Toyota Highlander 2020: Retiros, Quejas y Ley de Limón de California

The transmission has been making a whining noise since about 75K miles. Had the transmission fluid changed at about 110K miles. Still makes whining noise and now has a rumble occasionally. We took it to the dealer and they said the transmission needs replaced. Over $8k in charges for the repair.

NHTSA #11742625

The contact owns a 2020 Toyota Highlander. The contact stated that while driving to the dealer for a service appointment, the vehicle made an abnormally high-pitched sound. The vehicle was diagnosed with a UA80 transmission failure. No further information was available. There was no warning light illuminated. The manufacturer was notified of the failure. The failure mileage was approximately 71,233.

NHTSA #11742680

I took my car in for service and I noticed my car is making a loud whining noise. I asked the mechanic about it and he said my transmission is going out. I found on the web several people complaining about the 8-speed Toyota transmission and how it will stop working shortly. The complaints are numerous and it listed all the of the technical bulletins that Toyota issued and they knew about the problem years ago. I am taking my car to shop to have it fixed or replace. Based upon all my research, I am concerned that the car will stop working and leave me in an unsafe situation. I am not happy that Toyota is selling such a defective product.

NHTSA #11740733

The vehicle recently began making a whining noise when the gas pedal is pressed that is consistent with premature failure of the transmission. I took it to my local dealership and they recommended replacing the transmission and limiting usage of the vehicle to short trips until that is done because the transmission could fail while driving which would result in loss of power to the wheels which could lead to an accident.

NHTSA #11739243

Transmission failing/confirmed by dealer at 70k. No slipping, no warning messages, just whining prompted me to have it inspected. There are multiple lawsuits regarding these UA80 transmissions and Toyota is refusing to fix or acknowledge the manufacturing flaw.

NHTSA #11738669

The transmission failed. It is available for inspection. Should the transmission have completely failed on the road, it could have lead to an accident. Per the dealership diagnostic: replace transmission and torque converter assembly with applicable seals due to internal transmission failure. It has not been inspected by anyone else. No warning lights. This is a widespread problem in 2017-2020 Toyota Highlanders. Failure frequently happens right after the expiration of the manufacturer warranty and Toyota refuses to pay for it.

NHTSA #11737362

This Toyota Highlander make whining sound when I try to speedup, even a little bit. I had a transmission shop checked, and I was informed there is metal pieces in transmission fluid. I am concerned it will break one day on highway while driving.

NHTSA #11737887

The transmission failed after 56,000 miles. Based on the research this UA80 transmission has a lot of problems and Toyota has issued TBS and even extended warranty for the previous year models in the past. The transmission failed right after the time allowance for the 5 years 60,000 mile powertrain warranty, but within the mileage.

NHTSA #11735103

Vehicle jerked and then a metal grinding sound. Vehicle would then not even roll in neutral on an incline. Had to be towed to dealer. Transmission has a crack in the case. Need a whole new transmission. I was left on the road. No warning whatsoever.

NHTSA #11735905

I have a 2020 Toyota Highlander Limited, at 140k my car began whining with acceleration, I took it to the dealership and a new transmission and was quoted 9,790 alone for a new transmission. I have had Toyotas since I began driving, I have never put more than breaks and battery’s in them. It seems this transmission has been a constant problem and failing early in life. I am not sure how there is not a recall for as many reports that there is.

NHTSA #11734052

Transmission developed a "whine" just before 87,000 miles resulting in the transmission and torque converter needing to be replaced as the transmission was failing.

NHTSA #11734003

The contact owns a 2020 Toyota Highlander. The contact stated while driving at 35 MPH, depressing the accelerator pedal the vehicle to respond as intended and the contact could smell smoke while stopped. A dealer was contacted. The vehicle was taken to a dealer to where the diagnosed the transmission needed to be replaced. The vehicle was repaired, as the shift selector switch was replaced. The manufacturer was notified on the failure and offered to cut five thousand dollars off the cost of repair. The vehicle was not repaired. The approximate failure mileage was 41,800.

NHTSA #11737031

My 2020 Toyota Highlander experiences transmission jerking and hesitation during low speed acceleration. The issue was first reported to the dealership while under warranty but was not diagnosed. The vehicle now requires transmission replacement 7k miles over the warranty despite the issue being reported during the warranty. Toyota has refused a repair under warranty and has violated their terms of powertrain warranty. This 8 speed transmission commonly has issue during production years 2017-2022 and toyota has admitted to a production defect. Despite that they have refused a goodwill repair or a warranty repair.

