Kia Sorento 2024: Retiros, Quejas y Ley de Limón de California

The horn isn’t making any noise at all. There were no warning lamps or messages, I didn’t know until I needed to use my horn.

NHTSA #11743450

The Panoramic sunroof randomly exploded while driving down the highway. Nothing around us or above us to cause it. Myself, my [XXX] pregnant wife, and [XXX] daughter were in the car and had glass rain down on us after the very loud boom. We almost wrecked. The issue has not yet been inspected by the dealership but I understand this to not be uncommon. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11727717

The Panoramic roof glass shattered. It was not hit by any external debris. It just exploded scaring the driver almost losing vehicle control. The dealer inspected it and confirmed nothing external caused it, however KIA will not warrant it. Our insurance company has not inspected it yet. It is available for inspection.

NHTSA #11700393

A few weeks ago my sunroof began with out warning began to malfunction. It stopped closing all the way . When finally close I noticed the right rear side of the roof not closing all the way. I've noticed the bracket that holds up the glass roof to the track was broken. I took the car back to my car dealership, Gerald kia of Matteson. They told me that it was my fault because the tracks wasn't greased. Something that I wasn't at first purchased a car brand new. So they told me that consider an outside influence ira it would not be covered under a factory warranty. The reason I am filling this is because of hearing about some roofs , exploding , and this could be a situation similar to that.

NHTSA #11734947

The trim on my vehicle will not stay snapped down.

NHTSA #11680690

Driving on interstate during a partly cloudy day at 53 degrees going 65 mph. There were vehicles approximately half a mile away in the front of us and approximately 2 car lengths behind us with no noticeable debris on the road. Moon roof was fully extended and the moon roof exploded without warning (not due to rocks). It sounded like a gun shot went off and we were covered in glass.

NHTSA #11666770

I've had a couple of issues with the electrical components. One time the drivers side door controls wouldn't roll down any of the windows or lock/unlock the doors. This is a safety issue if you needed to roll the windows down/up or lock the doors for the security of your vehicle. I've also had it where the infotainment system has cut out while driving. As far as I can tell, the vehicle could still drive but I was unsure for a minute because the engine kind of revved at the same time. There were no warning lights when the windows and locks didn't work.

NHTSA #11694944

Horn has stopped working. Appears it happens often with the 24 sorento. Almost had a car collision due to the inability to warn the driver of the other car that I was in my lane. I do have an appointment to have it looked at, but not for almost 2 weeks.

NHTSA #11673135

Both Horn units need to be replaced . It's been confirmed by Safford Brown Kia in Manassas ,Virginia. The dealership did not have the parts and I have to wait 3 to 4 days for the parts to come in. In the meantime I have been driving the vehicle without an active horn because I was not given a loaner vehicle . I did call Kia Customer service whom stated that they are not aware of an open recall for my issue .

NHTSA #11671506

The contact owns a 2024 Kia Sorento. The contact stated that during a routine oil change, the mechanic added an unknown oil additive to the vehicle. The contact stated that on several occasions while driving, the accelerator pedal was depressed, and the vehicle lost motive power and drove sluggishly. The vehicle was taken to a dealer for an oil change, and the mechanic observed metal shavings in the oil. The vehicle was taken to another dealer, but it had not yet been diagnosed. The manufacturer was notified of the failure. The failure mileage was approximately 31,000.

NHTSA #11683103

I was driving on the highway about 60mph, I go to accelerate and merge to the exit lane since that lane funnels another previous merge lane. I press the gas and the gauge stayed frozen at 60mph then a violent loud clunk came from the floor like as if the transmission gear got stuck and then slipped in. After parking at the store the hybrid inverter coolant refill warning came on the dash. I drove back home to get fluid 2 miles from home the vehicle lost all power. The issue is search through the internet I’m seeing many many kia sorentos hybrid or gas with the same inverter issue. And every person posting online says the dealer has the same excuse a rock hit and punctured the small radiator. But the car also had a check engine light on and the dealer never brought that up. I’m a mechanic for 12yrs. Something fishy is going on, thank you.

NHTSA #11611411

Kia has failed to provide proper protection for their radiator on their Sorento and Telluride models. There are many many many reports online of these radiators sustaining damage which should not have occurred, and Kia refuses to cover any of these repairs under any type of warranty. In my example, my brand new 2024 Sorento with 1,300 miles overheated and dumped all of its coolant due to what the Kia dealership claimed was a puncture in the radiator. The vehicle was never driven off road, and had never been hit by anything. If Kia has a guard in place to prevent this from happening, the guard is insufficient and should be a concern. Kia refused to cover this issue under their warranty.

NHTSA #11595462

The vehicles windshield may not be sealed properly or have moisture that builds up between the pressed glass causing reduced visibility and higher risk for crash obstructing the view of both passenger and most importantly the driver.

NHTSA #11740994

Panoramic sunroof panel spontaneously exploded at highway speed.

NHTSA #11703966

The vehicle was driven home from work, parked outside in a secluded spot. When I went to leave like an hour later, there was a huge crack in the windshield on the driver side. The crack seemingly appeared out of nowhere, and there is no chip, indicating that it was hit by something that would’ve caused the crack.

