Ford Bronco 2022: Retiros, Quejas y Ley de Limón de California

I took my vehicle to the local Ford dealership for the remedy for recall Ford 25S01 on Feb 2, 2026. During the inspection, it was found that the part affected was damaged and the dealership sent photos to Ford. After that, I haven't received any guidance from Ford or the dealership. Since the invoice I received indicated that there was a weld crack in one of the absorbers, I assume that the recall should repair this as a safety concern, but I haven't received any proactive communication from Ford or the dealership. I have contacted the dealership twice since February but I have not received any callback. I am concerned that this is a safety issue and Ford hasn't done anything to correct this since they found out about the issue in February.

NHTSA #11742488

I took my 2022 Ford bronco Badlands sasquatch in for recall 25s01 rear shock absorber external reservoir corrosion on 01/15/2026 was notified the next day it was fix when I arrived it was not fix they said parts where on backorder and that Ford has placed the recall campaign on hold. I was advised to take vehicle home and they would call back when they hear back from ford.Both rear shocks have failed and reservoir have fallen off. Vehicle is unsafe to drive due to blown rear shocks vehicle is bouncing and feels like it's all over the place

NHTSA #11715012

Ford has an active recall for failed rear shock absorbers. My bronco was inspected at the Ford dealership, the tech indicated the shock absorbers failed inspection and needed a recall. A picture was sent to Ford, Ford declined the recall stating the rust was not corrosion. Therefore, my bronco did not receive the recall. Recall number is.25V025.

NHTSA #11702033

I drive a Standard ‘22 Bronco. Only E-brake works for parking brake when in parking lots and such. My Bronco rolls into oncoming traffic and pedestrians when the e-brake releases. I am former Homeland Security and this unacceptable, as this if my 10th issue with the Ford Bronco! Safety First!

NHTSA #11741910

There has been an SSM release by Ford (SSM 51415) acknowledging that 2021-2022 Bronco vehicles flat towed in neutral may experience inconsistent or unintended ABS (anti-lock brake) module activation while being towed. The ABS module exits sleep mode unexpectedly due to road vibration input during towing, which can cause brake drag or lockup while the vehicle is being flat towed behind a motorhome. This is a safety concern as unexpected braking of the towed vehicle can affect the towing vehicle's stability and control at highway speeds. The vehicle is being operated exactly as documented in the Ford owner's manual, which explicitly supports neutral flat towing. Ford has developed a software update to address this defect but is declining to cover it under warranty or goodwill, instead classifying it as non-covered maintenance. The issue has been confirmed by an authorized Ford dealership who identified SSM 51415 as applicable. A community workaround requiring removal of fuses 28 and 29 to disable the ABS pump has emerged among owners, indicating this is a widespread known issue affecting safety during a manufacturer-approved towing method. Ford should issue a TSB or recall and cover the software correction at no cost to owners.

NHTSA #11740101

On May 7, 2026 while driving approximately 18 mph, my Ford Bronco 2022 Outerbanks experienced a sudden loss of normal braking assist. The brake pedal became stuck in the upright position requiring excessive force to stop the vehicle. When the brake pedal went down the truck rolled to the curb and I put it in park. There was a warning sign on the dash that flashed and went away. I could not see what it was. Luckily there were no bystanders or other cars on the road at the time. I was near an elementary school at the time. This would have caused a crash or worse if there were pedestrians. I turned the truck off and called the tow. At the dealership they diagnosed and confirmed an electronic brake booster (EBB) failure. This EBB failure mirrors a recent recall from Ford affecting 2025 Broncos. The dealership has refused warranty because I am 6 months outside the warranty period even though I only have 29,960 miles. This is not normal wear and tear. The 2025 recall # is 25V488. This EBB recall may also affect previous years such as mine and should be investigated.

NHTSA #11737162

The contact owns a 2020 Ford Bronco. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, however, the vehicle failed to accelerate as intended. The check engine warning light illuminated and the engine seized. The contact stated that while attempting to start the vehicle, the vehicle failed to start as intended. The vehicle was towed to the residence. The mobile independent mechanic came to the residence, and the vehicle was diagnosed with a failed low pressure fuel pump. The contact was informed that the low pressure fuel pump needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure. The contact was informed that the parts were unavailable. The contact received a recall notification, NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) however the parts were unavailable. The manufacturer was not made aware of the failure. The failure mileage was approximately 25,000.

NHTSA #11739511

The contact owns a 2022 Ford Bronco. The contact stated that while at a complete stop, the vehicle hesitated while depressing the accelerator pedal. There was no warning light illuminated. The contact was almost struck by another vehicle due to the hesitation of vehicle. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue, and the mechanic was unable to duplicate the failure. The dealer confirmed that the failure was likely related to the recall; however, parts for the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 30,000.

NHTSA #11699743

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); causing a significant impact to his business. The local dealer was contacted, and the contact was informed that parts were not yet available. The vehicle was not repaired. The contact called the manufacturer but had not received a response. The contact had not experienced a failure.

NHTSA #11679097

The steering is unsafe, my neighbor works at a ford dealership and said it’s the rack, which I also read online that it’s become a common problem, the steering has become very stiff. To the point where I have had to slam on the breaks at curves in the road just to be able to turn into the bend, which has almost caused two incidents.

NHTSA #11735298

On April 3rd, 2026 my steering started to intermittently lock up on my 2022 Ford Bronco. I immediately took my vehicle to my local dealership where they were able to recreate the problem. The vehicle was also throwing the code U3000:49-8A for steering gear failure. This issue appears to be consistent with the Ford Safety Recall 23S09. There was no warning prior to the issue. There were no warning indicators once the issue began.

NHTSA #11729984

I was operating the vehicle on the highway and the steering locked up. I had no indication that this was going to happen. It would not turn and almost caused an accident. I was able to break the steering do to my strength. I was able to limp truck to dealer. Upon inspection they confirmed a faulty / locked up steering shaft. This was not covered by ford. The shaft was replaced and functional now. I have made several attempts to communicate with corporate ford about this safety matter and haven’t been heard from. They have had shaft issues with their f150 trucks also. This issue is a direct result from poor manufacturing and is a real safety issue. This should never happen with a vehicle that is only a few years old with not that many miles.I have saved the part for inspection and looking for some assistance. Thanks you.

NHTSA #11734542

Complete clutch failure at 39,000 miles. Unable to shift or safely restart vehicle once stopped. Clutch Hydraulic line came completely apart. Ford part number MB3Z-7A512-A. Failure verified by independent SAE certified mechanic. Note: Clutch and Brakes feed from the same reservoir, so loss of clutch hydraulic fluid also impacts entire braking system.

NHTSA #11742368

REAR WINDOW (REAR FLIP UP OVER TAIL GATE) SPONTANIOUSLY SHATTERED AND REQUIRED FULL REPLACEMENT.

NHTSA #11716477

Front camera only works about 1/4 of the time. Most of the time its just black.

