2024 Kia Sportage: Recalls, Complaints & California Lemon Law

Sunroof exploded while driving. No rocks or anything hit it. Glass is pointing upward.

NHTSA #11735579

Sunroof on the vehicle shattered without being struck by projectile or road debris. The area where we were driving had no other cars near us at the time of the incident. There was no sound of something hitting then shattering, it just exploded. Examination of the sunroof did not reveal any points of impact, research done online has shown multiple other Kia Sportage owners with the same issue. Spontaneous shattering of the panoramic sunroof.

NHTSA #11734569

As I was driving to work this morning, I heard a loud bang. The sun roof blew up. Based on how the glass is raised, it looks like it blew from the inside out.

NHTSA #11731454

I was driving on the highway and had set the cruise control to 76. I then pushed the plus button once to increase the cruise control speed and the cruise control increased immediately to 110 mph. I braked right away which stopped the acceleration but could see it was still set at 110 mph. I pushed the button to turn the cruise control off. When I pushed it again, it went immediately back to 110. I tired multiple times over the next 45 minutes to turn the cruise control back on but it always went immediately to 110 mph.

NHTSA #11718151

Cruise control suddenly jumped to 110mph. Could not adjust the speed. Could only turn off cruise control. It happened several times in a row. Car would speed up until I hit the brake.

NHTSA #11625813

I purchased my car 10/12/24. On 11/2/24, one of the first times I had used cruise control, I was traveling between 40-45mph in a residential area and turned on my cruise control. The car immediately set the CC speed to exactly 110 mph and would not respond to the down arrow to adjust speed down. I paused CC and resumed and the setting remained at 110mph. I am not sure what caused the setting to finally clear as I was pretty frantically pressing buttons at that point. I do have a photograph of this instance and I have added it to this report. A brief google search confirmed multiple Kia drivers reporting the same issue with this line of vehicles. On 11/5/24 I took my car in to Olathe Kia's service department, asking them to investigate this issue. The service department reported that they found no error codes and had no repair to offer for the CC issue.

NHTSA #11624110

6” Snow ice storm & negative degree temps 12/13/25 used heated windshield deicer. On 12/15 driving to work on a country road no other traffic, heard pop cracking noise above my head checked sunroof snow ice melting no visible cracks thought noise from thawing ice. Parked vehicle in my home garage while I went out of town. Returned home 12/22 found large crack origination point in front windshield originating in glass down the middle of rear view mirror sensor housing black box mounted on inner windshield the crack spans from top middle to bottom of black box glass over to right center half of windshield. Believe this is a manufacture defect design flaw low quality integrity of glass weaker than standard glass making it more susceptible to temperature changes or minor impact. Entire crack feels smooth interior exterior glass as if the crack is in the inner layers of glass windshield. Due to multi complaints & prior class action lawsuit regarding manufacture defect of KIA windshields I am reporting my complaint as it is quite similar to others complaints, issues & lawsuits. The massive crack in windshield is a driving safety hazard & a manufacture defect that needs recalled & resolved before injury or death occurs. KIA must acknowledge, issue recall &/or post a bulletin, accept responsibility this is a manufactures defect, notify the public and replace the windshields under Good Faith Customer Relations Warranty

NHTSA #11706746

What I assume happened to my wiper blades: In December of 2024 we got a lot of heavy snow. I turned on my car to heat it up while I worked on cleaning off the outside of the car. My wipers were set to auto so the car automatically tried to clear the snow from the windshield. I did not notice this since they didn't move due to the snow weight. Once snow was removed I noticed the wipers did not work so I brought it in for the dealership to look at it. They determined that the gear had been stripped and needed to be replaced and informed me that this is not covered under warranty. Since the repair I have not driven the car in snow, no longer use the auto wiper function, and am sure to clean off all snow/ice before I turn the blades on. End of February I turned the wipers on to clean the windshield by pulling lever back. No fluid came out, the blades went back and forth a few times and then only one blade started coming up while the other lay in its off position. Determined that my car is not holding any wiper fluid (unsure if this was not connected properly during last repair). Have an appointment to get the car looked at again.

NHTSA #11646044

The contact owns a 2024 Kia Sportage. The contact stated while the vehicle was parked, the windshield cracked without impact. No warning light was illuminated. The vehicle was not taken to a dealer; the vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 23,000.

NHTSA #11622218

The contact owns a 2024 Kia Sportage. The contact stated that while driving at undisclosed speeds, or while the vehicle was parked, the engine intermittently hesitated and the vehicle almost shut off. The contact stated that the START/STOP button was depressed to shut off the vehicle; however, the button became inoperable. The vehicle was turned off and restarted to resume normal operation. The vehicle was taken to a dealer, but the failure could not be duplicated. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 18,700.

