffic conditions. I am requesting that this complaint be reviewed as part of a broader investigation into potential fuel system defects in Ford diesel trucks. I believe this issue may warrant further scrutiny and possible recall action to prevent similar incidents.

NHTSA #11735094

I have a fuel leak on this vehicle that seams to coming from fuel filter housing or fuel pump.

NHTSA #11677884

A large fuel leak occurred. The amount of diesel coming out of the top of the fuel filter area was so substantial that I could not drive the vehicle.

NHTSA #11663425

See attached document for complaint.

NHTSA #11703738

The contact owns a 2021 Ford F-350. The contact stated that while driving 65 MPH, the Disconnect/Reconnect message was displayed on the instrument panel. The contact stated that while depressing the brake pedal with the trailer brake control, the system indicated that there was no trailer detected. An independent mechanic was contacted. The vehicle was taken to an independent mechanic to be diagnosed; however, the diagnostic result was unknown. The contact stated that the fuses, wiring harness, and trailer brake control were replaced. The contact related the failure to NHTSA Campaign Number: 22V193000 (ELECTRICAL SYSTEM); however, the VIN was not included in the recall. The manufacturer was notified of the issue and informed the contact that a mechanic would be sent to inspect the vehicle. The failure mileage was 200,000.

NHTSA #11686080

Driver door will not lock or unlock.

NHTSA #11662287

Back up camera screen goes blue when put in reverse. Then after 20 seconds says camera unavailable see dealer. I had dealer repair with a software reset. Worked for about 2 weeks then same symptoms. Noticed Ford has a recall for the same symptoms on other vehicles but for some reason F-350s are not a part of it. Would suspect the truck uses the same camera system as the other ford vehilces under the recall. Ford needs to step up and cover the F-350s

NHTSA #11689583

Sunroof blowout while traveling at highway speeds.

NHTSA #11647118

When my F-350 had only 2,265 miles on it, I was getting in my truck and closed the door. When it closed, the rear window shattered. There was no object that had been thrown at or through the window(no lawn service around that day, etc.). I immediately called the local Ford dealership(Landers Ford in Collierville, TN) and was told that the window would not be covered under warranty. I then called the Ford customer service # on the ford.com website and they stated that this was not a quality issue and that it would not be covered under warranty. It is clear by looking at the picture that the window shattered out as though the pressure in the truck when the door closed caused the break. This occurred on 9/10/21 and I took the truck to Safelite on 9/13/21 to have the window replaced at my own expense.

NHTSA #11432869

Cold side intercooler boost tube cracked due to constant vibration impact from coolant overflow hose routed directly above and on top of it. Part and vehicle is available for inspection. The split in the boost hose caused me to loose power while attempting to merge onto a road, almost being hit by another vehicle. After research there are multiple other instances of complaints of the same thing happening to others and multiple aftermarket manufacturers producing replacement and upgraded parts with references and warnings of the same thing happening for the last 10 years. No warning lamps or symptoms prior to failure. After failure no warning lamps but could hear an audible hiss. The vehicle has not yet been inspected by the dealer or police. I was told by their parts people it is a regular failure and the part costs typically around 200 and they only sold it as a full part and not just the rubber replacement hose althought they are separate parts connected with hose clamps.

NHTSA #11719097

There is an active recall on my truck and it is affecting my ability to use my truck for work purposes. I am not allowed to used a vehicle with an open, active recall, therefore I cannot use my truck. This recall has been active for more than six months and a remedy has not yet been identified. I am posting a complaint to try and speed up the recall process, which if I understand correctly is a software update for the engine to reduce biodiesel buildup in the engine which "could" cause loss of power.