NHTSA #11708950

What component or system failed or malfunctioned, and is it available for inspection upon request? - Display for backup camera freezes after putting vehicle in reverse. Yes, it is available for inspection. How was your safety or the safety of others put at risk? - The display freezes when putting the vehicle in revers and the initial image on display of what was behind the vehicle stays the same while moving. If something or someone moves behind the vehicle while moving the image does not update to show that something or someone is now behind the vehicle. Previously recall 23S48 was completed related to the issue but it did not resolve the issue. Vehicle was taken back to the dealer and the dealer informed me that it is a faulty APIM and not the backup camera and is therefore not covered by the recall. This is a significant safety issue and needs remedied regardless of what component needs replaced. Has the problem been reproduced or confirmed by a dealer or independent service center? - Yes Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? - Only by the dealer (Midwest Ford in Hutchinson, KS). Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? - No

NHTSA #11717267

The contact owns a 2023 Ford Bronco. The contact stated while attempting to start the vehicle, there were several unknown warning lights illuminated. The contact exited the vehicle, raised the hood of the vehicle and became aware that rodents had chewed through the electrical wiring. The vehicle was not taken to the dealer or an independent mechanic to be inspected. The vehicle was not repaired. The manufacturer was notified not of the failure. The approximate failure mileage was 13,000.

NHTSA #11709244

My vehicle is experiencing potential electrical issues which appear to be similar to the same 12-volt battery management failures that are currently recalled in the Bronco Sport models. The "Charging System Service Now" alarm continues to pop up, sometimes every 30 seconds. I am also not able to use my communication and navigation system, and I am not sure if this is related to the same electrical system malfunctions. Furthermore, on three recent occasions, my vehicle stalled while I was pulling out of a street which was on a slight incline, another while I was on a hill in a parking lot, and another while I was reversing and putting my car into 1st gear to drive. During all of these occasions, my vehicle stalled and did not automatically re-start which had me blocking traffic while I turned my vehicle back on. All of these issues have affected the safety of myself and my passengers due to the unexpected stalling as well as electrical power loss, including loss of navigation/communications. It has also resulted in me getting pulled over by law enforcement twice due to swerving while I was looking at the screen when it went black and the other because I was speeding because my Charging System Service alarm went off and I was also unable to determine the speed limit of that road without having my navigation screen working. I believe I have contacted the Ford Dealership regarding the specific loss of the communication and navigation issue and was told they did not have the parts/software available at this time. I have taken my vehicle to an Advance Auto Parts store when the "Charging System Service Now" first appeared and was told it was potentially the alternator. I will have to locate the documentation at a later time.

NHTSA #11725550

The Molded-In-Color (MIC) hard top shows signs of delamination and cracking on the exterior skin of the roof panel. Models from the same production year were called under NHTSA Recall No.: 26V299. My vehicle was not included on this recall. I have attempted to have Ford inspect the issue and have refused since it is out of warranty. I am concerned that the delaminating sections will detach while driving.

NHTSA #11743541

Noticed that my hardtop was cracking around the rear windows. This is a know issue with Ford and is being replaced under warranty. Unfortunately, my vehicle is outside of the original 3 year 36,000 mile warranty period by just over 6,000 miles that would qualify for replacement. The dealer quoted over $10,000.00 to replace the entire top since all roof panels appear to be affected. This is almost 1/4 the cost of my vehicle on the used market and is unacceptable for a know issue that would normally be replaced under warranty.

NHTSA #11739202

When closing the lift gate, the pistons did not compress and the glass shattered while still holding the lift gate. This resulted in cuts to two fingers on the left hand, ring and middle, cut across the knuckles with bleeding. Support struts are remove and are available for inspection. Not reported to dealer or police. Insurance notified, for replacement glass.

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11692645

There has been a Safety recall in the fuel pump for almost a year, with documented known issues existing well before the release and Ford has still yet to make a remedy available.

NHTSA #11740207

My 2022 Ford Bronco experienced recall 25S75 where fuel pump failed while driving on the freeway outside LA near San Bernardino. Recall was communicated in July of 2025 and no fix available. How long has Ford been building cars? There were no warnings or symptoms prior to failure. This was extremely dangerous for car to stall in the middle of the freeway, not to mention it was 98 degrees outside. I was able to tow my Bronco to a Ford dealership where they confirmed and fixed the recall fuel pump issue.

NHTSA #11739285

There has been no incident because of this recall, but it is going on 3 months since I was contacted about this recall. We worry about the fuel pump going out when we drive the car. I mean how long do you have to wait? I have my grandson driving this car.

NHTSA #11688055

The contact owns a 2022 Ford Bronco. The contact stated that upon entering the vehicle and closing the door, the driver's side rear quarter panel window separated from the vehicle and fell on the ground. A Safelite mobile technician replaced the driver's side rear quarter panel window at the residence. The vehicle was repaired. The dealer was notified of the failure. The manufacturer was notified of the failure and informed the contact that the VIN was not under recall for the failure. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 39,000. The VIN was not available.

NHTSA #11669189

See attached document for complaint.

NHTSA #11662128

The contact owns a 2022 Ford Bronco. The contact stated while driving approximately 40 MPH in the rain and attempting to clean the windshield, the windshield washer fluid failed to operate as intended, and the windshield wipers became inoperable while driving approximately two weeks later. Additionally, the contact stated that she had noticed a fluid leak on the rear passenger's side interior door. The vehicle was taken to New Canaan Auto Body Inc., where it was diagnosed that the windshield wiper motor had failed, and the windshield washer fluid was leaking on the rear passenger's side interior door. The contact stated that additional diagnostic testing was being performed. The vehicle was not yet repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 49,000.

NHTSA #11658924

The contact owns a 2022 Ford Bronco. The contact stated that while attempting to reverse, the rearview camera became inoperable. The contact stated that the rearview camera image failed to function and the image would appear as blank. The contact received notification of NHTSA Campaign Numbers: 26V124000(Back Over Prevention) and 25V455000 (Fuel System, Gasoline), however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that the remedy parts were not yet available. The manufacturer was made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The approximate failure mileage was 35,000.

NHTSA #11736283

The contact owns a 2022 FORD BRONCO. The contact became aware that the VIN was included in NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) through a VIN search; however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Additionally, the contact stated that the rearview and front view cameras were intermittently inoperable. The contact related the failure to NHTSA Campaign Number: 26V124000 (Back Over Prevention). The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the issue. The failure mileage was approximately 8,600.

NHTSA #11741818

The contact owns a 2022 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V273000 (Back Over Prevention), 25V315000 (Back Over Prevention), and 25V455000 (Fuel System, Gasoline); however, the parts for the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact stated that after the initial start, the back over the prevention camera displayed a black screen until the vehicle was restarted. The failure was intermittent. While driving out of a grocery store parking lot at approximately 5 - 10 MPH and attempting to accelerate into oncoming traffic, the vehicle stalled. There was no warning light illuminated. The vehicle was pushed to a nearby parking lot with the help of the contact's spouse. The contact used a diagnostic machine to perform a diagnostic test on the vehicle. The DTC for a faulty fuel system was retrieved. The vehicle was towed to the dealer, who confirmed that parts for the recall repairs were not yet available. The manufacturer was made aware of the issues. The failure mileage was approximately 39,000.

NHTSA #11679751

The contact owns a 2022 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with several unknown warning lights illuminated. The vehicle was towed to the dealer, where it was diagnosed, and determined that the fuel pump had failed and needed to be replaced. The vehicle was repaired. The contact stated that after the repair, while driving at an undisclosed speed, the vehicle unexpectedly shook and sputtered. There was no warning light illuminated. The contact received notification of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 25V721000 (Seats), and 26V124000 (Back Over Prevention); however, the parts to do the recall repairs were not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 35,000.