NHTSA #11724730

1. The vehicle’s transmission appears to be failing. I was driving my 2020 Toyota Highlander on the freeway at about 75 mph with my family in the vehicle when the car suddenly lost power and would not accelerate properly even though the engine was still running. Because of the sudden loss of power, I had to carefully move the vehicle to the shoulder of the freeway. At the time I did not realize it may have been related to the transmission. 2.Recently I brought the vehicle to an authorized Toyota dealership for a routine oil change and because I had started hearing a whining noise when accelerating, especially above about 30 mph. After inspecting the vehicle, the dealership informed me that the transmission needs to be replaced and provided a repair estimate of approximately 9,800. The vehicle currently has around 72,000 miles and the transmission is available for inspection upon request. 3.The sudden loss of power on the freeway created a dangerous situation because traffic around us was moving at highway speeds. My family was in the vehicle and I had to maneuver the car to the shoulder while vehicles were passing at high speed, which could have resulted in a serious accident. 4.The issue has been confirmed by the authorized Toyota dealership service department. When the incident occurred and we were stopped on the shoulder of the freeway, we contacted the highway patrol because we were concerned about our safety while stopped on the highway. 5.No warning lights or messages appeared on the dashboard prior to the loss of power. The only symptom noticed before bringing the vehicle in for service was a whining noise during acceleration.

NHTSA #11724164

My 2020 Toyota Highlander, with 83k miles, started making a whining noise when accelerating. I took the vehicle to a local auto shop and they advised there was a transmission issue. There were never any warning signs of issue. I then took the vehicle to Antwerpen Toyota in Clarksville, MD (where the vehicle was purchased) and paid $185 for a diagnostic appointment. On February 20, 2026, The dealership provided a written estimate for “Replace automatic transmission assy” with a total cost of $9,403.77. I am very concerned for the safety of myself and others continuing to drive the vehicle without proper repair. The vehicle is otherwise in great condition and I keep up with all regular maintenance.

NHTSA #11720132

THE TRANSMISSION FAILED SUDDENLY.

NHTSA #11714593

Transmission is presenting a high-pitched whining noise.

NHTSA #11710248

Our 2020 Highlander with 45,000 miles started making a whining noise when accelerating. After the Toyota garage looked at it we were told that we needed a full transmission replacement. No warning lights came on alerting of us of problem. We were also told by the service depart that they are not surprised there hasn’t been a recall due to how many transmissions they have replaced on these vehicles and especially this type of transmission. Upon researching this particular issue, It is a wide known issue with class action lawsuits. New transmissions are also only carrying a 1 year warranty. That is hardly a warranty on a costly repair. It will cost us out of pocket $8,000 for a vehicle that is meticulously maintained and with only 44,000 miles. These vehicles are still being sold putting myself, my family and many more Americans as risk.

NHTSA #11711916

Transmission stutters. Only has 32000 miles.

NHTSA #11706447

Whine noise when you accelerate coming from the automatic transmission. Car is hesitant in shifting gears when needing to accelerate causing safety issues/concerns while driving due to the inconsistency. Toyota dealer as inspected the vehicle and recommended a transmission replacement. Dealer has filed a claim with Toyota to see if it will be covered or not. Total price of repair quoted from dealer was $8700.00. I am also being told there is a back order on parts related to the repair of the vehicle and that the amount of vehicles with this issue are increasing in numbers each day. I purchased this vehicle new in 2020 and have been the sole owner.

NHTSA #11710814

Transmission whines in low gear.

NHTSA #11706060

TRANSFER CASE MAKING ROTATIONAL BEARING NOISE FLUID HAVE LOTS OF METAL DEBRI

NHTSA #11702219

Transmission malfunction that left us on the highway with no power and in an unsafe situation. Not confirmed as of yet. At dealership tomorrow. No inspection completed by parties listed above. Check engine light appeared prior to malfunction.

NHTSA #11699712

While driving and/or accelerating you can feel some harsh shifts as well as slipping and shuttering with only 84k miles on this vehicle.

NHTSA #11700700

The vehicle’s automatic transmission (power train) has developed a loud whining/whirring noise under acceleration. This noise increases with engine load and indicates internal mechanical failure. The transmission is still installed in the vehicle and is available for inspection upon request. This issue poses a safety risk because it causes hesitation and unpredictable acceleration behavior while merging or crossing traffic. There is also concern that the transmission could suddenly fail while driving, resulting in loss of propulsion and potentially causing an accident. The problem has been inspected and confirmed by a Toyota dealership, which advised that the entire transmission needs to be replaced at a cost of over $8,000, despite the vehicle having only approximately 77,000 miles. The vehicle has been inspected by a Toyota manufacturer service center. They identified the transmission failure but stated there are no current recall programs covering this specific VIN. No warning lights or error messages were displayed at any time before or during the failure. The first noticeable symptom was the transmission whining/whirring noise during acceleration, which began around 77,000 miles and continues to worsen.

NHTSA #11703108

My 2020 Highlander developed a whining or grinding noise consistent with the Technical Service Bulletin. I took it to a Toyota Dealership for diagnostic and they confirmed the whining and hissing sound. They said it would cost $9,000 to repair. I called Toyota to request a goodwill repair and they denied me. Toyota case number: 251229000423. The car does not feel safe to drive. We worry that at any moment the car could break down with our children inside. The problem was reproduced at a dealer and inspected. There were no warning lamps or messages, just the obvious sound coming from the transmission.

NHTSA #11707470

Transmission failure. Noticed whining when driving, took to local Toyota dealership and they diagnosed transmission failure. They quoted $12,000 for transmission replacement and confirmed that this is a known issue with certain years/models of Toyota Highlander. Ours is a 2020.

