Toyota Tacoma 2025: Retiros, Quejas y Ley de Limón de California

Manufacturer Recall Number25TB11 NHTSA Recall Number25V656 Remedy has been pending for over 7 months! Concerned that I could be stranded if the vehicle drive shaft joint fails when off roading.

NHTSA #11743810

The contact owns a 2025 Toyota Tacoma. The contact stated that she received an email for NHTSA Campaign Number: 25V656000 (Power Train). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The contact stated that the dealer failed to alert her of the recall prior to the sell. The manufacturer was contacted and referred her to the local dealer. The contact had not experienced a failure.

NHTSA #11738127

The contact owns a 2025 Toyota Tacoma. The contact received notification of NHTSA Campaign Number: 25V656000 (Power Train); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer, where it remained since October 2025, while the contact drove a rental vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA #11732393

I went to open my drivers side door to get out, and the handle just flopped around and didnt open the door. Driver side door opener handle doesn't work. Have to roll down driver side window with truck engine on and lift outside door handle to open driver door. In case of emergency, and no power in truck, I would not be able to get out of my drivers side door.

NHTSA #11744724

Front passenger door handle broke under normal use exiting truck resulting in inability to open door from inside, entrapping occupant. Warranty claim filed with Toyota dealership. Dealer service advisor stated this is a common failure on Gen 4.Tacomas, and Tundras. Part is on backorder. Service advisor stated backlog is large and no time estimate can be given when the repair can be made. This can result in entrapment in an accident if side windows lose power to roll down if capable of opening door from, or crawl in rear and exit through rear doors if child locks are not engaged. Recall is warranted.

NHTSA #11742223

The interior driver side door handle on my 2025 Toyota Tacoma failed and wouldn't open the door from the inside. I had to roll down my window to open from the outside. The dealership replaced the handle assembly under warranty. This happened at around 9300 miles on the odometer.

NHTSA #11740765

Vibration when accelerating, coasting or braking 25-45mph. Driveline issue that affects performance of the truck

NHTSA #11693025

You can copy and paste this link into your browser if its not click able, to see video of the event! I got pieces of glass into my eyes [XXX] Video of the Event This is what I sent to Toyota and the Dealer Toyota of Pharr, as I get ready to take it in for repair but they told me to make a claim on my insurance, when it was literally a defect with the glass Warranty Claim – Defective Sunroof Shattering (2025 TRD Pro) To Whom It May Concern, I am the owner of a 2025 Toyota TRD Pro currently under the New Vehicle Limited Warranty. While driving, the sunroof on my vehicle shattered spontaneously without any external impact. I have video evidence clearly showing the glass cracking, with no rock strikes or other outside causes. This failure I feel is a defect in materials, not outside damage, and therefore falls squarely under Toyota’s New Vehicle Limited Warranty. The warranty specifically excludes glass damage only when caused by external objects; it does not exclude spontaneous failures like this one. For my safety and the integrity of the vehicle, I am requesting that this repair be processed under warranty without delay. I’m risking water to enter the vehicle which will cause more damage. Please document and submit this claim to Toyota Corporate. I also feel I need to help the public of future Tacoma TRD Pro buyers and owners and file a formal defect complaint with NHTSA, as this type of spontaneous glass failure represents a significant safety concern. I respectfully request written confirmation that this will be covered under warranty and ask that you proceed with the repair promptly. Thank you for your immediate attention to this matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11687616

I think it’s a serious safety issue for Toyota not to include a trailer brake controller or at least a connector to install an aftermarket trailer brake controller on my truck. This has been mentioned numerous times by customers. My truck is rated to tow 6,400 with no way to add a trailer brake controller. I don’t see how Toyota can legally sell this truck without at least giving an option to install an aftermarket controller, even though Toyota doesn’t recommend it.