NHTSA #11727079

The contact owns a 2022 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with several unknown warning lights illuminated. The vehicle needed to be towed. The contact was informed that the VIN was included in NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 25V721000 (Seats), and 26V124000 (Back Over Prevention); however, the parts to do the recall repairs were not yet available. The vehicle was towed to the dealer to be diagnosed, and it was determined that the low-pressure fuel pump had failed and needed to be replaced. The vehicle was not repaired, and the dealer confirmed that the parts were not yet available. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for additional assistance. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The approximate failure mileage was 40,000.

NHTSA #11725590

The contact owns a 2022 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 26V124000 (Back Over Prevention), and 25V721000 (Seats); however, the parts to do the recall repairs were not yet available. The contact stated that the infotainment screen intermittently turned blank at start-up, causing the rear-view camera to fail while reversing. The dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 15,000.

NHTSA #11726637

I believe my vehicle has suffered a cracked/fractured or broken intake valve on cylinder number 4. There is very low compression in that cylinder. I checked it and it only managed to produce 25psi. I inspected the cylinder with a borescope camera and there is no damage or excessive wear to the piston or cylinder bore. They both look pristine with no signs of anything. I could not see either the intake or exhaust valves on my camera. They are the only pieces of the engine I could not inspect that could possible cause a compression issue. It is my understanding that ford is aware of an issue of this happening on some 2.7 Ecoboost engines?

NHTSA #11717538

Vehicle was shifted into 4L on a relative flat surface. Vehicle would not indicate successful transfer to 4L, just a blinking 4L indicator light and then a message to place vehicle in N and then pull forward. After unsuccessful attempt to engage 4L, tried to return to regular driving mode and vehicle would not. After turning car off and even disconnecting battery, vehicle would not function as expected. Returned to the vehicle and got a Powertrain Malfunction error and service message. Called Ford and had it shipped to Landers Ford in Southaven Mississippi and awaiting inspection.

NHTSA #11640524

I’ve complained to my local Ford dealer about 10-speed transmission issues including to several different service techs. There is a loud clunk and physical movement of the vehicle when shifting from park through to reverse and eventually to drive—it’s the P to R which is most noticeable. I’ve had 3rd party mechanics inspect the clunk, had Ford replace the driveshaft, conducted a trans fluid flush, but the clunk persists. I am concerned that one day, the vehicle will not shift out of park or potentially damage the transmission to an undriveable state outside of warranty. This has persisted for several years. I need Ford to replace the transmission and then conduct research into the issues with the old one once removed.

NHTSA #11715026

While driving on an interstate it was determined that the engine walls over compressed and blew out the sides of the motor of my 2022 Ford Bronco. The Bronco has 67,000 miles on it which shows a clear manufacturer defect. It is available to be inspected as well to confirm. My wife’s and unborn child’s safety was put at risk by losing acceleration and losing control of the vehicle briefly as it began to shake from the engine misfiring. This easily could have caused a serious wreck had more traffic been present at the time. The dealership has not been able to confirm this on other cars. The engine has been inspected by a Ford Dealership. There were no warning lamps or messages prior to the failure and only appeared shortly after the engine over-compressed and began to shake.

NHTSA #11744590

The contact owns a 2022 Ford Bronco. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed and determined that the spark plugs had failed to remain connected. The spark plugs were reconnected. The next day the check engine warning light illuminated. The vehicle was returned to the dealer where it was diagnosed with the same failure. The spark plugs were replaced. The failure reoccurred and the engine sounded as if the engine was sputtering while starting the vehicle for several minutes. The vehicle was returned to the dealer where it was diagnosed as spark plug failure and that the engine was misfiring. There were no DTC codes retrieved. The vehicle was not repaired. The manufacturer had not been made aware of the failure. The failure mileage was approximately 35,000.

NHTSA #11613002

The contact owns a 2022 Ford Bronco. The contact stated while driving at various speeds, the vehicle lost motive power. The check engine warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed that a bent valve stem needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 103,000.

NHTSA #11626656

The contact owns a 2022 Ford Bronco. The contact stated while reversing, the rear view camera displayed a blank screen. The vehicle was taken to the dealer where the contact was informed that the parts were unavailable. The vehicle was not repaired. In addition, the contact was informed that the parts were not going to be available until July 2026. The contact received a recall notification, NHTSA Campaign Number: 25V455000 (Back Over Prevention) however the parts were unavailable. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 27,800.

NHTSA #11735878

The contact owns a 2022 Ford Bronco. The contact was informed of the NHTSA Campaign Number: 23V165000 (BACK OVER PREVENTION); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact experienced the failure and became aware that the back-over prevention camera had malfunctioned, and a black screen was displayed. The failure mileage was 35,900.

NHTSA #11721404

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V312000( BACK OVER PREVENTION) However, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure

NHTSA #11739241

The windshield washer fluid reservoir cracked along its seam and drains completely after a few hours. This was not due to an accident and I have not done off-roading. I live in a snowy environment and not having an operating windshield washer is a MAJOR safety hazard as road salt quickly builds up on the windshield dramatically reducing forward visibility. It also affects the rear window washer, but that’s not as troubling an issue. The defective reservoir is available for inspection. My local mechanic confirmed that the reservoir is cracked. My photo shows the fluid leaking onto the ground. The component has not been inspected by the manufacturer, police or insurance, but has been inspected by a mechanic at my local Chevron station. A “washer fluid low” warning and idiot light appears after the reservoir drains, goes off when fluid is added, and goes on again when the fluid drains out again. I have ordered a replacement reservoir from Ford (which has been revised from the original) plus two required hoses for $477.28 (without installation). An internet search suggests this is a common problem for my vehicle.

NHTSA #11711496

There is a bulletin that ford sent out that includes wipers intermittently not working properly when detecting rain. The issue happens when the normal steady wiper speed is selected and the issue isn’t resolved until the wipers are turned off and on again then the issue persists. Ford will not cover this issue even with a bulletin for a car 2,000 miles over their warranty. Further more fords extended warranty they offer at their dealerships will not cover this issue as well even though it extends the manufacturer warranty. This is a safety issue while driving in the rain

NHTSA #11637094

I was sitting in my car and the back wind shield exploded over my dog and I. Ford was made aware of the issue, and apparently the Bronco's rods hyper extend and cause the tempered glass to break. Ford wont cover any damages done, and says it isn't covered by warranty. Although the dealership and Ford acknowledge no pressure was existenet to cause the window to burst randomly. In addition, Ford is aware the plastic placer screws in the removable hardtop is defective and cracks over time. However, they are not warrantying this repair.