NHTSA #11671821

The Diesel Emission Fluid Injectors are becoming clogged due to crystalized DEF. This causes a DEF error to be generated which de-rates the vehicles speed over time from 50mph to 5 mph over a range of ~50 miles. In remote areas with desert, like where I live this can cause you to be limited to 5 mph on an 80 mph fwy which is incredibly dangerous, especially when some of the more remote fwys are 1-2 lane with limited emergency lanes for nearly 100 miles (especially over bridges). My understanding is this speed limitation is not due to the mechanical operation but is a manufacturer software introduced fault condition, which cannot be bypassed. This also appears to be a wide spread issue as my truck has been sitting in the Ford dealership lot for 2 months waiting for a new injector as these are nationally out of stock. Ford has changed the design on 2023-2024 trucks, the new parts are not forward and backward compatible. Was the design change due to reliability issues with their previous design, should there be a recall for existing customers. P.S. I have a 2021 F350 with less than 15000 miles.

NHTSA #11553939

The contact owns a 2021 Ford F-350. The contact stated that the back over prevention camera had been inoperable since purchasing the vehicle. The contact had received notification of NHTSA Campaign Number: 25V048000 (BACK OVER PREVENTION); however, the VIN tool showed no open recall. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 110,000.

NHTSA #11729638

The contact owns a 2021 Ford F-350. The contact stated that the back over prevention camera failed to function as intended. In addition, an error message indicated that the camera was unavailable and to contact the dealer. The contact stated that the back over prevention camera screen would display a black screen or a black screen with lines. The vehicle was taken to the dealer where it was diagnosed with a failed wiring harness. The contact was informed that the wiring harness needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the dealer several times; however, the failure was not duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 130,312.

NHTSA #11655026

The contact owns a 2021 Ford F-350. The contact stated when the vehicle was shifted into reverse(R), the back-up camera image was blurry. The contact wiped the camera lens; however, the image remained blurry. The contact had not taken the vehicle to a local dealer. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 93,000.

NHTSA #11624786

On 11/19/25 , my 2021 Ford f350 burned to the ground due to engine malfunction. From what the fire department said.

NHTSA #11702165

At this point, nothing has happened. This is a fuel pump, bio-diesel issue that can cause a lack of power which is a safety risk. This recall has been active for 7 months with no remedy listed, but according to Ford Motor Company will require a software update? The remedy is replacing the fuel pump with a DCR valve. Waiting for the truck to breakdown and potentially leading to loss of life should not be acceptable. They know about the issue, they say no remedy, yet they are continuing to manufacture these vehicles. Are they manufacturing new vehicles with a known safety risk or did they fix the problem on newer model vehicles and just stonewalling current owners?

NHTSA #11673419

This truck on a daily basis, shuts down with out warning. Check engine light comes on some time, some times get P0191, P0171 and other codes dealing with fuel rail and pressure. Vehicle had less than 10000 miles when started. Dealer don't know what to do. Shuts off when you are in a turn and leaves you with out steering, and shuts off when coming to a stop sign, or trying to park. Fuel filters have been changed 2 times in 2 months. Truck is not safe to drive because it keeps surging and cutting off. Idle speed varies as much as 250 rpm when sitting still. Now

NHTSA #11440834

Turned on wiper and passenger side wiper assembly only moved an inch. Does not clear windshield. Wiper arm assembly failure, striped. Can not safely drive vehicle. Manufacturer Recall Number 22S26. NHTSA Recall Number 22v087I was told by the dealership that parts are still not available.

NHTSA #11511708

The contact owns a 2021 Ford F-350. The contact received notification of NHTSA Campaign Number 22V250000 (Visibility) however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the vehicle had experienced the failure listed in the recall and the wipers operated erratically while randomly stopping and starting while activated. The failure mileage was 10,000. Parts distribution disconnect.