NHTSA #11684099

The driver's side window switch panel failed and caught on fire. It is available for inspection.It will be towed to a toyota dealership tomorrow. Nobody was in the vehicle when the fire started. The problem has not been confirmed or reproduced by a dealer. The vehicle has not been inspected, is going in for inspection tomorrow. There was no warning or indication prior to the fire starting.

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11735950

My 2025 Toyota Tacoma has an ongoing issue where Apple CarPlay frequently disconnects or fails to connect altogether. This happens both at startup and randomly while driving. The problem occurs across multiple iPhones, different cables, and even after ensuring that both the phone and the truck’s software are updated.

NHTSA #11698577

My 2025 Toyota Tacoma TRD Pro (VIN [XXX] , purchased from Delaney Toyota, DuBois PA) exhibited a recurring Smart Key and door lock malfunction beginning in late October/early November 2025 and continuing through the date the vehicle was traded in February 2026 with the defect unresolved. Symptoms observed: Doors locking autonomously on exit, sometimes before occupants could exit the vehicle System falsely detecting the key fob as being inside the vehicle when it was in the owner's pocket outside, causing the truck to refuse to lock Touch-lock refusal at the door handle Random unprompted beeps while parked and locked with no corresponding lock movement Key card unable to lock the vehicle Dealership witness: During a January 2026 service visit, Delaney Toyota Service Advisor Ricky Carlson was personally locked inside the vehicle by this malfunction before he could exit. This was witnessed firsthand by a trained Toyota service employee and is part of the service history, though it was not captured in the official repair order. Service history: December 22, 2025 — RO #XXXX, no codes found, TAS case opened January 21, 2026 — RO #XXX, TAS case XXX, technician unable to duplicate, no codes found February 9, 2026 — RO #XXX, TAS case XXX, dealership driver witnessed false key-in-vehicle behavior directly when owner demonstrated it on arrival, behavior self-resolved before service bay access, no codes found Additional facts This defect never generated a diagnostic trouble code across three service visits Toyota Corporate case XXX was opened and closed without resolution Toyota arbitration case XXX was also closed without resolution The identical defect has since appeared on a replacement 2026 Toyota Tacoma TRD Pro (VIN [XXX] ), currently under active Toyota Corporate case #XXX The vehicle was traded in February 2026 because Toyota Corporate failed to resolve the defect within the warranty window INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11725346

*Steering system - tie rod / steering nut lock was loose and discover after alignment service * Loose tie rod nut created a potential safety risk because it involves a steering component related to vehicle control. This could have put me, my passengers, and others drivers at risk if the condition had worsened while driving. *No, the condition has not yet been confirmed by a dealer or independent service center. I noticed abnormal steering/handling, inspected the vehicle myself, and discovered a loose tie rod nut. The vehicle is available for inspection upon request. *No the vehicle I available upon request *No

NHTSA #11733479

Clunky sounds from the drive shaft it's hard to steer while in 4x4.

NHTSA #11691330

The vehicle is unstable and easy to lose control! The vehicle height is asymmetrical! The vehicle body shakes! The tires are abnormally worn! The geometry deviation of the vehicle's rear axle is too large

NHTSA #11675769

The contact owns a 2025 Toyota Tacoma. The contact stated that while driving at approximately 10 MPH, the rear driver's and passenger’s side rotors and brake pads suddenly detached. No warning lights were illuminated. Upon further inspection, the contact became aware of metal debris on the ground by the rear wheels. The vehicle was scheduled to be towed to a local dealer for further investigation. The vehicle was not diagnosed or repaired. In addition, the contact related the failure to NHTSA Campaign: 25V058000 (Service Brakes, Hydraulic); however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 18,000.

NHTSA #11744415

The contact owns a 2025 Toyota Tacoma. The contact received a notification of NHTSA Campaign Number: 25V058000(Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The vehicle was left at the local dealer for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA #11666564

Less than 5000 miles - seat popping and cracking noise. If you look it up online, a lot of the 4th Gen Tacomas are doing this but when you take it to a dealership they say that is normal. It feels like the seat will break and moves around alot but Toyota will not acknowledge the issue at the dealership and has no fix. Seems unsafe.

