Ford Escape 2019: Retiros, Quejas y Ley de Limón de California

2019 Ford Escape 1.5L EcoBoost, VIN [XXX] , built July 2019, 59,300 miles. Experiencing coolant intrusion into cylinder bores — identical defect addressed by Ford Customer Satisfaction Program 21N12 and TSBs 22-2134 and 22-2322. Symptoms: white exhaust smoke at startup, low coolant level with no external leak, no check engine light. Two independent mechanics (Tune Craft Auto Center and Thomas Bros Auto Care, San Diego CA) independently diagnosed coolant intrusion into cylinders and recommend long block replacement per CSP 21N12 procedure. Vehicle build date of July 2019 falls three months after Ford's CSP 21N12 cutoff of April 8, 2019. Ford redesigned this engine block in late 2019 due to the same defect, confirming the defective architecture was still in production through at least July 2019. Ford has denied goodwill coverage citing the build date cutoff. This is the same known manufacturing defect Ford has accepted responsibility for in thousands of other vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11739188

The engine needs to be replaced due to engine leaking coolant into the cylinder. This falls under Fords TSB 22-2229. This is a known issue and manufacturing defect. While driving the check engine light started flashing and the car started overheating.

NHTSA #11738199

My 1.5L EcoBoost engine in my 2019 Ford Escape exhibits a low coolant levels, white exhaust smoke, and runs rough condition with an illuminated malfunction indicator light with only diagnostic trouble codes (DTCs) P0302 and P0316. Ford admits to having this issue as described in a Customer Satisfaction Program 21N12 but is not agreeing to service my vehicle as they state it does not have this issue despite exhibiting all of this symptoms listed in the Satisfaction Program.

NHTSA #11738955

Misfire in 4th cylinder. Replaced spark plugs and emission coils. Recurrent misfire. Diagnostics demonstrated coolant intrusion. Only option for repair is to replace entire engine block and this did not make sense for 7 year old ford escape with 65K miles.

NHTSA #11738924

I am reporting a serious engine safety issue involving coolant intrusion into the engine, resulting in misfires, loss of power, and potential engine failure while driving. My vehicle began experiencing rough starts after sitting overnight, including shaking and hesitation. in a few dayna, the issue worsened and is now accompanied by the following: * Coolant loss requiring refill approximately every other day * Sweet smell of coolant coming from the exhaust * Occasional white smoke from the exhaust on startup * Gurgling sound behind the dashboard during startup * Loss of engine power and hesitation when accelerating * Engine warning message: “Engine Fault – Service Now” Diagnostic Trouble Codes Retrieved: * P0300 – Random/multiple cylinder misfire * P0302 – Cylinder 2 misfire * P0316 – Misfire detected on startup * P0339 – Crankshaft position sensor intermittent * P059F – Active grille shutter malfunction * P06E9 – Engine starter performance issue I brought the vehicle to a repair shop where I was informed that coolant is entering the engine and mixing with the oil. I was also told there is evidence of oil leakage from the turbocharger area. The shop indicated that the engine likely requires replacement due to internal failure, with an estimated repair cost between $10,000 and $15,000. No prior warning of coolant intrusion was given during a recent service visit approximately one week earlier. This issue creates a serious safety risk because the engine may fail unexpectedly while driving. The problem appears to worsen after the vehicle sits, increasing the risk of failure during normal daily use such as commuting or transporting my child.Based on my research, similar issues involving coolant intrusion have been reported in Ford vehicles equipped with the 1.5L EcoBoost engine. This appears to be a known defect that can lead to engine failure without adequate warning.I am requesting that this issue be investigated as a potential safety defect.

NHTSA #11734956

P0217 engine coolant over temp condition, p0316 misfire detected on startup, p2601 coolant pump a control circuit performance stuck off. investigated coolant and found no coolant in reservoir. inspected for leaks and found no leaks. preformed block test on engine and engine failed block test this indicates a failed head gasket. This happened at random, with a full tank of coolant, while driving. There was a heat warning on the dash, I pulled over immediately, and took it into the mechanic the same week. There is a crack in the engine block that is leaking coolant into the cylinders.

NHTSA #11735687

My 2019 Ford Escape overheated, had the vehicle towed. The repair shop said it was coolant intrusion into cylinder 3, first was to replace the head gasket, upon disassembly the mechanic notice gouges in cylinder head. Endurance would not cover the replacement of head gasket or cylinder head. car displayed overheated pull over safely. Not sure if this will be a reoccurring problem.the mechanic said I have the updated design of the engine block . took a month to get the repairs done

NHTSA #11742432

Coolant intrusion on the cylinders due to a manufacturing issue with the Ford Ecoboost 1.5L engine manufactured between 2017-2019. This issue warrants a total engine replacement and the vehicle is currently at a Ford dealership. This can cause total engine failure while driving or even vehicle fires. This issue was acknowledged by Ford in TSB 19-2139 which was published in November of 2019. The symptoms we experienced were hard shuddering, white smoke from exhaust, check engine light, a "service engine now" message on the dashboard.

NHTSA #11740871

My vehicle has stop working because the engine has a crack and coolant is leaking into cylinder block. My vehicle is currently at a Ford dealership and I was directed by my warranty plan. The dealership inspected vehicle and found the issue... Ford warranty does not want to pay for the repair or recall. I would like to open and investigation Thanks

NHTSA #11732181

Car overheats and stalls or shuts down due to engine issues. No prior warning codes.

NHTSA #11734762

Engine failure due to overheating and leaking antifreeze but not a viable leak Misfire cylinder 1 and 3 repeatedly White smoke

NHTSA #11730704

The vehicle experienced coolant intrusion into the engine cylinders related to the 1.5L EcoBoost engine. The issue has been diagnosed as an internal engine failure requiring engine replacement. Symptoms included coolant loss, engine misfires, rough operation, white exhaust smoke, check engine warnings, and intermittent no-start conditions. The vehicle is currently at a Ford dealership and is available for inspection upon request. The vehicle experienced rough engine operation, loss of power, shaking, intermittent starting issues, and engine fault warnings while being driven on public roads. The engine misfires and loss of performance created concern about the vehicle potentially stalling unexpectedly in traffic or during highway driving, which could have increased the risk of an accident. The coolant intrusion also created concerns about sudden engine failure while the vehicle was in operation. Yes. The problem was initially diagnosed by a trusted independent mechanic and later confirmed by a Ford dealership. Both identified coolant intrusion consistent with the known issues associated with the 1.5L EcoBoost engine and Ford Customer Satisfaction Program 21N12. Yes. The vehicle has been inspected by both an independent mechanic and a Ford dealership service department. Ford corporate customer service has also been contacted regarding the issue and an active case has been denied coverage. Yes. Prior to the confirmed failure, the vehicle experienced rough idle, shaking when placed into drive, engine misfires, coolant loss, and intermittent starting issues. The check engine light and “Engine Fault – Service Now” warning message also appeared. Symptoms first became noticeable shortly before diagnosis and progressively worsened over time.