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11616384

See attached document for complaint. Dear Ford Motor Company, NHTSA Officials, and Lindsay Ford of Wheaton: I am the registered owner of a 2022 Ford vehicle, XXXXX. I am in receipt of NHTSA Safety Recall Notice 22S72 (dated November 2025, enclosed herein), which states in part: "Vehicle identification Number (VIN): [partial VIN redacted] ... This recall applies to vehicles which may have a defective motor assembly that can cause sudden loss of power, stalling, or fire risk while driving. Until parts are available, Ford recommends parking the vehicle outdoors and away from structures." I am terrified to drive this vehicle. The recall explicitly warns of fire risk, sudden power loss, and inability to restart, all life-threatening conditions. Ford admits no remedy is currently available, and the interim instruction to park outdoors is not a fix; it is an admission that the vehicle is unreasonably dangerous. My Legal Rights Under Federal and State Law: NHTSA Authority (49 CFR § 577.5) "The manufacturer shall remedy the defect or noncompliance without charge when the vehicle is presented for remedy." 1. Ford has failed to provide a timely remedy and instead issued a "park outside" advisory, which does not eliminate the hazard. 2. Magnuson-Moss Warranty Act (15 U.S.C. § 2301 et seq.) Ford's express and implied warranties of safety and merchantability have been breached. A vehicle that can catch fire or stall without warning is not fit for its ordinary purpose (safe transportation). 3. Maryland Lemon Law / UCC § 2-314 (Implied Warranty of Merchantability) A known fire hazard renders the vehicle defective and unmerchantable. I have a right to revocation of acceptance and replacement or refund. 4. Ford's Own Recall Language The notice states: "If you are not comfortable driving your vehicle, contact your dealer. "I am not comfortable. I am afraid for my life and my family's safety. I am copying the dealership as well. DEMAND FOR RELIEF: Within seven (7) business days of receipt of this letter, I demand: 1. A brand-new, identical or comparable 2022+ model replacement vehicle (same trim, options, and features), delivered at Ford's expense, with: 0 Zero miles or loaner credit until delivery All taxes, title, registration, and delivery fees paid by Ford 0 Full transfer of remaining factory warranty 2. Immediate pickup of the defective vehicle at Ford's expense 3. Written confirmation that the replacement vehicle is not subject to Recall 22S72 or any open safety recalls 4. $1,500 inconvenience stipend for stress, loss of use, and reliance on unsafe transportation FAILURE TO COMPLY: If Ford fails to meet this demand within seven (7) business days, I will pursue small claims/superior court action for breach of warranty, revocation, and damages; and, seek punitive damages for reckless endangerment (knowingly selling/distributing a fire-hazard vehicle).

NHTSA #11701153

I am submitting this complaint regarding an open safety recall on my vehicle, NHTSA Recall 25V721 (Manufacturer Recall 25SB5), which has been active since October 29, 2025. As of today, the recall remains incomplete and the manufacturer states that no remedy or parts are available, with no estimated timeline provided. The recall involves a potential issue where a front seat frame height-adjust pivot bolt may loosen or dislodge, increasing the risk of injury in a crash. According to the manufacturer, this condition may not be identifiable without an incident or collision. My concern is that: 1.The recall has been open for over three months with no interim remedy, inspection protocol, or mitigation guidance offered to owners. 2.The manufacturer has not provided clear written guidance on whether the vehicle is considered safe for continued operation while awaiting the remedy, beyond stating that parts are unavailable. 3.Owners are left in a prolonged state of uncertainty, despite the recall being classified as safety-related. 4.The lack of interim guidance or remedy availability is causing financial and practical hardship, as vehicles with open safety recalls are restricted from certain lawful uses, even when no symptoms are present. I am requesting that NHTSA review whether the manufacturer’s delay in providing a remedy—or interim safety guidance—meets expectations for timely resolution of a safety recall. I am also requesting that NHTSA encourage the manufacturer to provide either: •An interim inspection or mitigation procedure, or •Clear guidance on vehicle operability and risk while awaiting the final remedy. Thank you for your review of this matter.

NHTSA #11719006

All metal components of the seat have rusted and corroded. The seat is no longer safe and its structural integrity is compromised. This is on the Black Diamond trim package where the interior of the car is marketed and sold as weatherproof with sealed electronic components, marine grade vinyl upholstered seats and drain plugs installed in the floor board to empty water from the floor boards Ford Motor Co has denied the bumper to bumper warranty on these seat components stating that the seat was exposed to moisture This is the ford bronco that is pictured in advertisements and marketing materials with no roof or doors installed, and has supplements and guide materials provided with the owners manual that outlines practices to drive through water / rivers My truck has never been through any standing water

NHTSA #11643425

Crack in airbag cover on steering wheel

NHTSA #11690412

The contact owns a 2022 Ford Bronco. A warning light restraint indicator lamp warning saying airbag system may not deploy properly, vehicle impact sensors affecting airbag, received warning indicator on the instrument panel saying vehicle should not be driven until remedied and should be taken to dealer. The vehicle was taken to the dealer where it was not diagnosed or repaired but the dealer advised does not know how to resolve the issue, The manufacturer was not notified of the issue. The approximate failure mileage was 14,440.

NHTSA #11741895

During heavy rains, I noticed some water leaking through the A pillar where the air bag is housed. I am concerned that the water may damage the air bag overtime. More importantly, if the air bags are deployed in low temperature (when the water becomes ice), it may create great safety problems.

NHTSA #11586465

While operating the vehicle under load, the vehicle suffered a sudden and severe loss of engine performance, followed immediately by loud metallic banging from the engine bay. The vehicle lost all power and was immediately disabled (LIMP MODE), presenting an imminent highway safety hazard.The Physical Damage: Subsequent mechanical teardown revealed deep vertical cylinder wall scoring, heavy raw fuel residue in the engine oil pan, and a blown head gasket. Relationship to Active Safety Defect: This catastrophic block failure perfectly mirrors the progressive failure profile of NHTSA Campaign 25V455 / Ford Safety Recall 25S75 (Low-Pressure Fuel Pump Failure). Internal component degradation in the fuel tank delivery module dropped fuel pressure to the engine. Under turbo boost, this starvation induced an extreme, instantaneous lean-out condition. The resulting low-speed pre-ignition (LSPI) exploded and shattered the internal piston rings (the metallic banging), leading to mechanical wall gouging, unburnt fuel wash into the lower crankcase, and a secondary blown head gasket. Request for Action: Ford's current VIN parameters for Recall 25S75 have not yet captured my specific vehicle despite it matching the exact production window, component setup, and catastrophic failure sequence. I am requesting that the NHTSA log this case as clear evidence of consequential engine destruction originating from the 25V455 pump defect, and evaluate whether Ford's recall scope must be expanded to protect other consumers from highway engine failures.

NHTSA #11744448

The Incident: While operating the vehicle under high load, the driver received an explicit "Service Engine Soon" powertrain malfunction alert stating: "The powertrain control module lost communication with the vehicle active grill shutter module for a period of time." Immediately following this warning, the engine experienced a severe loss of power, followed by loud metallic banging from the engine bay. The vehicle stalled completely and lost all motive power, creating an imminent highway safety hazard.The Physical Damage: Subsequent mechanical teardown by the dealership revealed terminal block destruction, including deep vertical cylinder wall scoring, heavy unburnt liquid gasoline residue in the engine oil pan, and a blown head gasket.Relationship to Active Safety Defect: This catastrophic engine failure mirrors the progressive failure profile of NHTSA Campaign 25V455 / Ford Safety Recall 25S75 (Low-Pressure Fuel Pump Failure). In this EcoBoost architecture, the Active Grill Shutter (AGS) module shares critical voltage paths, grounding blocks, and wiring looms with the engine management and fuel delivery systems. The sudden network communication loss is diagnostic proof of a severe voltage drop or electrical short caused by the high-friction fuel pump degradation detailed in Recall 25S75. This circuit failure instantly starved the engine of fuel under turbo boost, inducing an extreme lean-out condition. The resulting pre-ignition forces violently shattered the internal piston rings (the loud banging), which then gouged the cylinder walls, wiped out compression, fouled the crankcase with fuel residue, and blew the head gasket.Request for Action: Ford's current VIN parameters for Recall 25S75 have not yet captured my specific vehicle despite it matching the exact production window, component setup, and catastrophic failure sequence. I am requesting that the NHTSA log this case as definitive evidence of consequential engine destruction originating from the 25V455 fue

NHTSA #11744471

The contact owns a 2022 Ford Bronco. The contact received notifications of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) and 25V721000 (Seats); however, the parts to do the recall repairs were not yet available. The dealer was contacted, and the contact was informed that parts were not yet available. The manufacturer was contacted, and the contact was informed that parts were not yet available. The contact had not experienced a failure.