NHTSA #11732972

Right Front Seat cushion appears to be collapsed / defective. Was present at 29 miles. Dealer looked at it, and dismissed it as not there problem. Started a case with toyota North America, and they're refusing to acknowledge any problem. The passenger seat is noticeably collapsed compared to drivers seat. I have since parked the vehicle as I feel it is unsafe to drive. I bought this truck new the week of Thanksgiving 2025. I fear that the seat may structurally fail during an accident, thus injuring any passenger in that seat.

NHTSA #11711050

My father and I both purchased a 2025 Toyota Tacoma SR5 2WD double cab last year brand new from different dealerships, both were in FL. My father was driving his new Tacoma with adaptive cruise control engaged, this was on an interstate, and the vehicle in front of him moved to the left lane next to him and started braking and this caused his vehicle to start braking extremely hard with no vehicles in front of him (he was driving about 55mph when this happened). He said this has happened to him before. I was in the vehicle with him when this happened. When I was driving from his home in GA a few days later, back to my home in FL, I was on the interstate ([XXX]) with the adaptive cruise control engaged and the exact same thing happened with my truck. A semi truck in front of me moved into the lane to the right and started braking. This caused my vehicle to start braking extremely hard with no vehicles in front of me. Had a vehicle been behind me, this could have caused me to be rear-ended going about 70mph. The sudden automatic braking with NO vehicles in front of you is aggressive enough to cause a rear-end collision and possibly cause the driver to make a startled, impulsive, corrective mistake to the sudden aggressive braking. Problem has not been confirmed or reproduced. Neither my father's or my vehicle has been inspected for this issue. Im betting its a software issue. No warning lights or messages before the aggressive braking in either mine or my fathers vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11744969

The contact stated that while driving in the rain, when passing another vehicle, the vehicle began shuddering and experienced a loss of power. The check engine light illuminated and multiple other warning indicators. The vehicle pulled over to the vehicle was stopped and eventually restarted. The vehicle was taken to a dealer were it was diagnosed with an air intake failure. Shortly after, the vehicle experienced the same issue. Again and was returned to a dealer. The dealer diagnosed with a turbo mud and water found inside the air intake, water is covering the filter and there was no additional repairs that could be completed so the vehicle. The manufacturer was not notified of the issue. The approximate failure mileage was 19,600.

NHTSA #11741639

On Sunday March 22, 2025 at around 1340, I was leaving my house and driving on a small incline and noticed my vehicle had a jerk when down shifting. This happened four times while traveling up hill. I have not yet had any repeat issues since this date.

NHTSA #11729199

My 2025 Toyota Tacoma engaged the emergency braking/pre-collision system system while my vehicle was going under 10 mph on a steep road in winter conditions. My vehicle was completely under control before the system engaged and there was no risk of a collision with any vehicles in front of me. The emergency braking system engaged and rendered my vehicle completely out of control. I tried desperately to pump the brakes in hopes I could regain control of the vehicle, but the brakes were fully locked. Had the brakes dis-engaged, I could have easily avoided the collision. The car not only did not decelerate, it accelerated down the hill while the brakes were locked for several seconds. My vehicle eventually slid into another vehicle that had been parked on the side of the road. From doing extensive research I believe a perfect storm of events caused this malfunction. Previously on this day, several inches of snow had fallen. The road had not been plowed and cars were parked on the side of the road. There was also a curve in the road near my vehicle's collision where the other vehicle was parked. My windshield was also still defrosting in the uppermost section near the rear view mirror. It is also possible the radar block on the front of the vehicle had snow or ice on it. It was also actively snowing. From what I have read, any of the above factors can cause a malfunction in the emergency braking pre-collision system. I had never been in an accident in over 20 years of driving and my vehicle did the least safe maneuver it could have in the given situation. There is no circumstance where one would purposefully slam the brakes on a snowy/icy down hill road if they know how to drive in the snow (even if you were going under 10mph as I was). At the most basic level of failure, I can't imagine this system should ever engage if going as slow as I was. Also, the system is designed to decelerate (was accelerating) and I was pumping brakes in effort to disengage