NHTSA #11744708

When we were entering a major intersection, car strolled and rolled forward and stopped 3/4 thru the intersection. It would not restart immediately while cars were speeding by on both sides. It finally started. This is the second occurrence we took the car into the KIA dealership. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11656699

Since day one of my purchase I noticed All warning light turned on and goes off while driving over an hour I thought it was normal as it’s my first Kia so continue to drive and it did same when ever I go on long drive and after 2 months it started vehicle to loose power and I always has to stop and restart the engine. Continued with same issue and all of a sudden it stopped on interstate and this time the car bogged out and engine shut off which was a dangerous situation for my whole family as cars behind would have hit us and cause multiple car collision I called my dealership to add this issue on my appointment for first service so it can be taken care of and I dropped off the car at dealership and after road test they confirmed that yes it has issue where multiple lights comes on and off so they don’t really know what’s causing the issue but will try to change the infotainment screen which they think is the issue might solve it so they kept my car for more than 90days and got my car back with scratches on dash and digital display bit shaky but according to milestones look like they tested if the issue been solved. ????

NHTSA #11669615

All the dash lights come on randomly has happened 3 separate times the 4th time they came on I also couldn’t shift out of park.

NHTSA #11658802

While driving my 2024 Kia Sportage PHEV X-Line AWD the instrument panel went black for 3-5 seconds and appeared to be "re-booting/resetting". The first time this occurred was approximately March 2025 (odometer reading approximately 6000 miles) and the issue has re-occurred numerous times (30+) since then (current odometer reading is 12,410). There was no warning prior to this happening and there were no warning lamps, messages, or other symptoms of any problems with the vehicle. I took the car into my local Kia dealer to have them check the instrument panel issue under warranty and to perform the recommended 8000 mile service. During the service visit they addressed the SC322 - Hybrid Control Unit Software upgrade recall. With regards to the instrument panel issue, the Service department told me that they could not fix the issue under warranty unless they could reproduce the issue. Therefore any work that they would perform to address the issue would have to be paid for by me. They suggested that I try to capture the issue on video as evidence of the issue. Given that the event only happens over a 3-5 second period, there is no way for me to safely videotape the issue while I am driving the vehicle and I have no idea when it will happen again. This issue has continued to occur randomly multiple times since that service visit with the last event happening three days ago. When the instrument panel goes black it is very distracting to the driver and draws your attention from the road to the instrument screen which puts the occupants of the vehicle at risk as well as others driving/walking around your vehicle. I have read online of others having this same issue with no clear consistent resolution from Kia. I strongly believe that this is a serious safety issue for many Kia drivers and needs to be addressed via a recall or voluntary dealer campaign to avoid unnecessary crashes/injuries.

NHTSA #11678731

The digital instrument cluster panel goes blank intermittently and without warning while I am driving.Within moments, the instrument panel reads: "System Reset". The information then reappears on the panel, displaying important information (speedometer, fuel gauge, etc.). My speed, however has been significantly reduced. I was driving on the highway at 70 mph when the instrument panel shut down (went blank). When it reappeared after "System Reset", I was going 48 mph.I believe this is a safety issue as it fails to comply with the requirements of Federal Motor Vehicle Safety Standards 101 "Controls and Displays and 138, "Tire Pressure Monitoring Systems". Also, the car is dangerous as I have no control over my speed. I could easily get rear ended by another vehicle which is another safety issue because the lithium batteries in this hybrid plug-in are in the back of the vehicle. This has occurred four times. The 2023 Kia Sportage Plug-In Vehicles were recalled due to this same problem. I am requesting the 2024 Kia Sportage Plug-In Vehicles are issued a recall also.

NHTSA #11626682

Trim parts came off roof traveling on highway.

NHTSA #11635184

The glass panel placed between the windshield and the Panoramic sunroof blew out with no external forces. Looking at other cases from online, this appears to be a problem dating back to the 2019 model. Attached are photos from the date of incident (12/31/2024) from 1/3/2025 and 1/17/2025.

NHTSA #11636634

Sunroof explosion

NHTSA #11625831

Forward collision warning systems check error light hard braking occurred and scared the pee out of me. Camera blockage obstruction error

NHTSA #11725384

While driving in cruise mode at 70mph in the [XXX] , the vehicle suddenly accelerated to 110mph. I detected the issue when I felt the car speeding up by itself, so I proceed to brake to avoid any accidents. As you might already have noticed, this is a major safety concern. I tried setting the car to cruise mode again, and it repeated the same action. The car was sent to the dealership, but they couldn't fix the issue. Reset the car and apparently was solved. Two months later, while driving my daily commute, the car repeated the same issue stated above. This time I had a car closer and could avoid to have a major issue by quickly braking the car, as the car quickly increased the power to reach the 110mph that for some unknow reason is doing by itself. I sent the car again to the dealership, they couldn't fix the issue and it's been in maintenance for over 55 days. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11617002