NHTSA #11703925

The car started making whining noises when pressing the gas pedal. Toyota reported "noise from transaxle final drive. recommend replace. vehicle ok to drive but noise will continue until transaxle is replaced." There are no warning lights, messages or other symptoms prior to the sound starting or currently. This is a known issue with its 8-speed automatic transmission (UA80E/UA80F) that can cause whining, erratic shifting, and premature failure. This issue is the subject of a Customer Support Program (CSP ZJC) and several lawsuits, but the program has limited coverage for VINs, leading to owner complaints about a lack of assistance from Toyota.

NHTSA #11697161

I am filing a complaint with the NHTSA regarding persistent transmission slipping in my 2020 Toyota Highlander LE equipped with the UA80-E 8-speed automatic transmission. Since reaching approximately 55,000 miles, I have experienced noticeable slipping, characterized by delayed acceleration, erratic shifting, and occasional lurching, which align with documented defects in the UA80 platform as outlined in over 430 NHTSA complaints and Toyota’s Technical Service Bulletins (e.g., T-SB-0160-18 and T-SB-0008-21). These issues stem from a known manufacturing flaw involving a washer tab failing to secure the counter drive gear’s retaining nut, leading to gear movement, internal wear, and symptoms like mine. This defect, prompting Toyota’s Customer Support Program ZJC for 2017–2018 models and reported in later years like 2020, compromises vehicle safety and reliability, as slipping can cause unpredictable handling. I urge the NHTSA to investigate further and hold Toyota accountable for addressing this widespread issue across affected models.

NHTSA #11691766

UNKNOWN, dealers are reporting 1-2 2020-2022 Highlanders are needing completely transmission replacements at 8-10k in cost. They are all failing and toyota knows this.

NHTSA #11692000

At around 45,000 miles, my 2020 Toyota Highlander started making a whining noise on acceleration. This condition seemed to get worse (whining got louder) I took it to a Toyota dealership and they said there are no codes left by the vehicle but the repair technician knows that this whine is related to a total transmission failure so the recommendation is to replace the transmission at a cost of approximately $8000, Toyota said the vehicle is out of warranty (by 4 months) so they will offer nothing to assist with the repair. Looking on the internet and this website, it is very clear that this is a common issue with this model of vehicle. Dealer said I can drive it but eventually the transmission will fail, leaving me stranded on the roadside.

NHTSA #11696327

Whining noise when accelerating. Took it to toyota dealership and confirm it was the transmission .toyota corporate would not assist repair cost as my warranty is 7k miles pass warranty mark..did a research about the transmission and there is a class action law suit about the faulty transmission

NHTSA #11691192

After my 75000 mile inspection at my Toyota dealership, which is required and I have been bring my vehicle in every 5,000 miles. I started hearing a slight whinny noise. I thought it was around my wheels or tires. Then I thought it must be a new wind noise. Which that is another issue. I took a short trip and by the time I got back it was louder. I took it to the dealership and the technician drove it and said I need a new transmission. I ask my service provider if he has seen any other vehicles having this problem? And I should not have any transmission issues at this mileage. My service provider stated that he knows of highlanders having this issues.

NHTSA #11696718

TRANSMISSION GAVE OUT

NHTSA #11687502

The vehicle’s transmission makes an audible whining noise during acceleration and intensifies as the car increases speed. The vehicle has been diagnosed and inspected at the original dealer where the car was purchased and confirmed that the transmission needs to be replaced. The vehicle’s powertrain warranty has just expired and this issue is a major problem and concern with similar model years.

NHTSA #11687751

Transmission is defective. I do have a warranty that I purchased but I am aware that this is a faulty transmission for the 2020 and 2021 Highlander and Toyota refuses to do anything about it. Transmission is 2 - 3 months backordered and Toyota will not provide a rental.

NHTSA #11687883

Transmission whine Owners of 2017–2022 Toyota Highlanders, 2017–2020 Siennas, and 2018–2020 Camrys are experiencing serious transmission issues—including high-pitched whining, erratic shifting, clunks, hesitation, and premature failure. These vehicles are equipped with the UA80F (AWD) and UA80E (FWD) 8-speed automatic transmissions.

NHTSA #11686420

Road noise was very loud. I thought it was a bearing and I took it to the shop and found out that the 'transfer box' on the side of the transmission had to be replaced. I was told that not replacing it could lead to major transmission failure. This cost $6000. Mechanic said it's unusual. Upon reading the internet I'm learning that I'm not the only one this and similar problems.

NHTSA #11702304

Transmission failure at 78,000 miles

NHTSA #11683790

Transmission Planetary Gears in 2020 Toyota Highlander. Makes a "whining" noise when accelerating. No warning lights or other symptoms. Many reported problems with this model but no recall. Many people are needing to pay out of pocket due to the 60k mileage powertrain warranty.