NHTSA #11726508

The contact owns a 2022 Ford Bronco. The contact recently purchased the vehicle to use as a rental vehicle. The contact stated that while registering the vehicle with the rental agency, the contact was made aware of the two open recalls. The recall notifications were NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) and 25V721000 (Seats); however, parts for the recall repairs were not available. The dealer was made aware of the issue. Due to the parts not being available, the contact might have to sell the vehicle. The manufacturer was contacted and informed the contact that the parts were not yet available. The contact had not experienced a failure.

NHTSA #11716280

Differential carrier replacement due to metal contmination being found in differential during oil change and a transmission overhaul due to excessive wear of(clutch container, CDF bushing, forward hub and front support bushings). They also noted a sticking valve in the main control on my 2022 Ford Bronco 2.7L V6 when taken in to dealership to evaluate vehichle under warranty due to ongoing intermittent thump/clunking noise when coming to a stop and accelerating from a stop as well as when backing up from a stop and while driving as well, intermittent loud metal slapping sound at speeds over 60 mph, intermittent jerking of vehichle when cycling through gears, unexpected downshift at high speeds. After differential replacement and transmission overhaul due to excessive wear while under warranty, my vehichle continues to experience the same symptoms and problems and feel this is a safety issue.

NHTSA #11744346

UNKNOWN grinding sound when at idle or in/out of gear ( manual transmission) sounds like transfer case. Other owners of 2021-2023 broncos regardless of trim levels have heard this sound with their broncos as well (manual trans)

NHTSA #11628042

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that upon starting the vehicle, the vehicle sputtered and nearly stalled. The contact turned off and restarted the vehicle; however, the failure persisted. Additionally, the fuel gauge was constantly inaccurate while starting the vehicle and while driving. The contact stated that the fuel gauge read 0 miles or 0 percent while there was fuel in the tank. The check engine warning light was illuminated. The dealer was contacted to schedule an appointment; however, the dealer informed the contact that the part for the recall repair was not yet available. The vehicle was not diagnosed or repaired. The contact stopped driving the vehicle due to safety concerns. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 59,700.

NHTSA #11721630

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle was driving roughly, and it stalled several times. The vehicle was taken to the local dealer, and the low-pressure fuel pump was replaced, but the failure persisted. The manufacturer was made aware of the issue. The failure mileage was 5,000.

NHTSA #11722896

Adaptive Cruise Control was enabled and in use and the vehicle nearly rammed into the leading vehicle. The vehicle speed and distance became erratic and finally the vehicle had an alert that the ACC was unavailable. This was a very scary incident and could have resulted in a collision. an earlier model Bronco had a misalignment radar module recall but it appears my vehicle should also be included in this recall as well.

NHTSA #11699988

Claim # CAS CXH-026-40233- PRE- COLLISION ASSIST(PCA) TO WHOM IT MAY CONCERN PLEASE FORWARD TO CUSTOMER SERVICES Since they refused email. We have a 2024 In route to RIVERHEAD FORD and refuse to pay their $200 diagnosis fee on PCA failure. Not in OBD III plug in diagnosis no way to check if functioning. Will be reported to NHTSA. MY Broncos 2022 is still in bumper to plumber warrantee but recently with MY key not administrator key noticed the PCA was not functioning. On page 24 Bronco Quick Reference Guide states in pertinent parts: " If your vehicle is rapidly approaching a stationary vehicle, vehicle traveling in the same direction as yours or a pedestrian within your driving path, the system is designed to provide three levels of functionality. Alert; Brake Support & Active Braking" While driving an speaking to a customer service agents I tested behind a Benz at approximate 40 mph and deliberately move my Broncos MY22 less that one car length or so. NADA! NO DISPLAY! To place a pedestrian in from to test the PCA would be wrong. The limited express warrantee state no charge for warrantee service, yet a call to Riverhead Ford service agent who stated a diagnosis charge of $200 or so for one hour. The warrantee also states that power up on line modem saves are updates are no charge. Ford three customer service read " non-warrantee" Ford policy , but refused to disclose where they found that statement in warrantee . ( Attached download) Further two supervisors read same "non-warrantee" Ford statement said I must pay $200 or more for electronic software/radar type RF signaling systems like proximity sensors for diagnosis purposes. A simple drive with a car in front should when switch by touch screen from high ,moderate or low should function and save lives. It failed that test. Previously, the system function ,when a driver cut dangerous in front of me and if function on screen and I immediately braked, no so today. A non- Ford check the display a

NHTSA #11614990

When my brakes are cold and I stop on a hill...the brakes do not hold and the car moves about a foot forward. Then something kicks in and it jerks the car to a stop (all the while my foot is completely pressed down on the brake. No warning lamps, no lights, nothing...just rolls when brake is completely applied. It only does this when the brakes are cold. After they warm up it doesn't do it anymore. The dealer has looked at it and couldn't replicate (because the brakes weren't cold) and told me to bring it back if it happens again. It happens every morning but by the time the dealer gets it it doesn't do it anymore. A PLETHORA of bronco owners are experiencing this same thing. Our thread on [XXX] is full of people experiencing the same thing. Some guy in Canada said he had every brake part replaced and it still happened. Then they did some sort of software update and he hasn't experienced it since. Why is this update not available to all? This is a serious hazard! Someone is going to get hurt! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11681704

Break pedal feels very mushy and no breaking effect , very dangerous on highway speed for my car and cars behind me. I went to different dealers for a fix ,they all says it is normal, but it is sure not normal, I had multiple close calls. Break feel is inconsistent everyday. When I apply the break lots of deadline and no breaking effect for first few inches also pedal sinking to floor, ford and dealership are ignoring this serious safety concern. kindly do the needful,thank you

NHTSA #11611842

We purchased the above referenced vehicle new back in 2022 and have received numerous recalls since 2023. Many of these recalls have no remedy or remedies not yet available. Thankfully, most of these recalls are not urgent and do not pose much of a problem. However, the most recent recall 25S75/25V455 poses a threat due to loss of fuel pressure and recently our vehicle has shown signs of malfunctioning. I am majorly concerned because our daughter is supposed to use this vehicle in February 2026 and the way the recall repairs are trending, it may take months or years to remedy. I am writing this correspondence so you are aware of the recall and put it on your radar to track. I plan on writing again if a significant amount of time has passed with no remedy per Ford's direction if we are having difficulty getting our vehicle repaired in a "reasonable" amount of time. There is no reason Ford should be producing faulty, no remedy vehicles. Families have to rely on their vehicles and should feel safe and confident, not worrying if the car stalls mid highway with their child in it.

NHTSA #11684931

The contact owns a 2022 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V025000 (Suspension), 25V315000 (Back Over Prevention), and 25V455000 (Fuel System, Gasoline); however, the parts to do the recall repairs were not yet available. The contact stated that while driving at various speeds, the vehicle experienced a bumpy ride. Additionally, the contact stated that the rearview camera image flickered, and the engine was running abnormally rough. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the failures. The failure mileage was approximately 6,000. VIN tool confirms parts not available.

NHTSA #11674199

The seat belt does not retract. It is loose and does not tighten properly.