In January 2026, my wife was driving our 2024 Kia Sportage Hybrid EX downhill in traffic when the hybrid system failed without warning. Cabin filled with smoke, lost steering control, and explosion shook the vehicle. She was surrounded by other vehicles and could have been killed or caused multi-car crash. COMPONENT FAILURE: Dealership diagnosed hybrid system failure after 2.5 weeks. Vehicle at dealership awaiting repair. Failed components available for inspection. SAFETY RISK: Zero steering control downhill surrounded by traffic. Smoke impaired visibility. Explosion posed fire risk. Life-threatening danger to occupants and other motorists. DEALER CONFIRMATION: Yes, confirmed by dealership. Repair pending. WARNING SYMPTOMS: None. Instantaneous catastrophic failure. CRITICAL ISSUE: I discovered Kia issued service campaigns for 2024 Sportage Hybrids directly related to this failure: Service Campaign SC322 (January 2025) - Hybrid Control Unit software failure affecting 2023-2025 Sportage Hybrids built Feb 2022-Jul 2024 12V Battery Overcharge Campaign - Battery Management System overcharging causing loss of motive power and "Check Hybrid System Stop Safely" warnings SC319 (NHTSA 24V-422) - Motor-Driven Power Steering contaminated circuit board causing loss of power steering Never notified of campaigns despite being owner since May 2024. NHTSA shows zero recalls, falsely indicating safety. By classifying defects as "voluntary service campaigns" instead of safety recalls, Kia avoided mandatory federal notifications. My wife drove with multiple known defects Kia failed to disclose. Vehicle under 2 years old, within warranty. This catastrophic failure and notification failure warrants NHTSA investigation. There was smoke and we called 911 and the fire department came out.

NHTSA #11716349

I am writing to report a serious and dangerous issue with my Kia vehicle that is putting my life and my family’s safety at risk. While driving, the engine shuts off completely whenever I come to a stop or press the brake pedal. I then have to manually restart the engine to continue driving. This happens frequently, including while I am in traffic or on the highway. I have come very close to being hit by other vehicles multiple times while my children were in the car. I already brought the vehicle to a Kia dealership, and they informed me that the issue was fixed. However, within one week, the same problem started again. This clearly indicates that the problem has not been resolved and may be due to a manufacturing or system defect. I cannot continue to drive this vehicle under these conditions. I am requesting immediate assistance to ensure my vehicle is either: Properly repaired and guaranteed safe to drive, or Replaced with another vehicle if the defect cannot be corrected. Please treat this as a high-priority safety matter. I am sending this email as official documentation that I have reported this issue to Kia Headquarters in case anything happens to me or my family while operating this vehicle. I expect a prompt response and resolution. Thank you for your urgent attention to this matter. Sincerely, [XXX] [XXX] [XXX] [XXX] Vehicle Information: Make/Mode: 2024/kia Sportage VIN: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11693258

A month after buying my vehicle in February of 2024, while driving my vehicle the screen behind my steering wheel will black out and come back on and do a system check as if I had just turned my car on. It happens at all times of day, at all speeds. I kept a log of some of the incidences and there are no two that are the same. I have even been in park with the car on and it will happen. When you are driving with cruise control on and it does it the cruise control shuts off then comes back on after it has done the system check again. This is extremely dangerous while driving on the interstate and a line of cars around you. I have taken it to the dealership and they have worked with Kia to try to figure it out and still have not been able to. I am now going on almost two years of this happening without any resolution. Below I put the last time it happened but this happens ALL the time and is not one isolated incident. I have attached a log I kept for two months of the incidences.

NHTSA #11705254

The dash on my sportage will go black while driving, and then the system reboots showing "system check" the cruise control also goes out when this happens. This happens about once a month. Dealer has checked it more than 3 times and has found no issues except the first time I brought it in.

NHTSA #11685920

Not safety but I couldn't locate the complaint section you supposably have. The front rotors had to be turned with less than 18K miles. They have since been completely replaced twice at my expense and the car is less than 2 years old. Now the rear rotors have issues and it's going to cost me $360 to turn them or $700 to replace them. The dealer says it's either my driving or the weather. I've have literally been driving for 40 years and have never had to replace rotors. As for weather, unless Columbia, MO has some special weather that eats rotors that is not the case either. A parts counter employee told us it was an issue with the axle and that until we find a service tech smart enough to fix it, we'll just keep replacing rotors. He said he worked for Toyota, and they had the same issue. The Kia tech said he had no idea what he was talking about so again, we're paying to replace parts on a less than 2-year-old car and they won't even warranty their repair work. There is obviously something very wrong with this car.

NHTSA #11675759

Front brake rotors are warped on new 2024 KIA Sportage with only 4000 miles on the vehicle. The vehicle is available for inspection anytime When braking the steering wheel will pulsate left to right The problem has been confirmed by the dealer as an ongoing problem with this vehicle brand and model. The vehicle is scheduled for repair on October 15, 2024 I have been advised that the front brake rotors will be re-surfaced and not replaced. I have also been advised that KIA will NOT perform a second repair

NHTSA #11617100

While driving, the vehicle engine shut off while making a turn. Before the engine stalled, the engine began to sputter as I made the turn. I was stranded on the roadway as I could not restart the vehicle. For my safety, I stayed in the vehicle as there was no shoulder and many vehicles including dump trucks. Several attempts to restart the engine were unsuccessful - the engine would try to turn over and then stop. I contacted roadside assistance and the car was towed to the dealership. Diagnosed as a Faulty Fuel Pump/Bad Connectors. Approximately 8950 miles. This is the second time the car stalled while driving.