NHTSA #11683248

2020 toyota highlander l Transmission..whining noise it gets louder when accelerating

NHTSA #11687706

My 2020 vehicle has 75,000 miles on it. It started making a high pitched sound when accelerating. I brought my vehicle to the dealership where I bought it, to have it inspected. I was assuming it would be a belt or an easy fix. The service agent walked over and cooly explained that I need a new transmission. He continued to say that this is a common issue with this make and model. He stated that at the beginning of the year customers were having to wait a couple of months of transmission parts, but now because of the demand due to the well known power train failure, that the current wait time for transmission parts are only two weeks. He stated several times, that this is a common problem, one that car owners are expected to pay $9,000. to fix. A quick google search brings up a plethora of customers having the same exact problem. Toyota needs to make this right and issue a recall on their faulty product.

NHTSA #11688249

My wife was driving on the highway, felt a bump and the engine RPMs spiked. The check engine light came on as well as a error message that the secondary collision braking system was disabled. The vehicle was taken to the dealership and we were told there was a internal failure in the transmission. The vehicle has approximately 80K miles.

NHTSA #11676335

The contact's wife owns a 2020 Toyota Highlander. The contact stated that soon after purchasing a new set of tires, the vehicle made an abnormal rattling sound upon acceleration. The vehicle was taken to a dealer for an oil change and tire rotation, and the contact was informed that no defect was found on the vehicle. As the failure persisted, the vehicle was taken back to the shop, where the tires were purchased. The contact was informed that there was no defect in the tires, and the failure might be related to the differentials of the vehicle. The vehicle was taken back to the dealer, where it was diagnosed with transmission failure. The manufacturer was then notified of the failure, and the contact was offered partial financial assistance towards the purchase of a new engine. The vehicle was not repaired. The failure mileage was approximately 55,000.

NHTSA #11708000

76,000 miles on my 2020 Highlander. Car was made in September 2020, less than 5 years old. Started to hear whining noise from transmission. Over past few days it has gotten louder. Took to Serra Toyota dealer today in Birmingham, Alabama. They confirmed a problem with transmission and told me I needed a new one for $8600. None are even available. I refuse to pay Toyota any money for this. This is a KNOWN issue with the UA80E transmission. The transmission may completely stop working at anytime now. Dealer was unwilling to do anything to help me since car is out of 60,000 mile warranty, and no TSB's or recalls are for my particular year 2020. There is a TSB for 2021 UA80E transmissions. I am so angry about this. This is a clear manufacturing defect. When this transmission dies which will be sooner than later the car will be worthless with no transmissions available.

NHTSA #11671385

The contact owns a 2020 Toyota Highlander. The contact stated while driving at an undisclosed speed and attempting to accelerate, there was abnormal whining sound coming from underneath the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission assembly. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Support Program: POL 19-04. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 129,000.

NHTSA #11670858

UA80E or UA80F Toyota transmission require a complete replacement at 65K miles. Not covered under warranty or Technical Service Bulletin T-SB-0160-18, T-SB-0008-21

NHTSA #11673633

Whining noise upon acceleration, replacement transmission recommended by Toyota dealer. Defective UA80F installed.

NHTSA #11677260

At approximately 72,000 miles, my 2020 Toyota Highlander Platinum was diagnosed by my dealership with a failing transmission that requires full replacement. I first began hearing a high-pitched whining noise during light acceleration shortly after a routine oil change, at some point between 60,000 and 70,000 miles. I did not immediately recognize it as a drivetrain issue until the symptoms worsened. This model uses Toyota’s UA80 8-speed automatic transmission, which has been the subject of Technical Service Bulletin T-SB-0008-21 and a Customer Support Program (ZJC) for earlier Highlander models due to similar internal component failures. Despite clear continuity in the symptoms and transmission design, Toyota has not extended coverage or issued a recall for 2020 models like mine. The failure occurred shortly after the end of the 5-year/60,000-mile powertrain warranty, but symptoms began while the vehicle was still within warranty range. Toyota has not responded to my formal escalation through Customer Care for nearly three weeks. I am deeply concerned Toyota is not addressing what appears to be a systemic and known defect in a critical drivetrain component that can jeopardize vehicle safety. There was no warning light or dashboard alert at the time the failure developed, making this both a mechanical and safety concern. While this issue does not involve a catastrophic failure like the Takata airbag recall, Toyota’s lack of response to a known, widespread transmission issue raises broader concerns about safety, transparency, and accountability. A sudden transmission failure—particularly at highway speeds—could result in loss of power or control. Given that several owners have filed similar complaints, I respectfully urge NHTSA to investigate this issue further and assess whether Toyota should issue a recall or expanded service campaign for 2020 Highlander models equipped with the UA80 transmission, particularly in light of prior coverage for earlier model years.

NHTSA #11671630

My 2020 Toyota Highlander Platinum started having the well-known "whining" sound at just under 60,000k. This is coming from the transmission. The vehicle is now just over 60,000k and I did not know that the noise was a cause for concern, let alone something that was an issue (I am not tech savvy - I'm just a regular person). I will not drive this vehicle again, as it is my only transportation for my children. Toyota issued a service bulletin about this issue for 2021 Highlanders ONLY, but as I am now experiencing this problem, I see that this is something well known as a problem.