NHTSA #11737398

Coolant intrusion issue causing excessive smoke and coolant leakage. Ford is aware of the issue and provided a service notice but no recall and an extension of coverage but. Y. Vehicle falls beyond that scope due to mileage. The repair solution is a brand new engine on a known engineering flaw costs more than. The worth of the vehicle.

NHTSA #11734030

on March 26, 2026 my engine light turned on and I’m getting in misfire on my car, and all of a sudden I can’t run more 40 mph or my car start shaking. I went to AutoZone to get it checked and the the result is, they are needing to replace the cylinder 3 coil pack or spark plugs. I went to Ford on March 31, 2026 trying to have my spark plug replaced and was told that my engine has coolant intrusion and that the long block needs to be replaced and the head gasket is blown they recommended me to have the engine replaced, and it will cost me more than 8 grand. That they was so unexpected for me because I’m not planning to get a new vehicle and my car is only more than six years old with 78,000 miles on it. I called Ford and asked them if I could get help with the situation and I was told that the certain VIN number of my car was not affected by the recalls that they have for the same model and the same year. If anyone is reading this don’t buy ford at all cost.

NHTSA #11732774

I have a 2019 Escape with only 33k miles. The check engine light came on for P0304cyl 4 misfire and on/off again rough idle. Ford service had technician pulled plug on cylinder four and used a borescope and found coolant leaking into engine. Ford has a known TSB for coolant intrusion on this particular model and vin and manufacturing date. Ford refuses to help me with cost to replace the long block of the engine at a cost of $14000. The blue book is 10k. This appears to be a very common issue and needs a recall immediately. This is completely wrong of Ford to do this to customer fully knowing there is a problem but won't pay to fix it.

NHTSA #11727294

Coolant leaking into go engine. Causing erosion. Only 40,000 miles and been without car for 3 months now. Upon research this is a known issue. Confused why it wasn’t recalled with the number of people who appear to have been impacted.

NHTSA #11739760

Coolant leak via head gasket failure on cylinder number 3. Trouble light (check engine) reported on the dashboard.

NHTSA #11728660

Ford at Jim Ellis dealership in [XXX] [XXX] look at my car last Thursday and gave me only one code P0304 which means tune up but texted me that my car need $8000 of labor and $6k of a new engine, without an explanation. Prior too the vin they pulled up showed Cust satisfaction 21N12 said yes a recall when the rep saw it. However, even expired 2022 another paragraph states If exceed mileage 84000 and 7 yrs ..that THIS IS NO COST. Yet ford still stating not related to Cust sat...engine fire, exhaust low coolant smoke rides rough which is what my car did last Saturday 3/14/26. To text me 15k pay or not with a conversation as to why but invoiced only one code about a tune up yet told the Tow guy my coolant going into the engine but didn't advise me of that same information is highly unprofessional this is a risk and unsafe I have seen 3 other complaints 2025 2022 same issues and on kbb. The rep said that depends on manuf well it showed [XXX] same manuf as Cust satisfaction. This should be listed as a new recall many more complaints on kbb.....I will notify FTC as I am also a govt worker its unruly unsafe and for Ford to act unworthy with no integrity is an outrage. I called there corp and complained as well. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11726862

We just bought this vehicle 3 weeks ago, paid sales tax and first car payment. The check engine light came on for P0304cyl 4 misfire, notice white smoke blowing from exhaust and low coolant level. Had technician pull plug four and used a boriscope and found coolant leaking into engine. Ford has a known TSB for coolant intrusion on this particular model and vin and manufacturing date. Ford refuses to help me with cost to replace the long block of the engine at a cost of $7000, out of my pocket. I have not even put a thousand miles on this car. This is completely wrong of Ford to do this to customer fully knowing there is a problem but won't pay to fix it.

NHTSA #11726813

Coolant intrusion into cylinder

NHTSA #11733542

Ford dealership in Ferndale,MI told me I needed a new engine February 2025 which was covered under warranty. they told me they had to replace my engine. I serviced car at same dealership for numerous oils changes engine light was in but they told me that it was codes for something else that they reported on my papers. My Vehicle started running hard in January 2026 asked them about why it was running hard when driving was not able to get any answers according to them they were unsure of the reason then February 2026 my engine went out while driving again and they told me I needed another new engine recent search says there is a class action suit with Capstone Law APC, along with co-counsel, is litigating a consolidated class action lawsuit The lawsuit alleges, among other things, that Ford Motor Company: failed to disclose that these vehicles have a defect that causes coolant to leak into the engine’s cylinders, which can cause corrosion, oil dilution and contamination, and engine failure; and failed to disclose these defects create a safety risk, because the lack of coolant created by the leaks causes overheating and can result in the cylinder head cracking, total engine failure, and/or engine fires. My engine is completely out and now they are telling me that I have to pay out of pocket for a new engine when this was a safety issue while driving on the road with a engine that was said to have been replaced

NHTSA #11740307

I purchased the vehicle on February 10, 2026, at which time it had approximately 31,000 miles. Within one week, the check engine light illuminated. I brought the vehicle to a repair shop, where diagnostic testing identified a fault related to spark plug #2. Further inspection revealed that the engine was losing coolant. According to the technician, coolant intrusion into the cylinder caused the spark plug to seize in the cylinder head, resulting in a misfire in cylinder #2. The spark plug was removed, and a pressure test of the cooling system was performed. Using a borescope, the technician observed coolant entering the cylinder and dripping down the cylinder wall. Based on these findings, the shop determined that the engine requires a short block replacement to correct the issue.