NHTSA #11650023

While in use, the vehicle engine shut off while making a turn. Several attempts to restart the engine were unsuccessful - engine would try to turn over and then stop. Vehicle was pushed off the road and roadside assistance was contacted and car tower to the dealership. Diagnosed as a Faulty Fuel Pump. <900 miles

NHTSA #11605235

My sunroof shattered without anything hitting it.

NHTSA #11648622

While driving down highway, roof molding came loose and started to bang against the roof by flopping.

NHTSA #11613557

Car brakes automatically applied, for no reason. I was driving in a city street, around 20 or 30 mph. The car randomly applied the brakes (hard) then released the brakes. I was able to continue driving after. But the braking made me jerk forward to the point that it locked my seatbelt. It was raining. But the road was completely open, no obstacle.

NHTSA #11629660

Since leasing this SUV and experiencing the safety features for the first time, the method this manufacturer used for zero crashes methodology seems thought out and looks refined in its final product; however, there is a strong safety issue at hand. That safety issue revolves around the driver not having full response and other drivers reacting to that. For example, when I back out of my own driveway or a parking spot, water on my rear camera will immediately jam on my brakes. Since I didn't do that as a driver and there isn't an apparent danger, it is not only a human performance issue for the driver but also for other drivers on the road. Next, when I install a bike rack on the rear of the SUV, I have to reverse while overriding the rear parking brake at the same time which is added complications. This also isn't perfected so often it also jams on the brakes. While all of this is happening, the safety sounds and camera views on my screen are changing automatically.

NHTSA #11627650

Tire pressure monitoring system (TPMS) is not working correctly. It is under reporting pressure by over 3-5 PSI on Cold and Hot Tire. My vehicle is available for inspection upon request. TPMS is flagging in the system and pushing to over fill tire with air over prescribed pressure by the manufacturer. It is safety risk. I got my vehicle air pressure checked twice in 2 weeks by a national tire chain shop. It didn't happen before. it is first time. Issue first appeared 4 weeks back.

NHTSA #11623808

I recently bought this vehicle and there was no spare tire. I was aware there was no spare, but I was not aware none were available for purchase! My problem is that Kia has not certified a compact spare tire for this vehicle and probably wont for two model years. I understand the manufacturers can sell vehicles without a spare tire, but consumers are UNABLE to purchase a spare on their own for two model years! I believe NHTSA should at least require them to have a certified spare available for consumers to purchase before they can sell the cars to the public. In my opinion, this is a safety issue that could leave motorists stranded on the side of a road somewhere.

NHTSA #11581005

The contact owns a 2024 Kia Sportage. The contact stated while driving 25 MPH, the check engine warning light illuminated. The vehicle was able to restart on the third attempt; however, the failure recurred. The vehicle was driven to the dealer but was not diagnosed or repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was 17,000.

NHTSA #11618581

I was stopped at a red light in middle lane with traffic all around when the car just stopped running. After a few tries it started again.

NHTSA #11591820

24 hours after purchase, the steering wheel had high vibration and was worrisome to drive. Returned to dealer and was originally told I break too hard- before they kept the vehicle for 8 days. They claim the rotor was replaced. Everything I am experiencing for my first car is sounding unreasonable. Why would a new model off the dealer lot have a rotor issue and why can my dad replace his breaks in 3 hours but a dealer takes 8 days. I’m not sure what is wrong with my vehicle but wanted to report it in case something happens.

NHTSA #11598571

While driving the car on road, I suddenly started getting all types of warning regarding different safety system and power steering wheel. The steering wheel was stuck/frooze while I was at 40-50 mph and couldn't turn it at all. With lots of difficulty was able to pull the car and get it towed. This put us as serious risk of danger as if this was on freeway would have been dangerous to not have functioning steering wheel. Before this similar issue had occurred but while in a parking lot so was not serious but happening while on road is extremely dangerous. After the repair said it was fixed, the problem was experienced a 3rd time while driving again but since car was slow was able to pull it on side. There seems to be a serious defect in car but car manufacturer is not able to repair it and putting lives in danger

NHTSA #11588359

Sudden Unintended Acceleration – 2024 Kia Sportage – Safety Hazard. Incident Date: April 18, 2026. Location: Parking lot. While pulling into a parking space at low speed, I brought the vehicle to a complete stop with my foot on the brake. Immediately after stopping, the vehicle suddenly and forcefully accelerated forward on its own without my foot on the accelerator. I was actively pressing the brake pedal, but the vehicle did not respond as expected and continued to accelerate. The acceleration was strong enough that the vehicle jumped over the parking bumper with both front tires and struck a fixed post. Even after impact with the post, the vehicle continued to push forward as if still accelerating, until it hit another barrier and finally came to a stop. At no time did I press the accelerator pedal. The vehicle’s behavior felt completely uncontrolled and unsafe. This incident could have resulted in serious injury or death if it had occurred in traffic or with pedestrians in front of the vehicle. The vehicle has been towed to KIA dealership and is pending inspection. I am reporting this as a serious safety defect. No injuries. Front-end damage after collision with post. This event was sudden, unexpected, and not driver-induced.