NHTSA #11676094

headlights and taillights went out while driving and a few seconds and then came back on and everything on the dash also went out and came back on. i was driving at night time when this happened it put me and my child at risk. i called the dealership and they refused to fix saying that my kia is not impacted by this recall. But that i could schedule an appointment to have my headlights checked, i explained to them there is nothing wrong with my headlights this is clearly a software issue, Tonya at Kia Louisville east is still saying its not related to the recall, and is scheduling appt to have my headlights checked. no warning lamps messages or any other symptoms before this happened and has only happened the one time.

NHTSA #11698885

Front headlights are fogging up and blocking headlights. Dealership has looked at the issue and waiting for KIA to approve the replacement. No action yet, but if this is happening to my SUV, I'm sure others are having the same issue.

NHTSA #11655357

No less than 6 times in approximately 8000 miles the vehicle has lost all electrical power while driving and then regained power. All interior electric components are lost, power steering, headlights, everything. Twice it has completely stalled out when this has happened. I cannot recreate the issue on-demand. On occasion, the vehicle will not hold a hill. It will drift backwards when taking your foot off the brake. Again, this is not reproducible and is completely random.

NHTSA #11638983

We purchased the car around Thanksgiving of last year (2023). A month and a half after purchase, we noticed all the warning lights coming on all at once. When we reported the incident and safety concern with the Kia dealership, they claimed it would be okay and we had nothing to worry about until our service appointment in Mid-March. Today, my wife was driving with my mom in the car and the brakes completely failed while they were driving on a major highway. Fortunately they were able to pull the car into an embankment before going down a large hill into the valley. We had the vehicle towed back to the Kia dealership where they’re running tests and diagnostics to identify the issue. We’ve also opened a case with customer affairs at Kia of America.

NHTSA #11573528

At 7,100 miles the transmission failed requiring a new transmission replacement after one year. At 16,636 miles (2years into the lease) the new transmission also failed, and the car is in the garage getting another transmission replacement after.

NHTSA #11733308

The contact owns a 2024 Kia Sorento. The contact stated that the radiator was leaking. The vehicle was taken to a local dealer and the dealer stated that a rock or road debris had caused the puncture in the radiator. The contact was advised by the dealer that it was a known failure and that there was no radiator debris shield to protect the radiator from damage. The contact was informed by the dealer that the repair was not covered under warranty. The manufacturer was contacted and informed that the contact that repair was not covered. The contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was 23,417.

NHTSA #11729386

EBP light comes on dash while driving. Codes have been determined by dealership but refuse to fix unless light is active. To get light off - must stop vehicle and turn on and off EBP switch and light goes off. Switch or sensor not working causing the problem.

NHTSA #11720380

1. **Component or System Failure:** - The malfunction occurred in the **automatic braking system** while the vehicle was in **snow mode**. The brakes engaged and locked the wheels, resulting in a loss of traction. - This system is available for inspection upon request to assess the failure, where the car was towed to. 2. **Safety Risk:** - The automatic brakes locking the wheels put the driver at risk by causing the vehicle to slide uncontrollably. - The situation was further exacerbated by the fact that the vehicle collided with a tree, indicating a significant safety concern. 3. **Reproduction of the Problem:** - It is unclear if the issue has been reproduced or confirmed by a dealer or independent service center, but given the nature of the malfunction, it would be advisable to have it inspected by a professional to verify the problem. 4. **Inspection by Authorities:** -the vehicle was inspected by police and the towing coming stating the car was a total loss because of the damages . 5. **Warnings or Symptoms:** - There were no indications of a problem prior to the failure, such as warning lamps or messages. The incident occurred suddenly when the brakes engaged, leading to the vehicle losing traction and ultimately colliding with a tree. - The failure of the airbags to deploy on the passenger side is also a critical point that needs further investigation. ### Key Takeaways - The automatic braking system malfunctioned in snow mode, leading to a loss of traction and a collision. - Safety was jeopardized due to the vehicle's sliding and the failure of the airbags to deploy. - Further inspection by qualified professionals is necessary to confirm and address the issues.

NHTSA #11711697

On 3 separate occasions, while idling, the engine will sputter as if it’s about to cut off. The RPM will rise and fall and the engine will rev up and down and finally it will quiet down. Once the light is green, It is able to drive as normal. At the next light the same thing happens and the engine revs up and down sounds like it’s about to die. At a certain point the car will lose propulsion,(hard to notice at first when it’s stop and go traffic) even with the pedal all the way down, making it difficult to drive at a safe speed. The car will operate this way in a very limited capacity w stuttered propulsion for a minute or two then a warning symbol and alarm sounds letting me know there is a safety issue with the hybrid system and to stop safely. The car then becomes completely unresponsive and you must stop immediately and shut the car off. Once restarted the car jolts back up and operates somewhat normally.