NHTSA #11733096

I am experience coolant intrusion into cylinder 3 causing the check engine light to come on, when.checked on obd2 system shows a misfire on cylinder 3, multiple checks by service centers all diagnose the coolant intrusion defect on the 2.0 ecoboost engine requiring a long block replacement

NHTSA #11722668

Waterpump pulley/ waterpump, yes it's available for inspection. I lost power and a message came up on the screen to shut off the vehicle there was a engine failure , overheating. No, I have not had it confirmed by a dealer yet. No it has not been inspected by any person. I started hearing a noise about a month ago and I was going to make an appointment the same week it happened to break down on me. I have a disabled daughter and I'm thankful I just took her home because of the extreme cold weather. I was outside for over an hour waiting to get suv towed.

NHTSA #11713249

I have a coolant intrusion in my 2019 Ford Escape. It idles roughly, there’s thick sweet smelling white smoke coming from the exhaust and when we refilled the coolant to max and started it once, the coolant level was immediately at the minimum. We have not turned it on or driven it since we found this out. There is a customer satisfaction program for 2019 Ford Escapes for Powertrain Control Module reprogramming (Campaign 19B37) that then makes the vehicle eligible for a one time repair under campaign 21N12. This campaign fixes exactly what is wrong with my vehicle. It applies to vehicles built in Louisville until April 2019. My vehicle was built in Louisville in May 2019. The dealership told me to call Ford Customer Relations/Recall Team to explain the situation and get a goodwill repair since my vehicle is having the exact same issues as the vehicles built at the same plant the month before. The recall team refused to provide me with a goodwill repair and also refused to give me information on when or if at all my case will be reviewed by the appropriate team. I asked to be able to contact the team handling my review by phone. They said I could only communicate with them by physical mail. This is unacceptable and I believe that Ford caused an unsafe situation for countless drivers for years by not including 2019 Ford Escapes built in Louisville in May 2019 in their customer satisfaction program and are still refusing to do so.

NHTSA #11711177

Coolant intrusion into the engine potentially causing engine failure. A cracked cylinder head was allowing coolant to leak into one of the 4 cylinders.

NHTSA #11708329

I am submitting this complaint to formally document a known engine defect affecting my 2019 Ford Escape prior to initiating direct contact with Ford Motor Company. My vehicle has recently been diagnosed with a cracked engine block, a defect that is well documented for this model and engine type. I understand that Ford has acknowledged this issue and established a repair or replacement program; however, I have been informed that eligibility is limited to vehicles manufactured on or before April 2019. My vehicle’s manufacture date reportedly falls just one day after this cutoff. Given the nature of this defect, specifically that it is a manufacturing flaw in the engine block material itself. The one-day exclusion appears arbitrary and unrelated to the actual failure mechanism. The failure occurred under normal use, and there was no warning or misuse that would account for the damage. This strongly suggests the issue is consistent with the known defect affecting other vehicles within the same production period. I am requesting that this complaint be officially logged to document the defect, the timing discrepancy, and the resulting financial and safety concerns. My intent is to ensure there is a formal record of this issue before I proceed with further action or correspondence with Ford Motor Company. Please confirm receipt of this complaint and advise if any additional documentation is required.

NHTSA #11710879

I went to get my spark plugs changed as maintenance on my vehicle. The plugs on both the second and third cylinder were very tight and breaking with residue all over the plugs. The shop I took my car to had to send it to another shop in order to get the plugs put back into the engine. Since then it sounds like a blown muffler whenever I start my car and I have a check engine light with a third cylinder misfire. I have also been having white smoke whenever I start my car with a cool engine. I tried seeing about getting the car fixed but mechanics don’t want to touch my car because they said it will not fix the issue because this is a manufacturer defect caused by coolant intrusion. Now I have to sell my car and. I am under because I still owe 6340.95 on my Loan. The most I can get for it is $3300 through Carvana. The car has less 96,092 miles.

NHTSA #11707417

engine misfire, white smoke, loss of power while driving. Due to Coolant intrusion which could lead to dangerous situations, such as an unexpected stall in traffic or an engine compartment fire. Ford had offered a campaign thro' CSP 21N12 program but for a short time in 2022 which excluded many vehicles for people whose did have issues at that time.

NHTSA #11706667

On returning from vacation, the check engine light came on. Pulled vehicle into auto parts store for a computer diagnosis's, computer said spark plug issue. Took the vehicle next day to my technician for diagnosis's and repair. The mechanic had difficulty removing the Number two(2) spark plug. After using light and scope to examine the interior of the number two(2) cylinder,traces of coolant was found inside to cylinder. The mechanic researched it online and said there was a problem with the 2000 teen model Ford Escapes with a crack in the engine block. I took the car three weeks later to the Ford dealership where the vehicle was purchased from because the SERVICE ENGINE LIGHT NOW came on. I was told there was nothing they could do and I was asked to leave. One of the other personnel that worked at the dealership overheard our conversation and stepped in and told his coworker that even though we were over on the recall mileage for this issue we were still inside of the seven year window for the recall. I was given the Ford Customer Service toll free number to report this issue, and was told not to tell anyone where or how I got that number and would you be so nice and leave and take the vehicle with you.

NHTSA #11697216

2019 Ford Escape 1.5L EcoBoost. 74,000 miles. Check engine light came on out of nowhere. Had auto shop read the code and it was a misfire of cylinder 3 and needed ignition coil and spark plug replaced. A few days later the message "High Engine Temperature, Stop Safely" came on and the engine temperature shot up to High. Pulled over and let it cool down. Started driving it again and it shot back up to High again. Took the car to a mechanic who did a compression test and said that the coolant ran green which meant the coolant is infiltrating the cylinders. Per another mechanic this is a known problem with 2019 Ford Escapes that the engine is a open deck block that allows the cylinders to move and be unstable. Ford knows this problem but never put a recall out!