NHTSA #11732588

The contact owns a 2024 Kia Sportage. The contact stated that while driving at an undisclosed speed, the sunroof exploded. The contact stated that there was no evidence of an impact on the sunroof glass. The dealer was made aware of the failure. The contact was advised to take the vehicle to a Collision Center for assistance. The vehicle was taken to the Collision Center, and the contact was informed that the failure was a known failure with similar vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact was advised to contact the NHTSA Hotline and the manufacturer to report the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 28,525.

NHTSA #11715023

While driving, the vehicle experienced a sudden loss of propulsion and significantly reduced acceleration. At the same time, the climate control system stopped producing heat. A red warning message appeared instructing me to stop safely. The vehicle would barely accelerate, creating a dangerous situation while driving. This issue has occurred three separate times, including twice in the same day. Each occurrence happened while the vehicle was in motion. The condition resolved only after turning the vehicle off and restarting it. The issue is intermittent and cannot be predicted. The reduced acceleration and loss of propulsion placed my safety at risk, especially at highway speeds, as the vehicle could not respond normally to traffic conditions. The vehicle was taken to a Kia dealership and inspected. A manufacturer tech line case was opened, and testing was performed, including a smoke test. The dealership stated they were unable to duplicate the issue. No repair was made, and the manufacturer closed the tech line case despite the reported loss of propulsion events. The vehicle is currently being retained at the dealership because I do not feel it is safe to operate. The problem was not resolved.

NHTSA #11711940

While driving my 2024 Kia Sportage Hybrid, the vehicle displayed the warning message “Check Hybrid System – Stop Safely.” Immediately after this message appeared, the vehicle lost propulsion and entered a reduced power/limp condition. This creates a dangerous situation because the vehicle can suddenly lose power while driving in traffic. The dealership informed me that this condition is related to a known hybrid system defect but refused to repair it, stating it was “not under warranty.” This is a safety-related high-voltage hybrid failure involving the propulsion system and can result in unexpected loss of power while driving, increasing the risk of a crash. This defect makes the vehicle unsafe to operate.

NHTSA #11709962

While attempting to park the vehicle in an angled parking spot I was pressing the brake and slowing to a stop. Prior to stopping with my foot still on the brake the engine revved and the vehicle surged forward hitting the car in front of me. The emergency braking did not seem to activate nor di my foot on the brake slow the car. The car has been in the shop at least 4 times totaling nearly 30 days for electrical issues. The vehicle had a full charge prior to the drive which was about 6.5 miles. The vehicle was operating in automatic mode utilizing electric only during the trip. What component or system failed or malfunctioned, and is it available for inspection upon request? Powertrain gas and electric emergency braking. It is at repair shop can be inspected How was your safety or the safety of others put at risk? Car accelerated without warning Has the problem been reproduced or confirmed by a dealer or independent service center? Dealer has video of engine surging when switching to electric only mode. I also have many videos. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Dealer only in service shop. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Had check engine light multiple times shorting after buying vehicle. Also has burning wire or rubber smell when charging. Engine RPM's surged when manually switching to electric only mode. Dealer service tech has video and I have multiple videos of this happening. Other items. Car dash says to place hands on steering wheel while hands are on steering wheel. Have video of this. Car has a surging sensation while driving slight gyro sensation. Automatic wipers slow to activate or reactivate during light rain. Have video. Electronics related to android auto and heat AC do not work right flicker disengage and reengage over and over. Have multiple videos of this.

NHTSA #11708271

Blank Instrument Panel Screen. abnormal CAN message which can cause certain instrument clusters with a 4.2” screen to reboot while driving. During this rebooting, the cluster will not show information such as the speedometer or telltales for approximately five (5) seconds. As a result, the subject vehicles do not comply with the visibility and illumination requirements of FMVSS 101, §§ S5.1.2 and 5.3.1

NHTSA #11708050

On December 24, 2025, while driving in traffic, my Kia Sportage experienced severe lurching, bucking, and jerking, causing the engine to shut down. All dashboard warning lights illuminated, including a message prompting me to "turn engine back on." The vehicle would not restart, necessitating a tow to Horne Kia. After several days of diagnostics, it was determined that a blown ignition fuse and a bad fuel pump relay were the issues, along with a battery replacement. However, just 19 days later, while attempting to merge onto the freeway, the vehicle again bucked violently, and the engine shut down with all warning lights flashing. The police had to assist in moving my vehicle out of traffic, and it was towed to Courtesy Kia in Mesa, AZ. Once again, no error codes were found. After further diagnostics, it was discovered that the same ignition fuse had blown and that the catalytic converter had "shattered." The catalytic converter was replaced. Upon picking up the vehicle from the dealership, and driving less then 5 miles on freeway, the vehicle was bucking and hard shifting once again resulting in a third tow to dealership just 48 hours later after the previous service. The dealership ran several diagnostics under Kia's tech line, which revealed that the engine pistons are slipping and not functioning properly, resulting in loss of compression. Per Kia's tech line, a new engine long block was ordered and replaced.