NHTSA #11691852

The seat belt stem on the buckle receiver has corroded and snapped. This is on the Black Diamond trim package with marine grade upholstered seats, weatherproof electrical switches and buttons in the interior and drain plugs on the floor boards from factory. The metal stem of the seat belt receiver is bolted to the body of the truck, encased in rubber and has corroded and snapped in half. Ford motor co. has denied the bumper to bumper warranty on this part, stating that moisture exposure is evident . This is the vehicle that is marketed and intended to be hosed out with water to clean after off-roading . This is the same Bronco model that is pictured in advertisements with no doors or roofs installed visiting beaches, driving through rivers and climbing mountains It is obvious that the seat belt components have not been treated or coated with any enamel or coatings. From factory all seatbelt components are bare clean steel

NHTSA #11643416

When turning right, with the turn signal active, the turn signal will over-correct back to neutral and activate the left turn signal. This happens almost every time a sharp right turn is made, such as leaving a parking lot. The signal stalk must then by manually moved back to neutral. This is repeatable and occurs multiple times a week. This creates risk by presenting a false left turn signal to other drivers. This is a common issue on the Bronco, but Ford Motor Company has not provided a fix, TSB, or Recall.

NHTSA #11662853

Driving in wet sticky snow the unheated LED headlamps collect snow quickly and provide almost zero projection of light forward. When driving in areas without overhead lighting at night this becomes a serious safety concern and may lead to a serious accident when drivers cannot see any possible obstructions in the roadway or accurately see the edge of the road surface. Have been unable to demonstrate this flaw to any dealers due to snow being unpredictable and dealerships being closed at night. I do have dash cam video showing the issue that can be provided for review, video uploaded to youtube here [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11652915

I am on my 3rd Fuel Pump, it is currently at the Ford Dealership. My wife was accelerating through an intersection, making a left turn, when the engine shuddered, stalled and quite running. Luckily her momentum was able to get her through the intersection and avoid oncoming traffic. The Dealer has installed the 3rd faulty pump with the previous pump only lasting 3 months. Upon research this is a widespread manufacturing issues with the 2.7 ecoboost. I firmly believe this engine/fuel pump should be recalled due to the frequent malfunctions.

NHTSA #11656844

On [XXX] I was driving the vehicle during heavy rain. I commute 47 miles each way to work, when nearing my work location the car started to sputter like it was out of fuel and slowed to a crawl, applying pressure to the gas pedal had no impact - acted like it was getting no fuel, was able to pull vehicle over to side of the road. Vehicle would turn over but would not start - Check Engine light came on - codes displayed on code reader indicated that the high pressure fuel sensor and the low pressure fuel sensor were having issues. I had the vehicle towed to the closest Ford Dealer and they ended up replacing the fuel sensors and fuel pump. Thought that it was a faulty fuel pump. The Mileage I believe was 59516. On Wednesday [XXX] I was again driving this vehicle to work in a rain storm and at almost the exact same distance from home on the exact route the vehicle exhibited the exact same symptoms and the vehicle abruptly stopped running after shuttering to a stop with no fuel. In both cases the vehicle had a nearly full tank of fuel. The vehicle has been taken back to the Ford Dealership for repair. It appears that there is an issue when driving for extended periods on very wet roads water is entering the fuel systems electrical components and causing the system to fail causing a very unsafe driving condition. On December 11th the area had received 3.23 inches of rain in a 3 day period with the heaviest falling on the morning of December 11th. December was when Hurricane Helene passed to the west of our location in South Carolina dropping several inches of rain. Have made short trips in light rain with no issues, only in heavy rain and long distance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11630494

Concerns a safety-related defect involving the infotainment system in my 2022 Bronco, which is directly related to an active recall and has not been properly addressed by the manufacturer or dealership. Ford issued a recall concerning the infotainment system due to a safety concern. For over a quarter, Ford had no available fix. The entire time I had my Bronco, my infotainment system repeatedly malfunctioned, required frequent resets, & ultimately failed completely. When I contacted the dealership 10/23/25, the earliest service appt was 12/17/25. Upon arrival, I was informed that the infotainment system would need to be repaired before the recall software update could be applied. I explained that the failure itself was the reason for the recall. Despite this, I was required to pay a $196 diagnostic fee to determine if the failure was recall-related. After the eval, the dealership stated the failure was not Ford’s responsibility & provided an estimate of approximately $1,672.61 w/o tax to repair the system on a '22 vehicle. This determination contradicts the stated safety basis of the recall. I contacted my insurance provider to explore coverage. The claim was denied, w/the insurer stating the issue was not caused by an accident or break-in, but was consistent w/a vehicle defect. Despite this, I was still charged the diagnostic fee. Research indicates the recall involves an electrical defect, not only a software issue. A non-functioning infotainment system impacts access to safety alerts & vehicle information, which presents a legitimate safety risk. Ford & the dealership refused to repair the system under the recall, refund the diagnostic fee, or acknowledge the failure as recall-related. I'm continuing to operate a vehicle w/a known safety defect. I'm requesting NHTSA review if recall remedies are being improperly limited, if consumers are being charged for recall-related defects , and if manufacturer &dealership practices comply w/ fed safety requirements.

NHTSA #11708904

After reversing and driving away, the vehicle continued to display the rear camera and 360 view .Vehicle had to be shifted to park, stopped, then restarted in order to clear the display.

NHTSA #11590201

Vehicle has Surged and stalled randomly, the Crash alert warning appears on screen and starts to stop the vehicle with nothing in front of it, I have asked my Ford Dealer to remedy the recalls as I have paid over $50,000 for the vehicle and they tell me sorry there are no fixes, I tried to trade it in, and they said they cannot because they have a no sale enforcement on the Bronco and they said if they took it in trade they could not sell it.

NHTSA #11735309

Truck began scrolling warnings that pre-collision braking, hill start assist, forward collision, adaptive cruise control, and more were all not working. Alerts came out of no where while driving on highway and continued every 30 min to hour of drive time. Cruise control was disabled with this failure. Diagnosed with faulty steering-rack. This has been recalled on other 2022 Ford Broncos, but for some reason our was not included in this recall. This lot was clearly impacted as well. The truck is used for daily driving, does not go off-roading and was not involved in any collision or incident that triggered this, simply driving down the highway. Please let Ford know to expand the recall, our car is not safe to drive and is not inoperable unless we pay for the repair or the recall is expanded. Thank you for your assistance!

NHTSA #11738370

Getting a cross traffic alert and blind spot alert fault warning every time I drive the car.

NHTSA #11722829

The contact owns a 2022 Ford Bronco. The contact stated that while her husband was driving 65 MPH, the vehicle unintendedly decelerated and jerked abnormally. The driver pulled over to the shoulder of the road and inspected the vehicle. The driver then drove to the dealer, where the vehicle was diagnosed as having a contained fire inside the exhaust pipe. The vehicle remained at the dealer for further diagnostic tests with the assistance of the engineers. The dealer informed the contact that the manufacturer had denied the contact vehicle rental assistance. The vehicle was not yet repaired. The contact stated that with the three recalls, it was unsafe to continue driving the vehicle. The manufacturer was notified of the failure. The failure mileage was approximately 80,000.