NHTSA #11671361

All of the sudden around 70K miles, the transmission started to make a "whining" noise. It does not sound right and I'm afraid the transmission could fail while I'm driving. I took it to the dealer and they acknowledged that it's a known issue but that in my case the noise is not loud enough to warrant replacing the transmission. A quick research on the internet revels that this is a very common problem.

NHTSA #11689199

At approximately 75,000 miles the vehicle had a whining noise coming from the engine area. Took it to the dealer and they tested it, listened to it and determined that the transmission needed replaced. They confirmed the t-case oil is in good condition and level. No maintenance issues or concerns. Just that the transmission had gone bad. Toyota wants $8,000 to replace a transmission with low miles for a 2020 vehicle.

NHTSA #11732069

Transmission making whining noise that increases with speed. Concerned about safety if transmission fails while driving Diagnostic done at Toyota and confirmed transmission is failing and needs new replacement. There are no warning lamps. Noise has increased intensity over short period of time

NHTSA #11668004

8 speed automatic transmission started whining at 45k miles (purchased new), has been inspected, dealer confirmed transmission is bad and part is on back order (date keeps moving out),

NHTSA #11662250

My 2020 Toyota Highlander is equipped with Toyota’s UA80 8‑speed transmission. At around 62, 000 miles, a loud whining noise developed. The dealership confirmed the transmission is defective. Toyota has issued multiple Technical Service Bulletins acknowledging this transmission defect across all 2020 Highlanders with the UA80, but they are refusing to cover my repair because I am slightly over the 60,000‑mile powertrain warranty. Impact: This is a confirmed design flaw that affects every 2020 Highlander with the UA80 transmission. I rely on this vehicle as my only means of commuting to work—if the transmission fails, I will lose my job.

NHTSA #11677882

TOYOTA HIGHLANDER 2020 less than 5 years 63,000 miles started making noise Dealer where i bought it; said my warranty expired with 60,000 miles , so i have to pay transmission replace close to $9,000 , obviously this is a Toyota fabrication problem they need to assume responsibility .

NHTSA #11688890

The contact owns a 2020 Toyota Highlander. The contact stated that while driving at 30 MPH, there was an abnormal whining sound coming from underneath the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 78,000.

NHTSA #11689414

The transmission is making a whining noise at 104;368 miles. We own another 2020 Toyota Highlander and it had to have the transmission replaced for the same reason. It is available for inspection. It’s a safety hazard because it’s a bearings in the transmission that’s failing. The transmission will eventually stop working. The issue was confirmed by a Toyota dealer and one of our transmissions has already had to be replaced. Toyota has a service bulletin out for this known problem. There were no warning signs for the transmission noise.

NHTSA #11654949

Whining noise from the transmission after 66K miles - Change fluids still no improvement - Known issue with UA80 transmission . Dealers knew of the issue but still sold cars

NHTSA #11666429

Around 90,000 miles, the transmission has started to whine really bad. This seems to be a common problem with this 2018 to 2021 Highlanders, but 2020 has no recall or service bulletin. My mechanic priced a transmission from a dealership and was told it would be 3 months at least to get a reman transmission. There is a good chance of catastrophic failure before we can get a new transmission installed.

NHTSA #11658280

At around 61,000 miles, I noticed a whining sound in the vehicle when accelerating. I took the vehicle in to a Toyota dealer for diagnostics and their technicians indicated that my vehicle had transmission failure and it needed to be completely replaced - quoted at $8,000 to do the replacement. Diagnostic appointment also cost $174. Parts are on back order and no one could tell me when parts would come in - guess was one month. In reality, parts are now finally in (I'm about to take it in to be fixed) after 2 months. I was told by the dealership that I could drive it at my own risk of failure - if it were to fail, I would be stranded wherever that may be putting my family and those around me at risk due to the unknown nature of when that could happen. This failure is recorded for the same model and same UA80 transmission on several online forums: [XXX] The vehicle has been inspected by a Toyota dealer as I stated previously. Diagnostic report says "Internal component failure. Recommend transmission" No other warning lights or messages from the car to warn me of this problem even now. Just the whining sound from the failure itself. Keep in mind, Toyota's powertrain warranty period is 5 years or 60,000 miles - this vehicle just surpassed both of those limits as this problem came about. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11666696

2020 Toyota Highlander l developed a whining noise and after extensively researching this sound it seems like its common on highlanders with the UA80 transmission and leads to transmission failure. There is a Toyota forum where owners have gathered about this issue not only for this year highlander but early models when the specific transmission above started being used. Quotes to replaced this transmission range from $6,000-$13,000 at the dealer. Toyota has been called and they have been of no help to anyone. Even worse it seems all places are backordered on these transmissions and owners are left without a car. To quote a toyota member who called to get hemp with the issue, this is what Toyotas response was: “ Toyota refuses any support stating that "we can't predict an average life expectancy for any specific part of component", This only means life expectancy on their parts does not exist? Shouldnt they have a target life expectancy on parts? A lot of dissatisfied toyota owners as toyota is hiding from this issue.

