Hyundai Santa Fe 2024: Retiros, Quejas y Ley de Limón de California

The vehicle has experienced repeated transmission-related failures beginning at approximately 5,000 miles. The dashboard warning “Transmission System Error – Check Transmission Oil Immediately” first appeared while driving and was accompanied by sudden loss of power. When this occurs, the vehicle loses acceleration and drivability while in motion, creating a safety risk in traffic. The only way to temporarily clear the warning is to pull over, shut the vehicle off, and restart it. Photographs of the warning message were documented at approximately 6,738 miles on [XXX] and again at approximately 12,664 miles on [XXX]. The vehicle was returned to the selling dealer in Massachusetts multiple times for the same issue. During the first visit, the dealer drove the vehicle approximately 19 miles but stated they could not duplicate the problem. During the second visit on or about 3/25/2025, the dealer kept the vehicle for approximately six days while providing a loaner vehicle, but again stated they could not duplicate the condition. The vehicle was later inspected by another Hyundai dealer in New Hampshire on 8/19/2025 for the same dashboard warning and loss of power condition while driving. That dealer found the transmission fluid level below specification but stated they could not duplicate the warning message during inspection. Following that visit, the transmission warning did not reappear until [XXX], when the same “Transmission System Error – Check Transmission Oil Immediately” warning returned again while driving. On [XXX], the situation escalated into a possible rollaway event. While at an auto detailing facility, the vehicle was reportedly placed in Park with the engine running after being repositioned. The operator stated the vehicle indicated it was in Park. Moments later, after the operator exited the vehicle, the vehicle moved from its parked position and rolled into a building. The event was documented in writing by the detailing facility. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11739792

The contact owns a 2024 Hyundai Santa Fe. The contact stated that while the vehicle was turned on and shifted into park, the vehicle unexpectedly rolled away with no warning light illuminated. The contact stated that the vehicle then collided with a tree. The contact also stated that the air bags did not deploy during the crash. No injuries were sustained, and no medical attention was provided. The vehicle was taken to an independent mechanic where full body repairs were completed. The vehicle was later taken to the dealer; however, the vehicle was not diagnosed or repaired. The contact stated that the failure recurred, and during the second incident the contact’s spouse attempted to stop the vehicle and was almost run over. No injuries were sustained, and no medical attention was provided. The contact stated that the their arms and fingers are hurting during the failure, The contact stated that the vehicle then collided with an area of the contact’s home. The contact stated their concern that there vehicle is very hazardous and very unsafe and the failure could have been worse for the contact's spouse. The manufacturer was made aware of the failure. The failure mileage was approximately 32,000.

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11736056

When starting the vehicle, a transmission system error occurs because goes away when the car is shut off then restarted. When the error occurs the vehicle does not accelerate properly.

NHTSA #11737216

The glass in the sun roof imploded. It it available for inspection. The glass would have been propelled into the vehicle if the sun roof was open. The problem has been reported to the dealer and acknowledged. There was no warning prior to the implosion.

NHTSA #11732714

Rear bucket seat crushes occupant of seat belt is not buckled. Rear facing car seat is crushed posing huge risk to baby

NHTSA #11725035

I put my vehicle in park but it kept going anyway and hit a car in front of me.

NHTSA #11720532

I bought the 2024 Santa Fe XRT Pro new off the lot Sept. 2024. Brought it in for 3 different recalls but the electronic system panel is new: The panel lit up with every warning sign it can convey: from the engine light to the coffee break, to the emergency warnings. This has happened twice; once a few weeks ago and again a few days ago. My car is back at the dealership for repair to the electronic panel. The first time, the dealership replaced the entire panel as it is still under warranty. It's at the shop again and I don't know what they will do this time. I would trade it in, but the trade-in value sucks.

NHTSA #11737038

I purchased the Vehicle from Ourisman Hyundai of Bowie, Inc. (Bowie, Maryland) on [XXX] (the “Date of Purchase”). Within a few months of the Date of Purchase, I began having issues with the digital dashboard and heads up display. Both the digital dashboard and heads up display would go completely dark, leaving me an inability to view essential operational and safety information, including but not limited to, the speedometer, rear view camera, blind spot cameras, driving mode, driving gear, navigation, warning messages, lane following assist, tire pressure monitoring system, driver attention warnings, etc. (the “Hazardous Condition”). After multiple calls and emails with the service manager at Len Stoler Hyundai (Owings Mills, Maryland), I took my car to their dealership on November 5, 2024, December 30, 2024, and May 28, 2025, to have Hazardous Condition corrected. Although Len Stoler Hyundai was able to slightly improve the Hazardous Condition such that it was more intermittent – going dark for minutes or hours at a time instead of days at a time - the problem was never satisfactorily resolved. Recently, the Hazardous Condition became less intermittent, and all screens went permanently dark. Since Len Stoler Hyundai closed their doors, I reached out to Heritage Hyundai Owings Mills to address the Hazardous Condition. After a detailed call with a service advisor, I dropped off the Vehicle to them on August 15, 2025, and as of the date of this letter, thirteen (13) days have passed without them resolving the Hazardous Condition, or even returning my repeated telephone calls. To date, Heritage Hyundai Owings Mills remains in possession of the Vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11683707

I tried to open the doors of my locked vehicle with the key fob and there was no response. I tried several times and nothing happened. I called AAA and they opened the door with my valet key and was able to pop the trunk. He checked the battery and it was working fine. He then noticed that the wire connecting the battery to the fuse box has melted at the point of contract with the fuse box and actually melted part of the plastic fuse box. There was nothing he could do, so I had to have the car towed to the dealer. I was lucky that the total meltdown of the electrical system did not occur when I was driving or I would not have been able to see any of the controls on the inside of the auto and not be able to use the gear shift to put the car in park.