NHTSA #11696341

COOLANT WATER INTRUSION INTO THE CYLINDER BLOCK. COOLANT INTRUSION DUE TO MANUFACTURE DEFAULT. LONG BLOCK NECESSARY TO COMPLETE REPAIR. REPAIR IS NOT UNDER WARRANTY. CHECK ENGINE LIGHT APPEARED. OBD WARNING CODE P303 SUGGESTED CYLINDER 3 MISFIRE. COOLANT LEVEL WAS NOTED TO BE LOW. VEHICLE WAS THEN TAKEN TO THE FORD DEALERSHIP PROMPLY. AFTER DEALER INSPECTION COOLANT WATER INTRUSION WAS FOUND. IF THIS PROBLEM WAS NOT DIAGNOSED EARLY IT COULD'VE CAUSED ENGINE FAILURE WHILE DRIVING.

NHTSA #11698428

The engine recall was warrenteed up to 80,000 miles. l bought the vehicle with 75,000 miles. Sure enough l had the defective engine and it blew out at 113,000 miles. l ended up getting a personal loan as the engine was $10,000. I'm upset because Ford can set what ever mileage they want to establish a warranty expiration period. Hope you can help

NHTSA #11707069

I am reporting a safety-related engine defect on my 2019 Ford Escape (2.0L EcoBoost). On September 23, 2025, at 72,233 miles, the engine failed due to coolant leaking into the combustion chamber (cylinder #3). Ford’s own dealer confirmed coolant intrusion and referenced Ford TSB 22-2239. This issue is associated with known EcoBoost coolant-intrusion failures documented in multiple Ford bulletins and class-action suits. The engine failure required a complete long-block replacement costing $8,644.38. Ford denied assistance despite the failure occurring within the extended 7-year/84,000-mile coverage window under Customer Satisfaction Program 21N12. Coolant intrusion can cause sudden engine failure, stalling, loss of power, or inability to accelerate, creating a hazardous driving condition. I request NHTSA review this defect as part of the widespread EcoBoost coolant-intrusion problem. Owner: [XXX] , [XXX] . VIN: [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11704263

The engine failed at 51,000 miles due to coolant intrusion. The check engine light came on and a code scan revealed a cylinder 3 misfire. The dealership ran diagnostics and the pressure test, which determined the engine failed.

NHTSA #11687790

My Escape has about 73,000 miles on it and the check engine light went off last week when I started the car. The car itself was shaking in a very strange way. I brought it to a repair shop and they said there was coolant leaking into one of the cylinders. This was going to require a full engine replacement at the cost of about $9,000. They reached out to Ford and there was a pre-existing set of instructions on how to deal with this issue, so it was clear this is known to Ford on this model of car. If it was my vehicle only, I'd say I'd cut my losses and just get a new car, but I've read dozens of stories online about this issue and saw a temporary recall from back in 2022 for this exact problem. There are also many class action lawsuits active that name my make and model and the same coolant issues. I am attempting to escalate this with Ford as the technician said I maybe have two weeks before the engine fails altogether, which is obviously a huge danger to me and my family. Hoping Ford can be forced to do the right thing and issue a recall. I am in a tough spot where my family has a single car and either need to pay the large repair bill or pay-off an equivalent sized loan in order to trade in this car (with these known issues) for a new vehicle in the next few days.

NHTSA #11687990

According to my local ford dealership, the rattling/clicking sound in my engine is due to a faulty water pump which is apparently a known problem for a 2019 ford escape. I did not even have a check engine light appear and just happened to have my vehicle there for a different reason. This is an extensive and costly fix that should not be an issue with a 6 year old vehicle with 77k miles. With this being a common/known fault for EcoSport engines, it affects the safety of my engine and all passengers and other drivers.

NHTSA #11685375

My 2019 has the coolant intrusion in cylinder 2 issue. The dealership recommended a long block replacement and quoted me $10,850 to do this. It is a safety concern and I was advised not to drive it. The engine could seize if not repaired and put myself and others in danger. The extended warranty I had purchased expired a couple weeks before this happened. I understand there a many people experiencing the same issue and that there are some class action lawsuits regarding this as well. That may take years to resolve and in the end it won’t make us whole though. I’m submitting this to you today hoping this issue will be considered for a recall. Thank you for any help with this matter and could I trouble you to please advise me as to what if anything I can do regarding this matter? Kind Regards, Nancy York

NHTSA #11690864

Vehicle: 2019 Ford Escape, VIN: [XXX] Issue: Coolant intrusion into engine cylinders, consistent with TSB 19-2346. Symptoms include coolant loss, white smoke, misfires, and rough idle. Safety Concern: Potential for engine failure or fire risk due to overheating. Manufacturer Response: No recall issued; seeking investigation and formal recall consideration. Related Litigation: [XXX] v. Ford Motor Company, U.S. District Court, Eastern District of California. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11686728

The flex plate is cracked. Possible missing dowels.

NHTSA #11686328

The Ford dealer just advised that I need an entire new engine at a cost of $10,000 for a crack in the block, causing coolant to leak into cylinder three, potentially causing critical failure and danger while driving the vehicle. This is a known defect in this motor, which the manufacturer/Ford refuses to address.

NHTSA #11682643

The contact owns a 2019 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle shuddered abnormally. The contact believed that a fuel cleaner needed to be added to the fuel tank. The contact stated that the engine revved abnormally. While at a stoplight, the vehicle failed to drive forward and stalled. The contact stated that the axle and turbocharger had been repaired prior to the failure. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 104,000.

NHTSA #11680879

Coolant in cylinder causing overheating, misfiring of cylinder 3 and cracked engine block

NHTSA #11680941

at 96800 upon start up there was a cloud of white smoke and a check engine light. It was taken to the local ford dealer for diagnosis. Code was P303 and P316 indicating a misfire. the car was found to have coolant intrusion in cylinder 3 and would need a long block replacement. reference used was TSB 22-2229. This type of engine failure is know to ford due to design of coolant channels between cylinders. This could have cause sudden engine failure while drive resulting in an accident and injury or engine fire due to insufficient cooling causing loss of property and/or injury.

NHTSA #11682573

Coolant is leaking and causing the cylinders to misfire. The check engine light is illuminated. This problem has been confirmed by the service department at my local Ford dealership. The repair is to replace the short block with an updated part and estimated cost is $5000-6000. My 2019 Ford Escape has only 79,000 miles on it and has been well-maintained. This leakage will definitely put myself and others at risk when my vehicle breaks down. The check engine light appeared on Thursday, July 31st. I brought the car immediately to the dealership. Since I did not have a scheduled appointment, they did a quick diagnostic and reset to see if it would happen again. The check engine light came back on the next day. I brought it in for a service appointment today after returning from being out of town last week.