NHTSA #11660304

Transmission going out afraid it will come apart or lose power while driving. Toyota dealership told me that we could put new transmission in but it will be the same as the one that is in it and that problem with them has not been corrected and it probably won't hold up long either. Our vehicle only has 71000 miles and we bought it new.

NHTSA #11651486

Final drive failing in transmisssion

NHTSA #11665175

The contact owns a 2020 Toyota Highlander. The contact stated that while depressing the accelerator pedal, the vehicle was making an abnormal whining sound. The contact stated that the failure occurred at various speeds. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to Technical Service Bulletin: T-SB-0008-21 Whine Or Grind Noise from Transmission (Power Train). The manufacturer was not informed of the failure. The failure mileage was approximately 98,000.

NHTSA #11647946

Complete transmission and transfer assembly failure at 72,000. Just outside manufacturer warranty. Toyota Dealership and Corporate refused to acknowledge responsibility, stating that the transmission and transfer assembly met warranty requirements, and that they would not entertain assistance.

NHTSA #11644935

The contact owns a 2020 Toyota Highlander. The contact stated while driving at undisclosed speeds, there was a whining sound coming from the transmission. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the internal bearings had failed, and the transmission needed to be replaced. The vehicle was not repaired. The contact referenced Technical Service Bulletin: TSB-0008-21 as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 99,000.

NHTSA #11655829

Around 92k miles my transmission started makining a whining noise while driving. Dealership diagnosed a transmission problem and it needed to be replaced. They said eventually the transmission will go bad and stop working, potentially leaving me stranded or causing an accident. Spoke with Toyota HQ who would not offer financial assistance or assist with getting a part. UA80F transmissions are on a nationwide backorder. They also would not acknowledge that there is a problem.

NHTSA #11653583

At about 85,000 miles, the transmission developed a whine noise, and two dealers and a transmission shop all state it needs replacement. However, the backlog for replacement is enormous and I risk the transmission failing catastrophically while driving.

NHTSA #11656331

Transmission failure- this affects the safety of others when the car decides it doesn’t want to accelerate and could potentially lead to car accidents when another vehicle runs into it. The transmission needs to be completely replaced. This issue started back in January and has been an ongoing problem since warranty and Toyota will not assist with issue of their faulty product.

NHTSA #11668359

The 8-speed automatic transmission was making a whirring, whining noise. Transmission could failed completely and stranded occupants including children. Vehicle has been serviced every 5,000 miles and no warning lights or indicators ever came on. Dealer inspected and diagnosed an internal component failure necessitating complete transmission replacement. Vehicle is 4 years and 2 months old with 65,000 miles on it.

NHTSA #11651457

The transmission started slipping without any warning and then went into neutral while driving and I am not able to drive it anymore. The dealership said the transmission is bad. I see many complaints online about 2020 Toyota Highlander transmissions going bad for no reason. This is a new car only 4.5 years of normal driving and the transmission goes, this is not normal for such a high rated vehicle.

NHTSA #11634321

The transmission in my 2020 Highlander XLE needs replacement at 64,000 miles.

NHTSA #11631899

Highlander transmission broke down around 80,000 miles

NHTSA #11632588

The transmission is starting to whine at 108,000 miles. Toyota service told me the only fix is a replacement and they have seen two failures within the same week. They also said this is a known issue with this model year. A Reddit thread shows many owners in the US and Canada with the same issue. If this is resulting in failures of the transmission in operation this is a safety issue and a reasonable recall being a known defect for this line of transmissions. The recommendation from the service department since this vehicle is paid off is to run it to failure.

NHTSA #11643039

Began hearing a high-pitched whining sound when I accelerated. Took it into the dealer and they casually told me that I needed a new transmission. My car was less than four years old, but had more than the 60,000 miles that would apply under a warranty. I am now reading online. This is a widespread problem involving Toyota Highlanders. Can’t get a new transmission for three months or more.

NHTSA #11660920

Vehicle produces a noticeable whining noise under acceleration. Shifting is completely normal and no other drivability issues are present. Issue matches the pattern described in TSB T-SB-0008-21 (UA80E/UA80F front carrier assembly pinion shaft bearing failure). Multiple owners report dealers are diagnosing this as requiring full transmission replacement at 8,000–12,000, with no partial repair or recall offered despite Toyota’s prior knowledge of this defect in earlier model years (ZJC Warranty Enhancement Program for 2017–2018). Requesting NHTSA investigation

NHTSA #11724257

I have experienced ongoing transmission problems, including but not limited to rough shifting, delayed acceleration, jerking while driving, and abnormal noises. These issues have significantly affected the safety, reliability, and drivability of my vehicle. This transmission failure significantly undermines Toyota’s long-standing reputation for reliability and has substantially reduced the value of my vehicle.