NHTSA #11729275

Due to my husband driving the vehicle, ISP states it looks like he crossed into an oncoming semi-chip truck trailer, causing a fatal accident and killing him instantly. The 2025 Toyota Tacoma's Safety Sense obviously failed since my husband is now dead. We had the 2025 Tacoma in the prior week due to my complaints that the lane assist was not working properly and the screen did not respond to my touch to turn it on. After the fatal accident, ISP removed the black box to download information for the accident report. I am now waiting for isp report. No jaws of life was used to extract husband they didn't need it Tacoma metal already peeled back like a tuna can.

Reportado presuntamente: 1 lesión, 1 muerte (según lo reportado a NHTSA). NHTSA #11726018

When you fill up you gas tank the gas pumps are to thick to stick all the way in and it overflows the gas tank every time I have to put in certain amounts in per time

NHTSA #11718022

TIRE SIZE IS 245/75R17, NORAML DRIVING SPEED @ 70MPH AND GOT FLAT. THIS VEHICLE IS LESS THAN 8000 MILES AND ALREADY HAD (2) FLAT TIRES IN THE SPAN OF LESS THAN 6 MONTH, 1ST INCIDENT HAPPENED ON 9/08/2025 AND 2ND INCIDENT ON 12/10/2025.

NHTSA #11704426

MY 2025 TACOMA is part of a recall by Toyota, I was notified of the potential issue on early November 2025 and told Toyota was working on a remedy. On December 3rd, 2025 while using 4-wheel drive during a snow storm the drive shaft (recall issue) broke. On December 4th, 2025, the local Toyota dealer checked my Tacoma and found it unsafe to drive - they kept my Tacoma and provided a loaner vehicle. Toyota reported at this time the remedy would be available by the end of 4th quarter (December). As of today, February 21, 2026 -- there is still no remedy for the issue, my Tacoma is still sitting at the dealer, and I do not have my truck. Toyota reports a remedy will be available during the 1st quarter of the year but nothing yet. I called brand engagement recently and asked them to extend my warranty, Toyota care, and other free trials that were included with my purchase. However, Toyota refuses to do anything further - as they said a loaner car is enough - to make the issue more acceptable even though my new vehicle is losing this coverage.

NHTSA #11719623

The vehicle is a 2025 Toyota Tacoma TRD Off-Road subject to Safety Recall 25TA11 involving the front axle shafts potentially breaking. The manufacturer has confirmed the recall and that a remedy is not yet available. The vehicle has been at a Toyota dealership and out of service for an extended period while waiting for a repair solution. The dealer has confirmed that no repair can currently be performed because Toyota has not released a remedy. This defect creates a safety concern because a front axle shaft failure could result in loss of drive power and potential loss of vehicle control while driving. The problem has been confirmed by the dealership and manufacturer through the active safety recall notice. No warning lights or prior symptoms were observed before the recall notification. The vehicle is currently available for inspection at the Toyota dealership upon request.

NHTSA #11717017

I was driving to work when after running across a minor pothole I heard a clunking sound. It turns out it's the top cap for the front coil-over Bilstein shocks had broken allowing the shaft and the bump stop to protrude through the upper mounting plate. The coil did its job of keeping the vehicle suspended, but the shock piston has no ability to alleviate any stresses put upon the coil. Dealer states that because there was an outside contribution, i.e. a pothole, which had been driven around and over many times before, wasn't warrantable. There was no more than standard bump and sway than when driving around as usual. There was no shudder as though I was going too fast for the defect in the road. I dont know if there was pre existing stress damage from a recent collision(opposite corner of truck) or if the was a defect with the part. The top cap is made out of aluminum rather than steel, which I find disturbing after learning this is not the first to have broken. This vehicle has only been off pavement in gravel driveways and parking lots. I hope you can investigate this thoroughly.