NHTSA #11725255

While traveling at approx 65 mph on a clear, debris-free Alaska highway in -5°F temperatures, the panoramic sunroof of my 2024 Kia Sportage spontaneously shattered with an explosive sound. There were no vehicles in the immediate vicinity (nearest car was maybe 50 to 75 ft away) and no observation of flying debris or falling objects from overpasses. The failure appears to be a spontaneous glass breakage (SGB) incident potentially caused by thermal stress or manufacturing defect rather than external impact. Crucially, some of the remaining glass fragments and one large attached piece are displaced and flexed OUTWARD (upward toward the sky). There are also fracture lines in the remaining glass along and parallel to the sides of the vehicle as well as parallel to the front frame of the glass. They do not radiate out from a central point as one would expect from an object strike. This geometry to me indicates internal tension or cabin pressure release, as an external impact from a projectile would have forced the glass inward into the cabin. Additionally, there was very little glass in the vehicle cabin, certainly far less than one would expect given the size of the opening in the sunroof and the amount of glass missing. I have personally previously been in a vehicle whose side window was blown out from a vehicle kicked rock strike and in that case was showered with a lot of glass. Yesterdays catastrophic failure resulted in some glass intrusion into the passenger cabin at highway speeds, creating a severe distraction with sound was loud & sudden enough to potentially cause a loss of vehicle control. I am aware of similar reports regarding the 2023-2024 Sportage (and previous Kia panoramic sunroof class actions) regarding the use of ceramic glazing or assembly stresses that contribute to such failures. I request an investigation into whether the current model's panoramic roof assembly is capable of withstanding extreme thermal differentials and body flex.

NHTSA #11706279

The sunroof shattered while driving without any sort of impact.

NHTSA #11701591

The contact owns a 2024 Kia Sportage. While the contact’s daughter was driving approximately 70-75 MPH, the vehicle suddenly lost motive power. The driver was able to coast to the side of the road, where the vehicle was turned off for several minutes. The driver then activated the jump-start system of the hybrid vehicle. The driver was able to continue driving. The message "Hybrid Battery - Hybrid System Failure" was displayed. The vehicle was taken to an unknown dealer, where it was confirmed that the vehicle was included in a Voluntary Emissions Service Campaign: SC338; and the dealer completed the Service Campaign repair. No further information was available. The manufacturer was informed of the failure, and a case was filed. The failure mileage was 19,832.

NHTSA #11701683

Description of Crash: On [XXX], I was involved in a front-end collision while driving my 2024 Kia Sportage. Despite the impact, the airbags did not deploy. Additionally, the Forward Collision Assistance system did not engage or warn me prior to the crash, even though conditions were normal and the system was active. Safety Concern: •The airbags and collision assistance are federally regulated safety systems. Their failure put me and any potential passengers at serious risk. •I am very concerned this indicates a defect in the airbag and/or collision avoidance system. Damage/Injuries: My front end of my vehicle is completely destroyed, and so is my engine. As for myself I am experiencing some soreness and discomfort Requested Action: •I request that Kia and NHTSA investigate this failure as a potential safety defect. •I want confirmation that my case has been documented and reviewed for possible recall or repair action. State Farm Claim #: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11690901

While driving the vehicle and selecting EV only mode the engine RPMs surge to about 3000. This happens frequently and I have it on Video. Kia has had the car multiple times for electrical may electrical related repairs but say the vehicle is normal. The tech line person even had the dealer drive a similar car for a baseline. I would expect they had a baseline prior to manufacturing the car. This is an ongoing unrepaired issue. Date below is first reported date of electrical concerns.

NHTSA #11708265

The design of the backup light is awful. There is a single light that is about two inches long and an inch high under the license plate. When you back up in a parking lot like at Walmart, other drivers cannot see the light and keep driving by like you are not moving. We have had several close calls because of this. Kia should be forced to change the design