NHTSA #11486740

VIN [XXX] Ford has not fixed the recall. This is a work truck. The truck has been sitting on the driveway for 6 months as we are not able to drive it with a safety recall. Company policy is that even if it's not a tragic safety recall, they don't allow people to drive the truck. We need Ford to fix this recall ASAP INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA #11491801

The contact owns a 2021 Ford F-350. The contact received notification of NHTSA Campaign Number: 21V536000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA #11511226

I have owned the truck for just over a year and in that time occasionally when I put my vehicle in park and get out of the truck it will start moving without me touching it. It has happen 5 or 6 times within the year. I took it to the dealer and they told me there is nothing they can do unless the could recreate the problem. This situation is extremely dangerous especially if someone is in the way. One time when it did it the truck ran into my camper and broke the tongue jack. Another time it took off and ran into my hunting camp gate severely bending a solid steel gate. I was just about to step in front of the truck to go unlock the gate when it happened. One second longer I would have probably been killed. The last time it happened was about 2 months ago and after putting it in park twice it continued to roll and I had to put my plow down to keep it from moving

NHTSA #11462415

I was recently informed by Ford that my vehicle is subject to a recall (21S31) because the rear axle may deform and detach from the vehicle. I believe the Ford Safety Recall Report (and NHTSA Recall Number) is 21V-536. My concern is related to the proposed remedy. Ford States that additional welds will be applied to the axle. Based on the information provided, I believe this will only mask the symptoms of a failure (detachment of the axle), and not the problem itself (crushing of the axle tubes due to insufficient tube wall thickness). I am a licensed professional engineer, which is to say that I have a basic understanding of material behaviour. With this in mind, I would respectfully ask you to consider the following: 1) Primary: Outright replacement of the defect axle housing with a unit that is manufactured with the "old design" axle tubes. If item 1 above is not chosen, I propose the following alternatives (in combination): A) Requiring replacement of the axle housing if paint loss is observed at the locations where the u-bolts are used to strap the axle to the spring perches. Many people have observed paint loss at this location, and it would indicate deformation of the tubing. B) Warrantying the axle housing for an extended period of time - perhaps 8 years or 100000 miles as was done by Toyota due to the frame defects which affected their pickups. C) Certification by a licensed professional engineer that the proposed remedy (welding the axle) will prevent deformation under rated conditions. I believe this is important because it will require a "person" to certify the adequacy of the repair. My intent in suggesting this is to ensure that the defect is not left in place. Again, the proposed remedy seems only to "mask" the problem. I fear it could result in another "Firestone Situation", where the public is put at unnecessary risk. I greatly appreciate you considering this request.

NHTSA #11427543

On my 21 f350 I had a Gooseneck trailer attached and while it was in the process of getting loaded with no more than 5 thousand pounds. A very loud pop was heard. After a closer inspection I found that both rear leaf spring hanger brackets had split. Causing a safety issue.

NHTSA #11597336

While driving on a road with moderate potholes at about 45 miles per hour the steering wheel and front end stared violently shaking and did not stop until i came to a stop. I took it to the local ford dealership (Cavender Ford) and the service manager said it is a known issue and there is not a real solution for it. Apparently upon research it has been a known issue called Death Wobble. If I had been on a curve, in traffic or in bad weather there would have most certainly been an accident. I was referred to another Ford dealership 90 miles away to see if their more experienced technicians could fix the problem.

NHTSA #11491815

The contact’s boss owns a 2021 Ford F-350. The contact stated that her boss received notification of NHTSA Campaign Number: 22V2500000 (Visibility) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was notified of the issue and confirmed that parts were not yet available. The manufacturer was notified of the issue, but no further assistance was provided. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA #11489820

The contact owns a 2021 Ford F-350. The contact stated while driving 72 MPH, the contact heard an abnormal sound coming from the vehicle. The contact pulled over and upon inspection of the vehicle discovered that the sliding glass on the panoramic sunroof had shattered without incident. As the contact continued driving, the contact could hear the headliner shaking as the glass began flying off the vehicle due to the failure. The contact was forced to pull off the road again and clear all the shattered glass pieces from the top of the vehicle. The contact then took the vehicle to a dealer where he was informed that they would perform an inspection of the vehicle to determine the failure. A week later, the contact was informed by the dealer that the manufacturer had denied repair of the vehicle and that the failure was not a mechanical defect. The vehicle had yet to be repaired and remained in the possession of the dealer. The failure mileage was 6,237. The VIN was not available.