NHTSA #11679803

There's currently a coolant intrusion issue with my 2019 Ford escape and I see that there was a recall on this for all Ford escapes from the years of 2017 through 2019 and I wanted to see if this will be covered for repairs

NHTSA #11679924

Leaked coolant into second cylinder caused engine failure. This is a known issue with this model. No prior warnings, check engine light came on as the engine lost power. Risk of total engine failure.

NHTSA #11681529

The vehicle is suffering from an engine failure. It has a check engine light DTC PO303 with a heavy misfire. This causes to engine to lose power at times preventing proper acceleration which could lead to an accident. Ford has a technical service bulletin [TSB 22-2229 ] that describes the failure and the required repair. The problem is a design issue, but Ford is not covering any out of warranty repairs.

NHTSA #11682170

coolent intrusion int the motor - no notice given regarding a previous recall

NHTSA #11677799

2019 Ford escape titanium with 62000 miles.check engine light came on once and went off- took to dealer and was told the coolant was going into engine. Had an extended warranty to 75000 miles because of issue I had when car was brand new-brake release switch. Now I am told that warranty expired last year even though there is not 75000 on it yet. They are telling me I need a 8700 dollar new engine. I am [XXX] and this car is like new. Please help! I bought this brand new and only put about 10000 a year on it INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11676860

Coolant leak into the engine.

NHTSA #11678155

My Ford Escape was driving as usual, but as I was traveling on a down ramp in a left turning lane, the engine overheated abruptly and serious audible and visual alerts appeared on the screen. I was in heavy traffic and was forced to pull over quickly into the right turning lane. This could have easily caused an accident because all of a sudden, the Escape started stalling and would hardly move. It was terrifying, and I was barely able to maneuver it into a nearby parking lot. That night, it was towed to a Ford dealership that inspected it and now says that I need a new engine because the engine block is cracked.

NHTSA #11675142

My 2019 Ford Escape 2.0 Titanium has a KNOWN coolant intrusion issue where it is leaking into the engine. This began as my car shook on startup, then the check engine light would come on. Drove it a little ways, check engine turned off. Took my car into the repair shop and they looked up the stored code and it was P0301 cylinder #1 misfire detected and P0316 misfire detected on start up first 1,000 revolutions. Car seemed ok, so took it back. Happened again, 2x, check engine light on, off, then on again when I brought it back in. Same codes again. Mechanic said coolant low, removed cylinder #1 spark plug and sent camera into cylinder, found coolant leaking into cylinder. They said I need an entirely new engine, as this has been occurring a LOT with these EcoBoost vehicles. Ford had an open recall but only acknowledged a small amount of vehicles, mine not one of them, and there is currently a lawsuit against Ford because this has been happening to so many people. We are getting nowhere with Ford, they won't acknowledge the issue on the EcoBoost and now we have to come up with nearly $10k to replace an entire engine when the car isn't even worth $8k. PLEASE LOOK INTO THIS! Some people are having this issue at 50K Miles!!! This is not ok!!

NHTSA #11683883

The car had a rough idle (only for the first few minutes) for one day before the engine light came on. The car was taken to the dealership on the third day (less than 20mi of driving between the light coming on and the car being inspected). According to their scans, my 2.0L engine is experiencing water (coolant) intrusion into the clyinders (after only 5 years of service). The Ford technician said it is TSB 22-2229 (a known issue since 2019 TSB 19-2172). There are currently no NHTSA Customer Satisfaction Programs or recalls for this TSB, which is astonishing, as there is one for the 1.5L engine made in the same plant AND Ford completely redesigned the engine because they know it is so bad. The fix is to completely replace the engine ($10,000-$15,000). The danger is that the manufacturer knew there was risk of water intrusion, which can crack the block…this could leave the vehicle in a dangerous situation if driving at highway speeds or in heavy traffic.

NHTSA #11674047

My engine had a coolant leak a few years ago (2021) and needed a complete engine replacement since the car would no longer run. Since it was under warranty then it was replaced. However, the engine once again has had a major issue with the engine bearing and needs another full replacement and will no longer run. Many people are struggling with needing to get full engine replacements on Ford Escapes. There are Ford retailers keeping stocks of Ford Escape engines in preparation for these engine replacements, but Ford has refused to offer any assistance for this known issue. Requiring a 2nd full engine replacement at the value of the car itself is absurd. I received a warning message on my car, but when I took it in to have the issue assessed - it was notified as a minor gas cap issue.

NHTSA #11673977

Coolant intrusion issue caused by a defect from Ford. They are refusing to fix the issue.

NHTSA #11675507

The number 2 cylinder is cracked allowing coolant to leak into the combustion side of the engine. my dealer is asking for $15,000 to replace the engine.

NHTSA #11670727

Consumers claim the engines in their Ford vehicles overheat due to an internal coolant / antifreeze leak that allows coolant to enter into the cylinders of the engine. In many cases, the defect is alleged to have caused total engine failure and to require replacement of the engine block.

NHTSA #11674012

The failed component is the coolant leaking into cyl 4 TSB 22-2229 which has been a problem with this model in the 1.5 L turbo before. This model is the 2.0L turbo but having the same problem. According to the dealership, "This is the entire process need to either rebuild or replace the vehicle's engine. This is a process needed when the vehicle's engine is in need of serious repair." Reasoning according to the dealer: "Without replacing or rebuilding a damaged engine, the car will not be able to function and will be left useless." This car has only 46,391 miles on it for 2019 and has been meticulously taken care of since it's purchase in Aug 2021 as a used vehicle from the dealership. After an oil change was completed on the vehicle at 46,300 miles, the check engine light came on and the vehicle was taken into the dealership for it to be assessed. That's when it was found to be cyl 4 that was the problem.

NHTSA #11670470

The coolant kept getting low. I brought it to the Ford dealership I bought it less than a year ago. They ran some tests and said the coolant is leaking and the engine needs to be replaced. I'm waiting for them to hear back from Ford to see if it's under the extended warranty.