NHTSA #11686966

I am writing to formally raise a safety concern regarding my vehicle’s brake and rotor system, which has experienced premature failure on two separate occasions. First Occurrence: The issue was first identified prior to reaching 11,000 miles and was addressed by the dealership after surpassing 11,000 miles. The repair involved replacement of the rotors and bolts, but notably, the brake components themselves were not replaced. Second Occurrence: Around 23,000 miles, I began to notice progressively worsening shaking and a disturbing sensation of the brakes skipping or slipping—particularly during highway downgrades. By 24,500 miles, the issue had become significantly more pronounced. I returned the vehicle to Kia of Stockton at 25,248 miles. During my visit, Ricardo from the Kia of Stockton Service Department attributed the issue to “driver error,” citing hot spots on the rotors. However, he also acknowledged that during the initial repair, only the rotors and bolts were replaced—not the brakes. Ricardo further stated that Kia could not offer any additional support beyond a 10% discount on repairs, per his manager’s directive. I explained that I live and work locally, and my driving habits do not involve long commutes or frequent stop-and-go traffic. Given this, I strongly believe the repeated brake system failure points to a potential manufacturing defect rather than user error. Ricardo agreed that if this were his own vehicle, he would be concerned as well. This issue poses a serious safety risk—not only to myself and my family, but to other drivers on the road. In addition my vehicle has also experienced powertrain issues, where it feels as if the vehicle is stuck in 1st gear. I am therefore requesting a full investigation into this matter. If necessary, I would like to initiate the process of reporting this vehicle as a potential lemon under applicable consumer protection laws. Thank you for your attention to this urgent safety concern.

NHTSA #11685500

The car emergency brake component was faculty and kicked in at an inappropriate time. When the emergency brake occurs you are unable to move the car at all. Being unable to move put myself and my passenger seater at risk for bring hit to which we were. The vehicle was not inspected due to Kia Corporate office not answering the phone.

Allegedly reported: 2 injuries (as reported to NHTSA). NHTSA #11687004

hello , my mom was driving . she had all the lane driving assist systems on. the driving assist , lane assist, forward collision assist, lane keeping assist, & cruise control. it had started to rain my mom tried to move over to the middle lane the steer wheel would not let her it pulled her back as if someone was on the side of her but it wasnt it then started driving by itself. the car started malfunctioning , it toke control my mom tried to get a hold of the wheel but the power assit would not let her. it then turned by itself and drove straight into a mountain. we hit it head on with no warning. we then flipped 5 times and landed upside down. the door and windows did not work we were trapped. the power was completely out in the car. my insurance company has inspected it and states that they think the car malfunctioned. i have called kia and they stated a engineer was suppose to go get the black box to get the data. it has been three weeks kia has stopped returning my calls. my insurance company is holding my car for 90 days. Please Help. It is availible for inspection .

Allegedly reported: 5 injuries (as reported to NHTSA). NHTSA #11678633

I hear rattling coming from the rear right side of the car. There is extreme loss of control of vehicle when it hits any bump or imperfection in the road or driving service, ranging from small transition in road surface to potholes and raised patches in road surface. Must continually work to maintain control of the vehicle when driving over these surfaces. This occurs at any rate of speed. It feels very unsafe to drive.

NHTSA #11661422

The doors won't lock. The button on the handle won't work sometimes. It's just random. This has happened 4 times in the last 2 years I have owned the car. I have to use app to lock and unlock the car. Once I drive it again everything is fine.

NHTSA #11652592

The contact owns a 2024 Kia Sportage Hybrid. The contact stated that while driving at 30 MPH, the vehicle came to an abrupt stop. There were no warning lights illuminated. The seat belt failed to secure her grandson, who was occupying the front passenger seat, and he flew out of the seat. The driver's seat belt failed to secure her, and she was thrust forward over the steering wheel. The contact called the local dealer, but there was no response. While driving at approximately 30 MPH, the vehicle came to an abrupt stop. There were no vehicles around. While driving at 30 MPH, the vehicle suddenly stopped, and an unknown pickup truck crashed into the rear of the vehicle. The contact was concerned about driving the vehicle. The contact sustained injuries to her neck, back, and left shoulder, which was torn, and medical attention was provided. There was no reported fire or airbag deployment. A police report was filed. The vehicle was towed to another local dealer, Raceway Kia 4044 US-9, Freehold, NJ 07728, who determined the vehicle was working as designed. There were no codes displayed during diagnosis. The vehicle was not repaired. The manufacturer was contacted, who opened a case, but no additional assistance was provided. The failure mileage was approximately 3,200.

Allegedly reported: 1 injury (as reported to NHTSA). NHTSA #11646290

The Dashboard with all the instrumentation goes blank while driving causing loss of all instrumentation gauges and headlights shut off. This has happened repeated times since the car was purchased new in June 2024 and has been in the service department since October a total of six times. They have replaced fitments, the dashboard cluster, the phone charging pad and have done multiple software updates and it continues to go blank while operating. The dash then lights back up with System Check and all the instruments lights in dash glow and it stays like that for several seconds. I am repeatedly told they cannot recreate the problem to properly diagnose so they have been cherry picking solutions to fix and it’s dangerous to drive. I have filed a complaint with the NC Attorney General, a BBB Auto Complaint, a Complaint with the Manufacturer directly and they are telling the dealer to return car to me because they can’t recreate the problem and so in their opinion nothing is wrong when I have video of this happening while driving. Please help me

NHTSA #11650407

The ECU malfunctioned and the passenger side airbag didn’t go off and should have. There were error codes and I told KIA service department about it but they weren’t to concerned and said they would look at it at my first service appointment