NHTSA #11431201

Electronic tailgate on the 2021 Ford F-350 is opening on its own while driving. Doesn't matter the speed...its happened at 10 mph and at 60 mph. This is a critical issue since it is damaging RVs. My latest occurrence is noted in the Additional Details section, but it has now happened three (3) times since I purchased brand new with 6 miles on it...now has about 10,900 miles. There was a recall on model years 2019 and prior for this very symptom caused by moisture getting into the wiring harness.

NHTSA #11429268

Tailgate has randomly opened twice. Tailgate function on the remote was definitely not being pressed.

NHTSA #11429354

The contact owns a 2021 Ford F-350. The contact stated that while operating the vehicle, the check engine warning light remained illuminated. The vehicle was taken to the local dealer who diagnosed that the DEF Pump, DEF Pump Lines needed, and DEF heater element needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 92,567.

NHTSA #11719362

The contact owns a 2021 Ford F-350. The contact received notifications of NHTSA Campaign Numbers: 25V686000 (Back Over Prevention) and 24V957000 (Fuel System, Diesel); however, the parts to do the recall repairs were not yet available. The contact stated that while driving at an undisclosed speed, the vehicle stalled while the accelerator pedal was depressed. Additionally, while in reverse, the image displayed was blurry. The vehicle was towed to a local dealer; however, the vehicle was not repaired because parts were not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 129,000.

NHTSA #11719967

Driving and abrupt transmission shifting issues.

NHTSA #11718342

Upon starting the vehicle I get precollision not available warning light and hill decent control fault hill assist warning. Service steering and antilock brake brake fault lights. The dealer has looked at it but they said can not duplicate it. The problem is when I am towing my fifth wheel trailer and this happens it shuts down the brake controller for the fifth wheel and it’s VERY hard to stop the truck and trailer

NHTSA #11684074

The contact owns a 2021 Ford F-350. The contact stated that while driving at speeds above 40 MPH and attempting to depress the brake pedal, the vehicle slid and drifted to the right. There was no warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that the grease pins needed to be greased. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 44,000.

NHTSA #11691277

Ongoing Fuel System Failures Related to Recall 24S78 – Request for Escalated Review To Whom It May Concern, My name is [XXX] , and I am the owner of two 2021 Ford F-350 6.7L Power Stroke Diesel trucks, both of which are affected by Recall 24S78 / NHTSA Campaign 24V957 concerning biodiesel deposit accumulation in the fuel system and a pending PCM software update. Vehicle Information: VIN [XXX] VIN [XXX] Both vehicles have already experienced critical failures that directly align with the described defect in the recall, including: Failure of the CP4 high-pressure fuel pump Repeated clogging of the water/fuel separator filter Loss of power, extended crank times, and intermittent no-start conditions These issues occurred prior to the recall remedy being available and have compromised vehicle performance and safety. I am requesting: A full inspection and evaluation of the fuel systems under the scope of Recall 24S78 once the software becomes available. Coverage or reimbursement for repair or replacement of the CP4 pump and related components if found to be caused by biodiesel-related damage as described in the recall. A formal service record entry acknowledging these failures for future reference and eligibility under the recall. Escalation of this issue to a Ford regional service manager, if needed. Given the significant safety risk and the known failure history of the CP4 fuel system, I ask that Ford address this matter thoroughly and beyond a software update, if necessary. Please confirm receipt of this inquiry and advise me on next steps. I can be reached at: Phone: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11663020

My Ford F350 is experiencing the recall deficiency issued by Ford in January 2025 after repeated calls Ford still is unable or unwilling to fix my vehicle. Ford motor company, and the local dealership have told me workarounds could be performed, but they would be done at my expense. A rearview camera on a pick up truck is used often and is a safety hazard when backing up Blind to low objects.