NHTSA #11711712

Transmission whining around 38mph when accelerator is pressed. Goes away when foot is off pedal. No warning lights are on. I test drove 3 other 2020 - 2021 Highlanders in May before I purchased this one. All 3 of those had a very noticable transmission whine over 20mph. I opted for this Highlander because there were no noticeable issues/sounds. Just this month, I am noticing a more pronounced high pitch whine during acceleration. This certainly sounds like a much wider issue, especially calling around to multiple dealerships confirming they have other 2020-2021 Highlanders in getting transmission replacements (on 3+ months wait times for parts) This is absolutely a safety issue if a transmission fails while driving. There was a technical bulletin for this same issue with certain VINs, but I was told that my VIN fell outside of that range. To answer rest of questions: No confirmation from dealer on the whine, they are all charging $180 to diagnose the issue and I am not paying that. No further inspections by the above groups listed.

NHTSA #11624184

I own a 2020 Toyota highlander and the car mileage is 68,000 and the dealer told me my transmission is dead and needs to replacement. The cost for replacement is $13,000.00! I’m the first owner of the car and how could a new Toyota car transmission fail at 68,000 miles and the warranty is 5 yrs or 60,000 miles. This issue have to be Toyota manufacture problems and they should have a recall on this and I researched online and a lot of highlander owners have the same problems as me! NHTSA PLEASE RESEARCH AND HELP HIGHLANDER OWNERS! Thank you

NHTSA #11622122

I brought my 2020 Toyota Highlander to Round Rock Toyota in 09/2024 for a failed transmission, referenced in TSB T-SB-0008-21. As of today, the vehicle has been in Toyota’s possession for over 10 months and remains unrepaired. My assigned case manager (Case #241003001730) has confirmed that Toyota has no ETA for the replacement part. I’ve also confirmed through Toyota’s customer support line that their parts department cannot provide a timeline. Toyota acknowledged the issue is tied to a known defect, yet there is no resolution. I was denied a loaner vehicle until escalating the issue to the dealership’s upper management. Toyota’s delay has caused significant personal and financial hardship. This is a clear breach of their powertrain warranty and represents a systemic breakdown in their ability to support affected customers. I am seeking immediate federal review of this issue, as it affects vehicle safety, value, and reliability.

NHTSA #11671287

The contact owns a 2020 Toyota Highlander. The contact stated while driving at approximately 25 MPH, there was an abnormal humming sound from the engine compartment. The contact depressed the accelerator pedal, and the sound got louder. The contact stated there was no warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 67,000.

NHTSA #11619144

My vehicle is started making a loud whining noise at around 78K miles whenever you accelerate between about 25-60mph. The dealer said that a new transmission is the only thing that would fix it. The cost of the transmission is 8K. The dealer said that Toyota ought to cover it, but I called and their initial answer is that they will not. This part should be recalled, there are multiple people online saying they are experiencing the same exact issue. This is a very expensive problem for this car, and not one that consumers should shoulder at low mileages. [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11612621

The contact owns a 2020 Toyota Highlander. The contact stated that there was an abnormal winding noise detected while accelerating. The failure increased over time. While the contact’s husband was driving approximately 60 MPH and attempting to accelerate, the vehicle lost motive power. While shifting to park, there was an abnormally loud, high-pitched winding sound detected. The vehicle was slow to shift from first to second gear. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who determined that the CV joint needed to be replaced. The vehicle was repaired, but the failure recurred. The vehicle was taken to a transmission center, where the transmission was rebuilt. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 130,000.

NHTSA #11623929

Known transmission issue not being addressed. Internal parts issue and must be replaced after only a few years.

NHTSA #11614536

With 55k miles on a 2020 Toyota Highlander, we began hearing a whine. On various on-line sources it appears that this is not unusual among late teens to early '20s Highlanders. I brought the vehicle to the dealer (with close to 56k miles) and the dealer decided the transmission needs to be replaced. Even though the dealer service center acknowledges this is an ongoing issue w/the Highlander of this (late teens/early '20s) vintage I'm told its a 1-2mo wait for a transmission repair/replacement. Warranty is 60k miles... I was told be safe and don't go over 60k miles or its possible the warranty might not be honored. While currently operable, a quick internet search indicates, transmission failure often occurs unexpectedly, leaving drivers stranded on the side of the road. This situation can be not only inconvenient but also dangerous.

NHTSA #11614462

The contact owns a 2020 Toyota Highlander. The contact stated while driving at speeds above 20 MPH, there was a loud whining sound coming from the transmission. The vehicle was taken to the local mechanic and the contact was informed that the sound was an indication of transmission failure. The cause of the failure was not yet determined. The local dealer and manufacturer were not contacted or notified of the failure. The failure mileage was 73,000.

NHTSA #11610159

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA #11661535

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA #11658954

Known recall and Toyota is not correcting it.

NHTSA #11656359

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA #11653880

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA #11647613

The contact owns a 2020 Toyota Highlander Hybrid. The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. VIN tool confirms parts not available.

NHTSA #11637256

The contact owns a 2020 Toyota Highlander Hybrid. The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA #11637310

Toyota sent a letter in mid-2024 that there was a safety recall for airbag issue with 2020 Toyota Highlander. The letter stated that a remedy would be available by the third quarter of 2024. As of January 21, 2025, they still have not provided a remedy for the serious safety issue. I would like to file a complaint against Toyota for failing to remedy the defect within a reasonable time.