Allegedly reported: 2 injuries (as reported to NHTSA). NHTSA #11642932

When I was driving the vehicle using cruise control, the vehicle suddenly reset the cruise to 110 mph and the vehicle surged forward. The brake disengaged the acceleration but when I reengaged the cruise control it surged toward 110 miles an hours again. The only fix for this was to turn the car off completely and then the cruise control acted normally once again. Then it happened a second time. After that I quit using cruise control. I brought the vehicle in to Luther Kia of Bloomington and they did not know how to fix it. They contacted Kia who said their engineers were working on a fix and they were aware of the problem but at this point they did not have one. I have engaged a buyback Request from Kia because this vehicle is unsafe and potentially fatal to drive. They have denied my buyback request. I am reporting this because I think it is a danger to not only myself but other vehicles on the road.

NHTSA #11625184

The infotainment screen goes out randomly while driving and can stay off for the entirety of the trip. That includes the speedometer, check engine light, fuel gauge, etc.

NHTSA #11601022

The contact owns a 2024 Kia Sportage. The contact stated that while attempting to park in his residential carport, the brake pedal was depressed the brake pedal was stiff and did not move down as intended. The contact used excessive force but the vehicle failed to come to a stop. The vehicle collided with the screen room of his residence taking out three of the four walls of the patio. There were no injuries. A police report was not filed. The vehicle was towed to a dealer where the failure was not able to be replicated. The manufacturer was not notified of the failure. The failure mileage was 6,100.

NHTSA #11600203

While traveling on a 4-lane highway and using cruise control, a car in the left-hand lane was making a left turn across a median cut through, and my car's sensors detected a collision and took me from 60 mph down to 35 mph in about five seconds. If a car had been behind me, it would have rear ended me. I no longer use the cruise control for this reason. And yes, my sensors were clean. I had just gotten the car cleaned within a day or two prior. I have an appointment this coming Monday to take it to the dealership, to have them look at it. Separate incident. While parked in a parking lot, came out of restaurant and cars were parked very close on either side of my car. My car's sensors detected collision and would not let me back out. I had to pull forward and try to go back numerous times before it finally released the collision warning and allowed me to back out. This happened many months ago, but I am just now having the time to take it and drop it to the dealership because they want to keep it all day.

NHTSA #11641033

Two issues that I've taken to dealership 3 times since purchasing vehicle January 2024. 1. Adaptive cruise control -- I was in right lane of 4 lane highway with cruise control on. A car in left lane took a turn to cut through median and my car thought it was a collision and hard braked and took my vehicle from 60mph to 35mph in a few seconds. If a car had been behind me, I would have been rear ended. They cannot "replicate" so I no longer use cruise control unless there are no cars around. 2. Timing has been off (loud clicking every time I crank) since a few months after I bought the car. I sent approximately 9 videos to the service advisor. Took it in 2 times "cannot replicate." Left it overnight at dealership "cannot replicate." It's every time I first crank for the day. It's now louder and gotten worse. I have videos and can take more. I just want this fixed. Afraid I'll be stranded and it feels like they are pushing it farther and farther out so it will exceed warranty and they won't have to eat the cost to repair. It's been 1.5 years I've been dealing with this. Any help you can provide is greatly appreciated!!

NHTSA #11693745

The contact owned a 2024 Kia Sportage. The contact stated that while driving at 77 MPH, the vehicle was involved in a front-impact crash with a large-sized deer. The air bags did not deploy. The contact stated that two minor children were seated in the rear seat. The vehicle was towed to a local tow yard. No injuries were sustained. No medical attention was administered. A police report was filed. The vehicle was condemned as a total loss by the insurance company. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 22,500.

NHTSA #11581139

The sunroof exploded all of the sudden. I was driving on the I-675 highway toward Wright-Patt Air Force Base and the sunroof exploded, barely maintained vehicle control. The shattered glass hit my head and my child legs. Some glass sand enter my eye. I manage to pulled over and check my car interior for any strange/outside object but there was no external object, nothing. Called the police, they also inspect the vehicle and found nothing. I’m very concerned about this, could cost our lives. Drop the car at the dealership and they said that definitively was a manufacturing defect.

NHTSA #11557569

On October 22, 2023, we made a restroom stop at an ARCO in Moapa, NV. I was in the car while my wife used the facilities. It was a clear day with the temperature in the mid 70s. As I backed out of our parking space I heard a loud pop. I checked to see if I had run over something or had a flat. I saw nothing. I got back onto the interstate and about 2 miles later I heard a loud pop and in my rear view mirror saw debris flying from our car. I pulled off the road and again checked my tires. I then checked the roof and saw that part of the sunroof glass was gone. This was a new car only 23 days old, with only about 550 miles on it. It had never been on rough roads. We had never opened the sunroof. We understand that this is an ongoing problem with sunroofs that use tempered glass. Please add ours to your investigation and fix the problem. It is at the Kia dealer now. They said they would check with KIA.

NHTSA #11551418