NHTSA #11704560

Car has sensor issues. It ran into pole and median after defective collision assist said sensor was blocked. Has emission leak. Second vehicle i had with that and they wont cover under warranty. Kia refuses to by back a car do not feel safe driving. They refuse to fix things under warranty. The refuse to do anything about sensors, says its the safety features and they cannot remove them. Only offered me 19k for car. Why would I be upside down for a car that was sold to me with safety features issues..

NHTSA #11712048

I was involved in an automobile collision. It was a T- Bone collision on the driver side. My vehicle flipped on it's side, the moon roof completely shattered, my seatbelt released me and I was ejected through the moon roof. The vehicle landed on top of me. All of my air bags did not deploy even though my vehicle rolled over twice.

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11698884

The vehicle is jerky, loss of power, jolts, and very high concern of safety while in use.

NHTSA #11708235

On August 6, 2025, I discovered that both the driver and passenger front seat belts in my 2024 Kia Sorento were installed backwards from the factory, with the buckle facing inward instead of outward. This defect has been present since the vehicle was purchased brand new, but it was only discovered and documented on this date. The issue was confirmed by an authorized Kia dealership in an official service report and in a video recorded by the service technician. I also have photos and videos taken before the dealership visit showing the same defect. This is a manufacturing defect and poses a serious safety risk to occupants in the event of a collision, as the seat belts may not function as intended. Supporting documentation is available upon request.

NHTSA #11681221

Vehicle hesitation, transmission slippage at low speeds for up shifting and hard shifting. Pulled out of a parking lot onto a main road from stop and my vehicle would not upshift and sounded like I was in neutral and would not accelerate. I had a vehicle behind me that almost rear ended me, I pulled over and had to put the vehicle in park. Once restarted, it would shift again.

NHTSA #11673136

On two separate occasions, my 2024 Kia Sorento has activated its automatic emergency braking system, as if anticipating a potential forward collision on an empty Florida highway. The dashboard lights illuminate precisely before the forward collision warning and emergency braking lights activate and commence engaging. Since then, I have noticed a loose sensation in the steering wheel and a diminished braking response. Also screen on dash will randomly shut down and will not allow me to check my vehicle systems or to Kia connect.

NHTSA #11664705

The passengers window will not roll down the sound of clicking you can hear though when switch pushed this is a VERY common ongoing issue via KIA SORENTO COMMUNITY THREAD THAT GOES BACK OVER 7 years it’s never addressed or serious it seems for the services dept of several member’s experience to find the cause leading to ongoing hassle and inconvenience for those with one dealer hours away and the vehicle as NEW BRAND NEW ONLY 3k miles as mine! It’s a safety issue to say the least children on board

NHTSA #11659390

On March 19 I completed my 8,000 mile oil change and then drove to Florida. I had a warning light to change my oil since the company did not reset it. Unsure of the other warning lights. As I was driving in Florida on the interstate the car started having issues. It was making a noise, then started smoking and by the time I got off the exit and got out the front right of the car was in flames. I was transported to the ER with smoke inhalation. The car in still in Clermont, FL with no resolution. The car has been inspected by the insurance and a third party inspector. The last I was told the inspection report is with the Kia engineers. I am unaware at this point what the failure was that led to the fire. No response from Kia for over a month.

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11668617

My vehicle has issues with the power steering. At random times, day or night, the wheel steers to the right and I have to force my grip on the wheel to avoid crashing. It last between 3-5 seconds. No lights or alerts light up on the dashboard. Dealerships have been unable to assist me, I have gone to three different ones. They cannot identify the issue. Loss of power steering assist increases crash risk, since it’s harder to control the vehicle in tight maneuvers or emergencies. Car is available for inspection.

NHTSA #11698072

While utilizing cruise control on the PA Turnpike, the check engine light flashed on and the Sorento began to lose speed. The cruise control was attempting to compensate and pushing at 100% power, however the speed continued to decrease. We turned off cruise control and still were unable to increase speed. We were at 100% acceleration but lose 1 MPH every ~10 seconds or so. We pulled over and kept the vehicle running. Opened the hood and saw the engine shaking violently. We turned the car off - waited ~30 seconds and turned it back on. The vehicle operated fine afterwards and since. Dealers are unable to diagnose in a timely manner and are booking 1-3 months out - even further if you need a loaner vehicle.

NHTSA #11612757

The rear passenger seat has a major safety issue. The back will pop forward and then the entire seat moves forward pushing the passenger into the back of the passenger seat. I have brought this to the dealership two times now and it is still an issue that they now refuse to repair. I have video but can't load it here.

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11602826

Reason is unknown, was driving down road and car yanked to the right cause family to wreck in to a guard rail, no lights appeared before wreck, it was not raining and was not speeding. Clear sunny day. Police report has been made and has made several attempts to contact KIA, car has been in body shop since July. Wreck has happened in July. Car is still at body shop KIA told body shop there was no time line on getting any parts to repair, they do not know if it will be this year.

NHTSA #11621683

All dashboard lights turned on and were orange during two separate instances. During both instances I went to brake and nothing happened. Eventually the brake finally engaged. On one of the instances the brakes took ~5 seconds to re-engage while coming to a traffic light stop. There were two pedestrians that I almost hit before they re-engaged.

NHTSA #11582040