NHTSA #11701753

Vehicle Cannot Be Safely Driven – Structural / Suspension Defect Suspected – Dealer Claims “Repair Completed” Despite Unequal Wheelbase My vehicle is currently unsafe to operate, due to the following critical issues: ⸻ 1. Left–right wheelbase inconsistency The front and rear wheelbase measurements are not equal side-to-side. This is a strong indicator of structural deviation, such as: •Subframe misalignment •Control arm mounting point displacement •Deformed suspension components •Manufacturing or assembly error in chassis geometry ⸻ 2. Front caster angles remain abnormal •Left caster: 3.9° •Right caster: 4.9° •Cross-caster difference: 1.0° A 1° difference exceeds manufacturer tolerances and causes: •Vehicle drifting •Poor straight-line stability •Uneven steering return •Potential instability during emergency braking This is a safety-related steering geometry defect. ⸻ 3. Real-world driving confirms unsafe behavior The vehicle cannot maintain straight-line travel, the steering wheel is off-center, and the car exhibits instability at normal speeds. This makes the vehicle unsafe to drive. ⸻ 4. Despite these unresolved issues, the dealership insists the vehicle is “repaired” and demands that I pick it up. They refused to provide frame measurement reports or explanation for the unequal wheelbase. Returning a vehicle with unresolved steering and chassis geometry defects constitutes unsafe vehicle delivery. ⸻ Conclusion Based on unequal wheelbase, abnormal caster geometry, and inability to drive safely, this vehicle likely contains a structural or assembly defect. I formally request investigation, suspension geometry verification, and required action from the manufacturer, as this is a matter of public road safety.

NHTSA #11703390

While driving on a dry, clearly marked two-lane highway in Montana, I had Lane Tracing Assist and Active Lane Keep/Track Assist turned on. My hands were on the steering wheel, speed was within the limit, and visibility was clear. The truck unexpectedly steered itself out of the lane toward the right-side guard rail. There were no audible or visual lane-departure alerts, no “steering assist canceled” message, and the Pre-Collision System did not apply braking before impact. The vehicle struck the guard rail. The system failed on multiple safety layers — no lane warning, no steering correction, and no automatic braking — under normal conditions (dry pavement, well-painted lane lines, daylight). I believe this represents a malfunction or defect in the driver-assist software or sensor calibration for Toyota Safety Sense 3.0. I request NHTSA investigate similar incidents for 2024–2025 Toyota Tacoma models equipped with LTA/LDA and Pre-Collision System to determine whether a systemic defect exists.

NHTSA #11694597

Driving home and truck started acting like it was dragging and not going the correct speed. Then we got messages on the truck display . Parking Brake malfunction and System malfunction. We pulled over and called Sun Toyota. We then called Toyota roadside assistance and had it towed to them. They checked it out.

NHTSA #11681058

Turning a corner heard a loud clunk and steering went out in the middle of the street.I could of got hit

NHTSA #11681088

Turning a corner my left axle broke and I only have 3100 miles on this vehicle. Still is not fixed because of warranty issues. When I do get it back I don’t know how I’m suppose to feel safe driving it. Upon checking on YouTube and Internet I see there is a problem with this happing to others. Thank you for your time.

NHTSA #11681892

I am filing this complaint regarding my Nuna RAVA convertible car seat. The seat’s harness straps have loosened unexpectedly, even when fully tightened according to the instruction manual. While I have been able to get them to stay tight, I have to constantly monitor them for potential slippage. This unpredictability is concerning because it could compromise my child’s safety in the event of a crash.