NHTSA #11670944

Last year my vehicle has a recall for the Ecoboost. Ford in Boonville, IN. replaced engine. I am again having a foggy windshield, sweet smell, dizziness, and I can taste the coolant. I sent email to Ford motor company but haven't received a response yet. I left a message for the service department at dealership as well. I'm waiting for someone to get back to me. It's my understanding that if the same problem returns or is related to the recall it will have to be fixed.

NHTSA #11670419

Presence of coolant in the engine cylinders, Ford has it as a known issue but won't issue a full recall. Causing cylinder misfires. Needs new engine. Ford design flaw!

NHTSA #11669775

the night prior to my car breaking down I Did notice the car began to lose horsepower to move just a little bit not to much to worry about than the check engine light did appear on dash that night. Code popped up for misfire in cylinder 1. SO changed the spark plugs and light went off , next day light was on and smoke began coming out of the tailpipe.

NHTSA #11675813

The vehicle's engine shutdown while driving on the highway, forcing me to pull to shoulder in traffic. We had it towed to Ford and were advised that the engine was blown due to coolant intrusion into the cylinders. We're told the engine is totaled and they quoted us almost $15,000 USD for the repairs. There is a know recall notice for this exact issue, however we were told it only covers up 85,000 miles and our vehicle has 94,000 miles. We had brought it to a Ford dealership for an oil change 6 months prior and they didn't say anything about it. The dealership/manufacturer refuses any accountability, and offered us $1,500 loyalty discount if we purchased a new Ford vehicle from them. The SUV was in like new condition prior the engine failure (ie. no damage).

NHTSA #11676778

White smoke coming out of exhaust smelled of antifreeze. Took to Ford dealer in Eagle River, Wisconsin: Dealer found coolant in #1 cylinder and wrote on receipt - headgasket block failure, recommend replacing engine. Service writer said this is due to a defect in engine block being a slit machined in block between cylinders by Ford. Dealer quote for engine replacement was $9500.

NHTSA #11677305

In June 2025 vehicle had no coolant in tank, refilled and monitored, July 2025 check engine light appeared and code for cylinder 3 misfire, Aug 2025 vehicle went to local certified automotive repair company who began running diagnostics, replaced spark plug and coil #3. After replacement was asked to drive, less than 10 miles check engine came back on with same code. Mechanic kept working on vehicle until December/January 2026 when it was determined and confirmed that there is a coolant leak, running a check engine with malfunction of cylinder 3 inevitably leading to full engine failure. Was quoted February 2026 by another local certified automotive repair company over $8,000 for the removal and install of a new engine.

NHTSA #11726228

The contact owns a 2019 Ford Escape. The contact stated that while driving at various speeds, the vehicle shuddered abnormally, and there was white smoke coming from the exhaust pipes. In addition, the contact became aware of an abnormal coolant consumption. The check engine warning light was occasionally illuminated. The vehicle was taken to a local dealer, where it was diagnosed with OP code: 62. The contact was informed that the short block needed to be replaced. The local dealer informed the contact that the failure was related to TSB: 19-2208; however, the VIN was not included. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 117,645.

NHTSA #11666736

The contact owns a 2019 Ford Escape. The contact stated while driving 45 MPH, the contact heard a rumbling sound coming from the engine, causing the vehicle to shake abnormally. The check engine warning light was illuminated. The contact stated that an independent mechanic was contacted. The vehicle was taken to an independent mechanic and was diagnosed with engine failure, and that the cam shaft was damaged. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 130,000.

NHTSA #11669782

On or about June 1, 2025, the vehicle began losing coolant without a visible leak. Took the vehicle to dealer for a diagnosis. Dealer claimed than a coolant hose was bad and required an $1100 repair. I reported to the dealer the low coolant, water in the oil and white smoke at start up but they dismissed the complaint. Stated they would need the $1100 repair done before any other diagnosis could completed. July 1, 2025, after consulting Ford corporate directly, they are "looking" into my concern. No offer of repairs, at all.

NHTSA #11670502

I have Engine coolant intrusion into the the cylinder heads. White smoke during start up and loss of engine coolant. Also is stuttering during start up with check engine lights..

NHTSA #11697814

Replaced engine blowing a lot of smoke out of the exhaust when starting engine and it didn't do that before the new remanufacured engine was installed.

NHTSA #11679749

The contact owns a 2019 Ford Escape. The contact stated that while driving at approximately 50 MPH, the accelerator pedal was depressed; however, the vehicle lost motive power with the engine revving abnormally. The contact pulled over to the side of the road and restarted the vehicle however, after driving 100-feet, the failure reoccurred. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 80,133.

NHTSA #11663077

Vehicle indicates a misfire on cylinder number 2 . Diagnosis of the issue appoint to a leak of coolant into the cylinder bore.

NHTSA #11664432

The contact owns a 2019 Ford Escape. The contact stated that upon starting the vehicle, the engine was idling abnormally rough, prompting the contact to discontinue driving the vehicle. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that coolant intrusion into various cylinders had resulted in damage to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to the Customer Satisfaction Program: 21N12. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 57,000.

NHTSA #11692344

The contact owns a 2019 Ford Escape. The contact stated that while depressing the accelerator pedal, there was an abnormally loud sound coming from the engine. An Independent mechanic was contacted. The vehicle was taken to an independent mechanic where it was diagnosed with coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified on the failure. The approximate failure mileage was 130,000.

NHTSA #11691895

The contact owns a 2019 Ford Escape. The contact stated that the vehicle experienced an abnormal rattling sound on cold starts and while idling. The vehicle was taken to Midas Service Center, where it was diagnosed that the engine turbo had failed and needed to be replaced. The vehicle was not repaired. The local dealer was not contacted. The manufacturer was notified of the failure but no assistance was provided. The failure mileage was 101,000.

NHTSA #11677219

The contact’s daughter owns a 2019 Ford Escape. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an Auto Parts Store, where it was diagnosed with ignition coil failure. The vehicle was then taken to the residence, where a family friend replaced the ignition coils; however, the check engine warning light was illuminated, and the message "Engine Fault - Coolant" was displayed while driving the following day. The vehicle was steered to the side of the road and was turned off. The vehicle was then taken to a dealer, where it was diagnosed with coolant intrusion into the engine, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 95,800.