NHTSA #11720883

I have experienced a loss of fuel pressure/engine stall on several occasions. I am not sure of the specific dates yet I had to add one on this form. There has been a recall since July 2025, for which Ford has acknowledged this increases the risk of a crash yet there is still no resolution. This is unacceptable, I have listed the recall numbers below. Manufacturer Recall Number 25S75 NHTSA Recall Number 25V455

NHTSA #11714845

I own a 2022 Ford Bronco. My vehicle has an electronic brake booster failure that causes multiple warning messages, brake system faults, and loss or reduction of brake assist. When this happens, the vehicle also prevents the 4-wheel drive system from engaging or switching modes. This is especially dangerous during winter conditions. When driving in snow or slippery conditions, I am unable to engage 4WD when it is needed most, while also experiencing brake system warnings. The vehicle becomes difficult to control and does not feel safe to drive. The dealership confirmed this is a known issue affecting multiple Ford Broncos and that the electronic brake booster part is currently back-ordered and unavailable. I was told many vehicles are affected, yet there is no recall for the 2022 model year, even though newer model years have a recall for the same component. This issue creates a serious safety risk due to impaired braking performance and inability to use 4-wheel drive in hazardous conditions. The vehicle had to be parked due to safety concerns. and the he issue happens intermittently, making it unpredictable.

NHTSA #11713958

The instrument cluster panel goes black and stays blacked out for driving from startup to shutdown. This does not occur consistently, but it occurs often and unpredictably and is occurring more and more often. Attempted to have dealership fix and they want to replace the instrument cluster panel. This is a safety issue for basic functionality of the vehicle. Ford has had this issue identified during other years of Bronco production but appears unwilling to fix it in all of them.

NHTSA #11740584

The contact purchased a Carobotor Technology Ltd, Bronco digital instrument cluster for a 2022 Ford Bronco. The contact stated that soon after installing the digital instrument cluster, the check engine warning light was displayed on the instrument panel. After using a code scanner, the contact received several DTC: U0418 “Invalid data received from the brake system control module”, U0155 “lost communication with instrument panel control module”, P25B0 “Fuel level sensor defective”, U0140 “Lost communication with body control module”, U2403 “Ethernet failure with instrument panel cluster”. The contact stated that a false "Service Advancetrac" message was displayed on the digital instrument panel. In addition, the contact stated that the blind spot information system, collision assist, lane departure, cross traffic alert, and other safety-related features were automatically disabled upon starting the vehicle. The contact manually enabled the features. The manufacturer was notified on several occasions about the failures. The contact was sent a USB drive to reset and fix the errors; however, the failure worsened. The part was not repaired or replaced.

NHTSA #11715107

Engine started stalking and acting like it wasn’t getting enough gas about a month ago. Took to a dealership and they said u had a cracked file injector line. They supposedly fixed the issue. Today it started stalling again and shut off in the middle of the highway and wouldn’t crank back up. Tried jumping battery and it would turn over but acted like it wasn’t getting any gas when trying to give gas and take off then it would shut off again. Had to get a tow back to dealer ship.

NHTSA #11680863

Tried to get my vehicle fixed under recall Ford mistakenly told me that these were aftermarket rear shocks and that they weren't covered upon fixing the vehicle myself and bringing the shocks into a different dealership they told me that they were covered and should have been fixed under recall I've been trying to get reimbursed by Ford for this and I've been getting the runaround I've been promised call backs from supervisors and have not got any they are well past their 60 day window per their policy to respond this is going on 6 months now I've been trying to get reimbursed for this fix

NHTSA #11701988

RECALL REMEDY NOT AVAILABLE. Causing safety concerns while driving.

NHTSA #11682578

The vehicle currently has three active recalls with each not having a remedy as of to date although one I was notified of 7 months ago. I have already had to have a faulty fuel pump repair within the first month or so of onset of purchase where vehicle just lost power and died on side of the road and had to be towed. Then had to fight the dealership and write complaint to Ford after having defective camshaft which took multiple attempts and documentation for FORD and the dealership to repair properly. Vehicle would shift between 2wd/4wd/AWD randomly while driving. Then I had been notified about a windshield wiper motor recall that just dropped of out the system before attempting repair. So never had that update ran or problem addressed. Now I have three other major safety recalls. Definitely a LEMON. Need Ford to stand behind their vehicle. I pay way too much not be safe. None of these failure or problems provided any prior warming indicators.

NHTSA #11672361

The contact owns a 2022 Ford Bronco. The contact stated that while attempting to accelerate, the vehicle hesitated. There was no warning light illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 40,000.

NHTSA #11672821

My 2022 Ford Bronco has two active recalls for low pressure fuel pump failure and front seat height-adjust pivot bolt and link replacement with no available remedies. This vehicle has gone thru numerous recalls which I believe this poses a safety and financial hardship.

NHTSA #11696357

Jul 08,2025 Manufacturer Recall Number25S75 NHTSA Recall Number25V455 Recall StatusRecall Incomplete, remedy not yet available Summary ON YOUR VEHICLE, IT IS POSSIBLE TO HAVE A LOSS OF FUEL PRESSURE AND FLOW FROM THE FUEL TANK DUE TO FUEL PUMP FAILURE. THIS CAN CAUSE A LACK OF FUEL DELIVERY TO THE ENGINE AND RESULT IN AN ENGINE STALL WHILE DRIVING. Safety Risk AN ENGINE STALL WHILE DRIVING INCREASES THE RISK OF A CRASH. Remedy FORD MOTOR COMPANY IS STILL ACTIVELY INVESTIGATING THIS ISSUE AND WORKING TO DEVELOP A REMEDY. WHEN THE REMEDY BECOMES AVAILABLE, FORD MOTOR COMPANY WILL NOTIFY YOU VIA MAIL TO SCHEDULE A SERVICE APPOINTMENT WITH YOUR DEALER FOR REPAIRS TO BE COMPLETED FREE OF CHARGE.

NHTSA #11733183

I purchased this vehicle in May this year and in July the manufacturer issued a safety recall notice. The manufacturer mentions in the recall that the engine may fail and can lead to crashes. I am unbale to use the vehicle for business, since I received the notice and it is causing me a lot to the verge of collapsing my business. I would like the manufacturer to look into this and issue a remedy as quickly as possible as the financial strain on my business is enormous. Thank you!

NHTSA #11693658

On June 13, 2025 my 2022 Ford Bronco and was involved in a serious collision in which the airbags did not deploy, the emergency braking and forward collision warning did not activate either. The second vehicle was t-boned at an estimated speed at the point of impact was 45mph. Both vehicles were a total loss. The Bronco suffered a bent frame and the passenger door would not open. The repair estimate was in excess of $36,000. I have reported the concern to Ford Motor Company under case number CXH-04933824-C1C3G9. At the time of the accident, there were no open recalls, warnings or notifications affecting the airbags or other safety systems. The vehicle was as-delivered by Ford from the factory with all regular service conducted by the local Ford dealership.

NHTSA #11672794

The contact owns a 2022 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V273000 (Back Over Prevention) and 25V025000 (Suspension); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA #11661810

Good afternoon! My car started having issues going in reverse before I received the recall notification. It would nearly stall out and happened a couple times prior to getting the notice. Once I got the notice, I reached out to the dealer to see if anything could be done and was told no, not yet. Now, months later, it has gotten so bad that I am having to leave my house when it's cool (it doesn't stall as bad when it's cool out), and park my car in a certain way each day to ensure that I can effectively leave work without my car stalling. What is worse is that now, on hot days, my car semi-stalls, when I am driving on toll roads or back country roads on the way home. It loses power or jerks. I have an hour commute each way and this is NOT okay. Frankly, it is very scary sometimes. I have reached out to the dealership to ask them if it's safe for me to drive my car or if there is something they could do and I am constantly told that there is no solution, I have to wait, and they "legally" cannot tell me that it is safe to drive my car. They offered the option to rent a car, but I would have to pay a minimum of $45 out of pocket, per DAY, and I cannot afford to do that! I am already paying $600 a month for this car, now they want me to pay an additional $1350-$1395 a month just so I can feel safe? This has been going on for roughly 7 months. Who knows how long a "solution" will take. 7 months x $1350 a month = I would be out almost $9500 on TOP OF my car payment with no end in sight. I feel like this is moving at a snails pace. The problem is getting worse and I am getting the run around. No help is being offered to make me feel safe driving this car! They seem annoyed when I ask about it (I have only reached out three times in the last 4 months). The recall even says that it could stall while driving. So, honestly, what is it going to take for me to not die in a crash when my car stops on a high-speed road? Seriously. What can be done?