NHTSA #11685417

The contact owned a 2025 Toyota Tacoma. The contact stated that while driving approximately 75 MPH, a Semi Truck attempting to merge onto the highway crashed into the passenger side of the vehicle, causing the driver to lose control of the steering and cross three lanes of traffic before crashing into the concrete median. During the crash, no air bags in the vehicle deployed, the collision avoidance systems did not operate, and twelve error messages were activated, including a brake error, a Four Wheel Drive error, and an ABS error. The driver sustained a concussion from the head contacting the steering wheel and lacerations from shards of glass entering the vehicle during the crash. The front seat passenger sustained lacerations to the legs and arms, the rear driver side passenger sustained fractured ribs and lacerations to the arms leg, and face. The rear passenger side occupant sustained lacerations to the arms and legs. All occupants in the vehicle were transported to the hospital with injuries, along with the semi-truck driver. No further information was available. A Police report was taken, and the vehicle was towed away. The manufacturer and local dealer were notified of the incident. A representative from the manufacturer was sent to inspect the vehicle and deemed no failure had occurred. The vehicle was destroyed. The failure mileage was 4,000.

Reportado presuntamente: 4 lesiones (según lo reportado a NHTSA). NHTSA #11714169

On several occasions in the previous two months, I have been driving during heavy rain. On the first occasion, while high speed wipers were on, they suddenly stopped working. I slowed down, but was able to get them going again prior to pulling to the shoulder of the highway. I had to switch to the slow wiper speed to get them going. I switched back to the high speed wipers due to heavy rain, and kept stopping each time. It continued this cycle and stayed on after about 15 attempts. Today, on [XXX], I drove down [XXX] from Flint, MI towards Detroit at approximately [XXX]. The wipers again quit working and I had to switch the wiper speed to get it working again while at full highway speed during a deluge of rain and nearly had to stop in a construction zone with no shoulder and heavy traffic, nearly causing a collision until I was able to get the wipers to begin working again. On a previous occasion, I turned them on. When the rain stopped, I was unable to stop the wipers, but was eventually able to stop them by carefully moving the intermittent delay wheel to a position between on and off. It appeared that there may be a short in the wiper circuit. This was a definite safety issue in that my attention was taken away from driving to try to fix the wiper situation. In speaking with my service adviser at Randy Wise Toyota in Grand Blanc, MI, he went out to their lot and tried to duplicate the problem, which he confirmed happened on that same Toyota Tacoma model. I attempted to get this repaired under warranty. Their response was that there was nothing they could do since it appeared to be in the design of the wiper system. My opinion is that this is a serious safety issue which needs to be addressed immediately. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11672341

I purchased a brand-new 2025 Toyota Tacoma TRD Off-Road. From the first day, the steering wheel was off-center and the vehicle vibrated while driving. At around 500 miles, I noticed severe instability and abnormal tire wear. A wheel alignment report showed: Thrust angle: +0.15° (spec: 0° ± 0.05°) Rear toe: Left 0.23°, Right -0.10° (difference: 0.33°, spec ≤ 0.15°) Front caster: Both sides out of specification (shown in red on report) Driving symptoms include: Cannot maintain straight-line driving; requires constant steering correction. Excessive body roll during lane changes or turns. Continuous vibration of the vehicle and steering wheel on smooth roads. Vehicle bounces and momentarily loses control on uneven surfaces. Steering wheel rotation does not match front wheel steering angle. When stationary, turning the steering to full lock causes the body to rise; releasing it causes it to drop. Attempts to repair at Toyota of Manhattan (June 2025 – August 2025) were unsuccessful. The dealership repeatedly refused to perform proper inspections, provide reports, or acknowledge the defect, despite multiple appointments and a case opened with Toyota corporate. The defect presents a serious safety risk: reduced vehicle stability, increased stopping distance, loss of steering control during maneuvers, excessive and uneven tire wear, and abnormal fuel consumption (13.5 MPG with no load). The problem exists from new and has not been corrected.

NHTSA #11679590