NHTSA #11678713

The contact owns a 2019 Ford Escape. The contact stated that upon starting the vehicle, the check engine warning light illuminated. The vehicle was taken to a dealer, where it was diagnosed with coolant intrusion in cylinder #3. The vehicle was diagnosed with engine failure, and the contact was provided an estimate for the repair. The manufacturer was notified of the failure and offered to cover a portion of the cost of the repair. The vehicle was not repaired and remained at the dealer. The failure mileage was approximately 75,000.

NHTSA #11678225

The contact owns a 2019 Ford Escape. The contact stated while driving 15 MPH, the vehicle started to overheat and lost motive power. A message stating that the vehicle was overheating was displayed. The check engine warning light was illuminated. The temperature gauge increased to hot(H). The contact was able to pull to the side of the road and turned on the hazard lights. The local dealer was notified of the failure, and an appointment was scheduled for diagnostic testing. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 74,636.

NHTSA #11674286

The contact owns a 2019 Ford Escape. The contact stated while driving 3 MPH, the vehicle started to sputter. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic and the contact was made aware of an undisclosed recall. The mechanic determined that the short block needed to be replaced and there was coolant intrusion into the engine. The vehicle was taken to the local dealer, where it was diagnosed and determined that there was a misfire and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 102,000.

NHTSA #11672314

The contact owns a 2019 Ford Escape. The contact stated that while his wife was driving at unknown speeds, the vehicle started sputtering. The contact stated that the check engine warning light was illuminated. The contact stated that the failure was related to Customer Satisfaction Program: 21N12. The vehicle was taken to an independent mechanic who determined that there was coolant leaking into the cylinders and there was a blown head gasket. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and informed the contact that there was no warranty coverage on the vehicle. The failure mileage was approximately 52,000.

NHTSA #11671882

The contact owns a 2019 Ford Escape. The contact received notification of NHTSA Campaign Number: 22V413000 (POWER TRAIN). The contact stated that while the vehicle was being repaired under recall, the contact was informed that there was coolant intrusion into the engine, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure. The approximate failure mileage was 98,837.

NHTSA #11672855

The contact owns a 2019 Ford Escape. The contact stated that while driving at 55 MPH, the check engine warning light illuminated. A dealer was contacted. The vehicle was taken to the dealer, where it was diagnosed, and it was determined that the engine needed to be replaced due to coolant intrusion into cylinder #2. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 74,500.

NHTSA #11720222

The contact owns a 2019 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The check engine warning light was illuminated. The vehicle was able to restart. The vehicle was taken to the dealer, where it was diagnosed that coolant intrusion into the cylinder had caused the engine to fail. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 58,600.

NHTSA #11666523

The contact owns a 2019 Ford Escape. The contact stated that while driving at an undisclosed speed, the engine overheated, with the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that there was coolant intrusion into the cylinders, causing the engine to fail. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 52,000.

NHTSA #11663737

The contact owns a 2019 Ford Escape. The contact stated while the vehicle was parked, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that there was an internal coolant leak and that the short block, along with several other unknown parts needed to be replaced. The contact researched and was made aware of a possible recall; however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 11,000.

NHTSA #11661435

The contact owned a 2019 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly stalled, and an abnormal sound was coming from the vehicle. No warning light was illuminated. The vehicle was able to restart; however, the failure persisted. The contact stated that the vehicle failed to accelerate and unexpectedly lunged forward while shifting gears. The vehicle was towed to an independent mechanic, where it was diagnosed with transmission failure. The mechanic determined that the transmission needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 126,000.

NHTSA #11717580

The transmission in the vehicle needs replaced. There have been recalls on 2019 ford escapes for the same issue that this vehicle is having.

NHTSA #11708491

My first incident with my 2019 Ford Escape happened when I had my [XXX] in the vehicle with me at a stop sign In November of 2024. As I proceeded to enter the intersection, the vehicle would not accelerate. I was able to reverse enough to get out of the intersection, but was still on the roadway, which is a safety hazard. While I waited for help, I was having to direct traffic around my vehicle, another safety hazard. The vehicle would not drive at all. The milage at the time of failure was approx. 112,000 miles. I was later informed the vehicle's transmission needed to be replaced and that they had found metal shavings in the transmission fluid. The Ford dealership stated my vehicle was financed used and there was no warranty on it. The dealership also informed me there was no recalls on my vehicle. I spent approx. $4,600 to have this repaired by a local mechanic shop. Now, a year later, I had pulled over to let a funeral procession pass and once I began to accelerate, my vehicle began to stall. I was able to drive it to a gas station that was nearby where I was unable to drive it any further. My 3 children were in the vehicle with me. I took it to the same mechanic shop that had initially repaired it to inquire about a warranty on the transmission. I was informed the warranty was through a third party and they would not fix it, claiming I had gone 500 miles past what warranty covered ( 1 year or 12,000 miles). They diagnosed it and confirmed the transmission had to be replaced. I have been told it would cost me approximately $3,500 (plus labor) to repair again with another year/12,000 mile warranty. I took the Escape to the Ford dealership to have them diagnose it and was informed the the transmission needed to be replaced, and they would do it for $8,500. I have read about plenty of 2019 Ford Escape Recalls on the transmission and this is definitely a safety issue. I'm over being stranded on the roadway with my kids... thankfully I wasn't on the interstate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11710706

Engine failure due to coolant leaking into engine block. Known issue from design flaw.

NHTSA #11701345

The contact owns a 2019 Ford Escape. The contact stated that while his girlfriend was driving 55 MPH, the vehicle began to hesitate and shudder, prompting her to discontinue driving the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the torque converter and transmission. The contact was informed that the torque converter and transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 65,000.

NHTSA #11683961

Clunking/wobble from Rear differential unit, also roaring like a bad wheel bearing loss of acceleration intermittently/power intermittently

NHTSA #11684394

Driveshaft carrier bearing trashed

NHTSA #11684396

I am reporting a serious transmission failure in my 2019 Ford Escape SEL with only 86,000 miles. The vehicle began exhibiting signs of transmission malfunction, including whining noises and delayed acceleration. Upon inspection, the mechanic found metal shavings in the transmission fluid and reported that the front pump had completely failed. This issue aligns with the widespread problems detailed in the [XXX] et al. v. Ford Motor Company class action lawsuit concerning premature transmission failures in Ford vehicles. The estimated cost to repair my vehicle is nearly $8,700, which is unreasonable for a vehicle with such relatively low mileage. I am concerned about the safety implications of this failure, especially if the vehicle had lost power while driving. I believe this issue is part of a broader, known defect and should be investigated further. I have documentation to support my case and am happy to provide repair estimates or service records upon request. I reside in Virginia and would like this complaint to be recorded as part of your investigation into transmission-related issues on 2019 Ford Escapes. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11671564

Transmission failed. Since the transmission failed, I was stuck at an intersection and could not move forward for several moments. The transmission was inspected and repaired by Aamco transmission services. There were no warnings. The car had been driven only 38,633 miles. Ford will not reimburse for the repairs, but is aware the repairs were completed.