NHTSA #11683825

Death wobble: while driving approximately 60 MPH over a bridge and construction zone over rough pavement the steering oscillated rapidly and I drifted into another lane applied the brakes causing other vehicles to swerve and emergency brake. This occurred [XXX] in Denver Colorado.

NHTSA #11633920

Ford knew there was an issue back in 2021 as they so filed with your agency. Yet waited. Then warranty claims continued. Now, four years later they file as a safety issue, BUT have told me twice in phone calls that I can drive the truck, despite it could shut down on it's own while driving. I tow donated RV trailers to the North Carolina disaster, now I cannot as my dealership advised I not go on long trips. Ford refuses a like loaner, or any loaner at all. This is a Ford issue, not mine nor the dealership and Ford needs to either replace all suspected parts, have a resolution now or proved no charge loaners of like kind to all owners. This approach by Ford is totally unacceptable as they in two phone calls to corporate never once said to not drive the truck and the letter I received said they are not advising we park the truck

NHTSA #11636872

REAR CENTER HIGH MOUNT CAMERA ON CHMSL HAS STOPPED WORKING AFTER ONE YEAR AFTER PURCHASE

NHTSA #11616245

On highway for 2 hours, pulling 5th wheel trailer. Diesel Particulate Filter Cleaning alert went on. Immediately truck lost power, a few other alerts flashed on the screen that couldn't read in time then alert that truck was being put in Neutral which it did. Smoke coming out of engine compartment. Barely coasted to stop on side of freeway. Quickly turned from white smoke to brown. Barely enough time to get me, wife and dog out of the cab before flames coming out of engine. Engine and cab completely burned out.

NHTSA #11604955

The contact owns a 2021 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while depressing the accelerator pedal after stopping, the vehicle was slow to respond. The contact stated that there was several minutes before the vehicle responded as needed. The contact stated that the failure occurred after coming to a full stop. The contact stated there was no warning light illuminated. Additionally, the contact stated that while towing a loaded trailer, the vehicle was losing traction, and the rear end was swaying to the right and to the left. The contact had not taken the vehicle to a dealer to be diagnosed or repaired. The contact stated that during the failure there were several unknown warning lights illuminated. The contact stated that 3 months after purchasing the vehicle, the vehicle experienced brakes failure. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle and determined that all four brake pads and calipers needed to be replaced. The vehicle was repaired; however, the contact stated that the failure recurred while depressing the brake pedal, with an abnormal metal-on-metal sound coming from the brakes. The contact stated that the brakes were independently slowing the vehicle. The failure mileage was approximately 37,000. VIN tool confirms parts not available.

NHTSA #11635852

Driving down the highway at a speed of 70,truck began to vibrate uncontrollably changed lanes. Continue to vibrate uncontrollably in the front of the truck. Pulled safely to side of road. Expected to see flat tires. No flat tires. Turn truck off. Turn truck back on no issues again. I believe this was my first experience with the death wobble.

NHTSA #11565751

The contact owns a 2021 Ford F-350. The contact stated that while entering the vehicle, he observed a puddle of water in the front middle seat which was folded down to use as a cup holder. The contact stated that it had rained the night before but not enough to form a puddle outside around the vehicle or inside the vehicle. The contact stated that the windows were locked securely. The contact became aware that water was dripping from the sunglasses compartment located on the ceiling above the rear-view mirror. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact called the manufacturer and was advised to take the vehicle to a dealer to be diagnosed. The contact was also directed to call the NHTSA Safety Hotline for assistance. The failure mileage was 43,808.

NHTSA #11559781

While driving my 21 F350 my truck would go into limp mode. The climate control stopped working, passenger window stopped, blind spot monitors, along with the mirror. After running forscan it showed every code possible. After an exhaustive search I finally found the main plug under the bed just above the spare tire. The wires inside of the insulation had corroded away to the point it had to be stripped back at least 1/2 inch before getting decent wires that wouldn't crumble when touched. This is a terrible place to put a plug that controls so much.