NHTSA #11693670

On 03/31/25 at approx. 12:45 AM our 2022 Ford Wild Trak was engulfed in fire while parked on our driveway. There were no occupants, and it had last been operated on 3/30/25 at approximately 1030 PM. During its last operation there was nothing abnormal to indicate the potential of a engine fire (no warning lights, messages, unusual smell or odors, performance issues, smoke, or fire). Upon observing the Ford Bronco Wild Trak for the first time the engine compartment was fully engulfed, and it was clear the fire had started in the engine compartment. The flames from the Ford Bronco Wild Trak eventually spread to a second vehicle destroying it down to the frame and causing enough damage to a third vehicle rendering it a total loss. All three vehicles were within 4 feet of our residence and the flames were hot enough it melted the garage door window frames. The Ford Bronco Wild Trak is frequently parked in our garage, and it been we would have lost our home and the lives of all four family member would have been put at risk. Researching Ford Bronco Wild Trak engine fires, we discovered that Ford Bronco Sports and Ford Escapes both have recalls due to faulty fuel injectors resulting in engine fires. The fuel injectors in Ford Bronco Wild Trak’s are similar to the fuel injectors in both the Ford Bronco Sports and Escapes. Due to the similarity between the Ford Bronco Sports and Escapes with the Wild Trak fuel Injectors we are asking for the NTSBA to initiate an investigation into Ford Bronco Wild Trak engine fires. The Ford Bronco Wild Trak can be retained for inspection if requested quickly as it is scheduled to be picked up by our insurance company and then disposed.

NHTSA #11652129

This is about Brake system and vacuum line linked Bronco. This is highly related to my own safety as when I go uphill or highway, this 'brake failure system' always is on and sometimes you are very hard to press a brake pedal as it's very stiff and not easy to press using your foot. But the thing is it comes and goes and sometimes it stopped and coming back. I today asked for a repair at dealership and they charge me 650 dollars as there's no official recall. Although it happened before my warranty's up and there's so many people suffering this identical issue but Ford didn't do anything and charge money to customers.

NHTSA #11688921

I pulled up to a parking spot and when I tried to brake to place my car into park my brakes would not engage and my vehicle kept moving forward. I had to slam my car into park to prevent from slamming into a barrier. My rear camera goes in and out of a blank screen when “backing up” or reversing.

NHTSA #11635612

The vehicle’s back-up camera completely malfunctions about 20% - 30% of the time making it completely impossible to see anything behind the vehicle when backing up. Sometimes, when the vehicle is put into reverse, the display screen will be completely dark, other times the image freezes on a load up image or screen and there is no display of what is behind the vehicle, and worst of all, other times the display will lock on the first image from the rear facing camera and not show real-time video of what is behind the vehicle, making the driver think it is safe to back up when it may not be. The vehicle has been brought to two different Ford dealerships three different times over the last two years regarding this problem. The first time I was told the problem had been addressed. The problem continued to occur. The second time, I was told the issue could not be addressed at that time. I was told that Ford Corp was aware of the problem but they did not have a fix available at that time. I was told that Ford Corp was working on software enhancements that would be available sometime in the future that would address the issue. The problem continued to occur. The third time I was advised the problem could not be addressed at that time and “Ford is working on additional software enhancements which are expected to be delivered over-the-air (OTA) by late Q4 2024” and “Software will update automatically if vehicle connectivity is enabled in the vehicle’s settings.” The problem continues to occur, so much so that I have several recorded videos of the problem occurring.

NHTSA #11630488

We were returning home from a trip. We pulled into a gas station to get gas. As we pulled up to the gas pump, we smelled smoke and then saw smoke and fire. We immediately turned the Bronco off and jumped out. Shortly after, the whole engine compartment area was on fire. Luckily, there was a tow truck in the parking lot and was able to drag it away from the gas pumps. I had gotten an oil change prior to our trip. There were no warning signals, lights, or indication of temperature or oil problems. I had intermittently smelled gas while driving during our trip, but my wife said she did not smell gas on the passenger side.

NHTSA #11629828

The contact owns a 2022 Ford Bronco. The contact stated that the front passenger's side seat frame bolt had detached within a week of purchasing the vehicle. The vehicle was taken to a Ford dealer, where the bolt was reinstalled and tightened. Additionally, while driving 5-8 MPH in 4WD Low Mode, the vehicle made a beeping sound and stalled. The contact stated that the engine was chugging. The contact turned off and restarted the vehicle, and the vehicle responded as needed. The contact had stopped driving the vehicle in 4WD Low Mode. The vehicle was not diagnosed or repaired. Additionally, while reversing, the rearview camera displayed a black or blue screen intermittently. The vehicle was not diagnosed or repaired. The contact received notification of NHTSA Campaign Numbers: 25V312000 (Back Over Prevention), 25V455000 (Fuel System, Gasoline), and 25V721000 (Seats); however, the parts to do the recall repairs were not yet available. The dealer was contacted, but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA #11719030

The contact owns a 2022 Ford Bronco. The contact stated that while driving at undisclosed speeds, the “Powertrain Malfunction - Reduced Power Fault” message was displayed and flickered on and off. The contact that the battery was losing the charge. The contact stated that the battery was at 70% charge. The contact related the failure to NHTSA Campaign Number: 24V683000 (Power Train, Electrical System). The vehicle was taken to the local dealer, where it was diagnosed and determined that the battery needed to be replaced. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 36,000.

NHTSA #11642266

The contact owns a 2022 Ford Bronco. The contact stated that while his wife was driving approximately 55 MPH, the electronic traction control failed causing the vehicle to become unstable and difficult to steer or control. Additionally, the braking system had malfunctioned, and the brake pedal was firm while depressed, and the driver was unable to immediately stop the vehicle. The driver was able to steer the vehicle from the middle lane to the shoulder and used the parking brake to slow the vehicle to an eventual stop. The vehicle was later towed to the local dealer. The cause of the failure was not yet determined. During the failure, the driver’s side rear axle and the rear driver’s side wheel studs and aftermarket lug nuts were damaged and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 13,664.

NHTSA #11631445

The headlight/taillights control dial switches modes and settings when entering and existing vehicle, the dial for the auto lights it will change and turn off the lights so that while you drive at night the daytime driving lights come on but there will be no rear tail lights. Creating a very dangerous driving at night with no tail lights . I have not taken it in to the dealer as it is intermittent problem and hard to recreate on demand at the dealership. The only remedy is to check the settings dial several times while driving to confirm that the headlights settings have stayed to a lights on condition.

NHTSA #11609638

2022 Ford Bronco Outer Banks "Steering Assist Fault Service Required" warning appears on instrument display panel intermittently. When the warning appears power steering does not work.

NHTSA #11607178