NHTSA #11672081

Was driving out of town when the car started to slow down on its own, and when stepping on the gas kept slowing down and jerking and we had to pull over and shut it off. Did that a few times and then would go gaining speed a little at a time, except when going up a hill. Then would start to slow down and almost stall on the busy highway. Traffic was backing up behind us unable to pass and we continually had to keep pulling over on the highway as the car would start to stall. Then the check engine light came on, and a couple times it flashed. We pulled into our hometown garage (Heisler Auto, Mohall ND) and they checked it out and said it was a cylinder 1 misfire. We purchased spark plugs and did that ourselves. The problem continued immediately after we put them in and the check engine light came on again. We took back to Heisler Auto and 2 weeks later they changed out the coil packs to see if that was the issue. The issue continued when they took it out for a drive and upon further inspection found it to be the timing chain. It will be another 2 weeks before they get the part and do the work. So it’s been a whole month with no vehicle to drive. There was no warning signs of this. Car has driven great and has had great gas mileage until Bam, that day it just quit running. I will upload the $2200 repair bill after they get it done. I wanted to send this off now so I don’t forget. I called Ford and I have a case number for this: CXH-04637344 and they told me to file the complaint with you.

NHTSA #11666305

Cylinder 4 misfire code caused a check engine light. Brought to mechanic who replaced all spark plugs and the cylinder 4 coil pack. The code came back later that day. I started noticing a low coolant level and one instance of white smoke on startup. I brought the vehicle to the dealer for diagnostic and was diagnosed with coolant intrusion in the engine block. This is a well reported and well known issue for this and other similar vehicles and Ford has not addressed this with a recall. It is a design flaw associated with multiple model years. The cost to repair the issue is more than the cost of the vehicle itself. If the problem persists, it could result in a crack in the engine, which could become a major safety hazard depending on the circumstances. Ford should provide coverage for these repairs affecting hundreds of thousands of vehicles.

NHTSA #11731912

The contact owns a 2019 Ford Escape. The contact stated that while driving approximately 45 MPH on a local roadway, the vehicle went into LIMP Mode and failed to accelerate. The engine and oil warning lights were illuminated. The vehicle was towed to an independent mechanic, and the mechanic retrieved DTC: P1299, P0300, P0303; however, the vehicle was not repaired. The vehicle was then taken to the dealer, and DTC: P0303 was confirmed; however, the vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 72,000.

NHTSA #11731183

Ford has an issue where the coolant leaks into the cylinder blocks ruining the engine. Also, cause for low coolant which could catch the engine on fire.

NHTSA #11701940

The vehicle all of a sudden started saying there was a misfire on cylinder 1. So the ca was taken in for a tune up. Coil packs and spark plugs were changed. The vehicle was then losing coolant with no sign of a coolant leak externally. The coolant began leaking into the engine through a weakened gasket caused by the misfire. That should not of happened. The car had been marked as having various repairs prior to purchase at ford dealerships on such parts.

NHTSA #11689843

Took my 2019 Ford Escape in for oil change and tune up. Couple days after tune up check engine light came on (cylinder 3 misfire) and vehicle overheated. Got vehicle back to local repair shop and discovered coolant intrusion in cylinder 3. Overheating of engine left me stranded in traffic, as there was no shoulder, only a guard rail on side of the road. Could have easily been rear ended. Luckily about to minutes later, the police arrived behind me and waited with lights on until tow truck arrived. Engine code P0303. Ford has issued a TSB (22-2322), so they are aware of the problems with the 1.5L EcoBoost engine. My Escapehas all the symptoms listed on the TSB and build date is within the manufacture dates shown on the TSB

NHTSA #11692546

Within the first year of purchase, I was going to the Toronto Airport on the 401 and the vehicles' engine power quickly reduced to about 5mi/hr. I had to pull off the freeway in fear of being rear ended. I slowly made it to a gas station, the vehicle running at reduced power for about 15min. I turned the vehicle off and waited for About 30min. The car started up with full power when increasing the pressure on the gas peddle I took it to the dealer when I returned home. They found nothing. This happened again 3yrs later with the same outcome from a repair shop. I am told to use mid grade gas...although I fear another shutdown that could cause me to be part of an accident that could be detrimental to my health due to the quick loss of power and being rear ended. What is happening? How can you help?

NHTSA #11744870

The engine continually misfires, forcing me to continually get it fixed. Now, with only 68,000 miles I have to replace the head gasket ($4000), which my mechanic states is an extremely common problem with this make, model, and year. I also continually get notices to my Ford app about “fault detected—service engine soon” (for the misfire) and “a power train or AWD fault has been detected”.

NHTSA #11687440

The contact owns a 2019 Ford Escape. The contact stated while driving 45 MPH, the vehicle stalled. The contact was able to pull over to the side of the road. The check engine warning light was illuminated, and the contact received a power train malfunction notification through the Mobile App. The vehicle was able to restart but failed to respond while depressing the accelerator pedal. The vehicle was towed to the dealer, where it was diagnosed with transmission failure. The dealer determined that the transmission needed to be replaced. The vehicle was repaired. Additionally, the contact stated that the vehicle was difficult to start but was started after several attempts. The vehicle was taken to Loganville Ford (3460 US-78, Loganville, GA 30052); where it was diagnosed and determined that the cam seals, the crankshaft sensor and harness, and the timing components needed to be replaced. The vehicle was not repaired. The contact stated that the engine was previously replaced in 2021, and the fuel pump was replaced in 2023 due to the stalling failure. The manufacturer was notified of the failure and a case was filed. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 98,117.

NHTSA #11683742