NHTSA #11596800

On my 21 f350 while towing a 36 foot gooseneck unloaded I noticed a burning wire smell. And I realized I had no more trailer brakes. After diagnosis of the system I found the factory trailer brake controller had melted on the inside. Causing it to loose braking.

NHTSA #11597337

Transmission shifts erratically and sometimes completely doesn’t work. Has left me in traffic with no ability to negotiate vehicle and was almost hit on multiple occasions. There is a recall on vehicles built before 8-20 Kentucky but my vehicle build date is 11-20. The local dealer said nothing they can do until my 11-20 Kentucky build date truck is included. No offer of loaner and truck is NOT SAFE TO DRIVE !!!!! This has left me without.... transportation..... faith in Ford trucks Also. ..... same vehicle has the 7.3 ( Godzilla ). Dead miss in 1 cylinder. Internet information says not common but it has happened on multiple occasions. Stuck lifter which causes loss of oil pressure and scoring of cylinder walls. Local Ford dealership said replace 1 head with remanned parts and new pistons. My F350 has 58000 miles one would think it should last longer than that My thoughts. LEMON LAW Thank you for posting of this message. I have spoken personally with several people who have had the same issues and with similar results. Basically nothing from Ford.

NHTSA #11535328

The contact owns a 2021 Ford F-350 equipped with AMP Tires, Tire Line: Terrain Pro A/TP, Tire Size: P35/12/R24, DOT Number: 04N9MATTW. The contact stated that while driving 70 MPH, the vehicle began to shudder. There was no warning light illuminated. As the vibration continued, the contact began to lose control of the vehicle and the vehicle nearly swayed off the road. The contact was able to pull to shoulder of the highway. Upon inspection of the vehicle, the contact's wife discovered a bulge on the center tread of the front driver's side tire. The contact replaced the tire with a spare tire and drove to the residence. However, the same failure occurred on the front passenger's side tire two weeks later. The contact notified the tire shop who had sold him the tires, and a mechanic was sent to his residence to inspect the tires. The mechanic diagnosed that the failure occurred as both tires' belts popped up. The driver's side tire was replaced but the passenger's tire was not replaced. The tire failure mileage was 9,000. The vehicle failure mileage was 34,000.

NHTSA #11514054

The contact owns a 2021 Ford F-350. The contact received notification of NHTSA Campaign Number: 22V250000 (Visibility) however, the part to do the recall repair was not yet available. The contact stated while driving approximately 30 MPH while it was sleeting, the windshield wipers were engaged on intermittent speed mode; however, the passenger’s side wiper blade stopped functioning. There were no warning lights illuminated. An unknown local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and informed the contact that the parts were on a national back order. The failure mileage was approximately 22,000. Parts distribution disconnect.

NHTSA #11499060

On 7 Aug 2022, I lost cruise control, Navigation function (GPS0 and had problems with other elecrical functions on instrument cluster. I took truck to my local ford dealer; they rand Ford diagnostics on truck and it had 3 module errors listed. They cleared the codes and tried to get me to accept the vehicle. Road tested it and there efforts of clearing the codes did not fix any thing. Brought back in shop on 10 Aug 2022. Diagnostics ran again now narrowed it down to APIM failing 3 times in 2 days. Now deallership says they have to order part from California if they have them in stock. This truck only has 22,000 miles on it. Has had multiple failures of equipment for fuel system listing codes P0191 2 and threee times per day. Dealer will NOT attempt to fix that problem. Just says deal with it.

NHTSA #11478786

Check engine light comes on almost everyday. After at least 5 minutes driving, this trucks engine will shut down with out notice. Usually when making a turn or coming to a stop light. When this happens you loose all steering control. You have to shift to neutral and try and restart. This has caused me to almost rearend a highway patrol vehicle. Very dangerous. I have had this vehicle in to the local Ford dealership on numerous occasions; however they will NOT run diagnostics to see what is happening. Have ad independant mechanic and my scan tool run tests and it always shows code P0191 fuel pressure rail faault. Maintenance is always uptodate ad fuel filters changed by dealer every 5,000 miles. Dealer and MF not honoring warrenty.