NHTSA #11637062

I am not reporting any specific incident related to this defect. I am simply complaining to NHTSA that Toyota is taking far too long to provide a remedy for the OCS sensor issue, NHTSA recall number 23V865 (Manufacturer recall number 23TB15). This issue has been ongoing since late in 2023 and it seems that Toyota should have provided a remedy by now.

NHTSA #11634188

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA #11631417

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA #11617662

I received a safety recall notice from Toyota (Recall No. 23TA15 / 23TB15) for the front passenger Occupant Classification System (OCS) sensors. The letter states that the airbag system may not deploy correctly and that the remedy is not yet available. I’m concerned for my safety and my passengers since the airbag system could fail in a crash. Toyota has not provided a repair timeline or an alternative vehicle. I’ve contacted my dealer and Toyota customer service but was told there’s no fix yet. I would like NHTSA to investigate the delay and require Toyota to provide an immediate remedy or alternate transportation. Symptoms: •Airbag light may remain on or system disabled •Unable to safely seat a passenger in the front seat •No repair currently available despite safety risk Remedy status: •Remedy not available

NHTSA #11697766

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA #11617300

The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA #11616236

Sin narrativa detallada reportada.

NHTSA #11604652

While driving on the highway, our sunroof spontaneously exploded. We heard what sounded like a gunshot and found a giant hole in our sunroof glass.

NHTSA #11708693

Premature transmission failure. Vehicle had less than 100K miles. Took the vehicle in for an oil change before a long trip. Mentioned a "whine" during acceleration. Told us that the entire transmission would need to be replaced immediately at a cost of over $10,000. Made an appeal to Toyota to help with the cost of replacement and we were denied.

NHTSA #11711802

Lift gate does not close and it just beeps. Needs to be closed manually. Toyota has known this issue for a long time but failed to address. Repairs are costly and reduces my cars value

NHTSA #11704823

We were driving on the highway and heard what sounded like a gun shot. Our sunroof had exploded. Luckily the interior door was closed or we would have been showered with glass. There was no one around, no rocks or road debris. It just came out of nowhere!

NHTSA #11697273

The 8 speed automatic transmission is failing at 100k miles. Whining noises are heard and after being taken to Toyota dealerships mechanic, we were told that the gear mesh or bearing is bad and that we'll need to replace the transmission. We were told that many other highlanders have experienced the same issues. No light popped up before or during driving while the transmission is whining.

NHTSA #11697322

Lift gate not closing Car gas a whining noise upon acceleration

NHTSA #11702121

Whining noise upon accelerating. Diagnosed as bad transmission by a Toyota dealership. No warning indicator 62,500 miles

NHTSA #11683407

So there was a service bulletin put out by Toyota in December 2020, about its AC repair. Well no notice was given to Toyota owners about this. Well fast forward to yesterday May 21, 2025, my mechanic told me that the AC lines to the rear were leaking and needed to be replaced as it was leaking refrigerant into the environment. Well after reading reviews and other folks problems it seems Toyota knows there is a problem with the ac lines and the type of material they used. Toyota should be issuing a recall notice on these cars to replace the ac lines so it does not pose an environmental hazard inside or outside the vehicle.

NHTSA #11662526

Faulty Transmission that Toyota doesn’t want to cover fixing.

NHTSA #11655956

While driving on the freeway in the evening about 10 minutes into the drive, a loud bang was heard like a shotgun and the front portion of the panoramic sunroof had shattered. Small shards of glass entered the cabin but fortunately no one was injured inside the vehicle. No sign of a rock hitting the vehicle or defect in the panoramic had occurred prior to this incidence. It appears to have occurred spontaneously. There was a large hole in the glass with an outward projection like the pressure inside the vehicle somehow blew out the sunroof. The passengers in the vehicle were at risk of being covered in small shards of glass including a small child in a rear facing carseat who was sitting behind the driver's side. The driver and front passenger would have been impacted as well if the glass gave away. This occurred at high speeds on a freeway where if the glass would have fallen inside the cabin could have caused the driver to be covered in glass, injured while driving at high speeds and caused a wreck. The incident was reported to the highway patrol who could not place a formal report because they said it was not a mechanic defect and the Toyota corporate office said that they could not report because it was a glass issue. Insurance has not been informed yet as we are waiting from the local dealership to see if they can assist. There were no warning messenger prior to this problem and it occurred spontaneously.

NHTSA #11625665

My 2020 Toyota Highlander hybrid sometimes has a brake slipping or surging sensation when I apply my brakes while stopping. It happens periodically and not every time. I have not taken it to a Toyota service station for this specific reason but I mentioned it while in for a recent oil change. They checked for a recall but didn't find any. I have somewhat gotten accustomed to the issue and have been able to adjust. As I have stated, it doesn't happen every time I apply my brakes. My concern is if I allow someone else to borrow my car or even sell to a new owner. I believe I am the second owner.

NHTSA #11737274

While steering to the right to exit a parallel parking spot, the ABS sensor cable came into contact with a suspension bolt, snapping the sensor wire. This triggered the Check Engine Light and caused a malfunction in the braking systems.

NHTSA #11614588