NHTSA #11473541

The rear axle repair was not completed and yet they reported that the dealer fixed it. Not true. The truck was taken in for repairs but the dealer was not able to fix it and told me that. They said I will have to get it fixed on my own. The rear axle is a known flaw and was required to repair or replace by the NHTSA. I wonder how many other trucks have also had incomplete repairs and then reported as fixed?

NHTSA #11475328

The contact owns a 2021 Ford F-350 towing a boat. The contact stated while driving 60 mph, applied the brakes however crashed head-on with a 2015 Toyota Scion. The contact stated the rear seats failed to lockdown. The contact had the tools under the seat and was released into the vehicle during the crash. The air bags deployed. The passenger sustained broken ribs, right ankle sprain or fractured, and the seatbelt bruised the chest. The driver struck the steering wheel and sustained chest pains, lower, mid, and upper back issues, and neck injuries. Medical attention was provided for both occupants. The driver of the Toyota succumbed to his/her injuries. A police report was filed. There was no reported fire. The vehicle was towed to an independent lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to NHTSA. The failure mile was approximately 6,600.

Reportado presuntamente: 2 lesiones (según lo reportado a NHTSA). NHTSA #11446844

Transmission lunges forward at times even when putting into park position and starting vehicle. Also, when driving down the road vehicle jerks or bucks and throws you forward. Periodically, there is a complete loss of transmission function then you hear large bang and truck jerks forward. This has been reported to Fenton Ford Camden, NY several times and they cannot seem to find issue and stated if it doesnt duplicate happening when they have vehicle there is nothing they can do about it. This has become a serious safety concern when truck jerks forward when starting and park position and lunges forward in traffic. Thank you for your anticipated, cooperation and help resolving this serious safety matter. Thank You, [XXX] - Vehicle Owner INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11600089

The contact owns a 2021 Ford F-350. The contact stated that while driving at an undisclosed speed, the steering wheel was vibrating. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who informed the contact that the failure was due to the driveshaft. The vehicle was taken to the local dealer who informed the contact that there needs to be weight in the truck. The contact attached a trailer to the vehicle however, the failure still occurred. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 89.

NHTSA #11448243

The contact owns a 2021 Ford F-350. The contact stated that while the vehicle was hauling a trailer with a tractor, the tailgate unintendedly opened, causing damage to the tailgate. The vehicle was taken to the dealer where it was diagnosed that since there was no water leaking under the front passenger's side floor mat, the contact needed to pay out-of-pocket for tailgate replacement. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 23,000.

NHTSA #11463536

My setup: truck is level, trailer is 3/8" drop in front, and hitch ball up leaving one hole open from top. After installing product, ensuring proper setup, there is concern for towing safety, as the bottom of the drawbar drop is ~8-1/2" from ground, with reports from others that this setup has on numerous occasions, caused the drop portion of bar to contact pavement under normal towing conditions across the U.S. This has caused concern for possible catastrophic failure of drawbar drop when towing, believing that the welds on drawbar could become weakened and result in a disconnect of tow vehicle and trailer. I contacted the company, asking if they had plans to offer a 0" (would be an actual 3" length drop per their specs on the 6" and 8" drops) drop, or if they could say how much of the excess could be removed/cut from the drop safely. Their response is that there are no current plans to offer other drops and modifying the drawbar would void warranty. Others on various social media have warned of the drop making contact with pavement during the likes of National and State park entries/exits, as well as intersection transitions, etc.. I continued with my order/install, believing they had possibly installed incorrectly, but now see the concern, and do not want to void warranty, and in turn do not want to have a catastrophic failure that could kill someone..

NHTSA #11422634