NHTSA #11673035

Pirelli Scorpion MS 255/45r20 105, was driving at low speed in flat smooth parking lot when the tps monitor went off. I went from 35 psi immediately to 19 and dropped 1 psi poer second as a i parked. by the time i parked i had 12 psi. notices side wall blew out. same issue as my other tire on my last report. AAA driver stated it looked like product malfunction or dry rot. Tire had 13,111 miles on it.

NHTSA #11745178

pirelli tire has less than 13k miles on it. car was parked outside. came back and the tire was deflated in minutes. found the leak to be on the inside outer wall. just blew out on its own. had the same problem with the passenger front. same tire same issue 3 weeks later. will ber making a separate complaint. they are both a pirelli scorpion ms 255/45r20 105

NHTSA #11745177

Size & Description 245/45R-21 I just took my 2024 Santa Fe Caligraphy with 20k miles to get it inspected and I have 3 bad tires due to bubble/buldge. I can see that a lot of people are having this issue online. The tires are 500 each. I purchased this car new a year ago and the tire place said they had another one with the same issue. Looking for some help

NHTSA #11734590

Have a 2024 Hyundai Santa Fe Calligraphy Hybrid with a Drivers Attention Warning problem. The warning turns on frequently when using cruise control. When the warning beeps a few times in quick succession it actually shuts down the system, reduces speed to a crawl, and turns off the engine. This only happens while using cruise control, no issue with DAW when cruise control is off. So can't use cruise control on the highway/interstate. Dealer is no help. This is obviously a safety issue when the engine turns off while driving on an interstate. Thanks

NHTSA #11669192

The Adaptive Cruise control cannot be used while wearing certain sunglasses. The car has a Driver Awareness Warning that is supposed to warn the driver if eyes are not on the road. It does not work with certain glasses. While driving at interstate speeds, I engaged the Adaptive Cruise control only to have it shut off and quickly slow down. After fumbling with different glasses while driving, I found a pair that will work with the Adaptive Cruise control. In the display, there is a toggle to turn off the Driver Awareness option, but as soon as you turn on the Adaptive Cruise, the Driver Awareness turns on again. If the Driver Awareness function cannot be turned off it is a safety issue. My favorite driving glasses cannot be used and I think this issue will cause accidents with the quick slowing on the highway. There should be a way to turn off the Driver awareness so I can use the adaptive cruise with my sunglasses.

NHTSA #11664854

On a bright sunny day, the Hyundai Forward Attention Warning (FAW) SHUT OFF my adaptive cruise control while doing 70 mph, indicating that I was not focused on the road. I was looking straight ahead at the road the whole time. I later determined that the system was reacting to glare on my glasses (not sunglasses, no tint whatsoever, just glass). This led to a very dangerous condition because I was fighting with the car to determine what had happened (at 70 miles per hour), not focused on the road as I just had been prior. The system is checked as OFF in setup (as described in the manual) but clearly that was not the case. The driver CAN NOT shut the system like the manual says. I actually love the car, EXCEPT for that "feature". This subsystem should never have been permitted into a production vehicle and, had I known, I would never have purchased. It's that big of a problem. The system appears to be very dependent upon ambient light because I never have this issue when it's cloudy, raining, or at dawn or dusk. I have complained at 2 Hyundai dealerships here in the Chicago area, to a total of 4 Hyundai personnel, even sent a video my daughter recorded of me driving and exhibiting the issue. In 3 of the 4 cases, they replied the "system was performing as designed". That appears to be their mantra. The one service person replied that they had never heard that before. I guess they don't ever check Reddit or write down my many complaints. I think it's clear Hyundai, as a service organization does not intend to do anything about this and, perhaps worse, the company at large has no intention of doing anything as this same subsystem is part of an extensive line of their 2025 models as well.

NHTSA #11659658

I have had the driver’s side wiper blade stop working properly twice since purchase. The first instance involved ice within the vicinity of the wiper arm mount on the driver’s side. There was compacted snow and ice next to the arm motor mount location. When the wiper was activated, the wiper could not extend fully vertical due to the snow and ice in the corner and this caused the wiper arm to become loose. The driver’s wiper arm then failed to properly operate and frequently overlapped the passenger wiper arm/blade which still functioned. The arm was replaced under warranty at a dealership. The second time this happened, I was driving during a snowstorm and the wiper was turned on with minimal snow and ice accumulation from roughly one hour of driving and occasional wiper use. The snow buildup between the driver’s wiper blade and the A pillar prevented the blade from completing a full sweep of the windshield and the driver’s side wiper came loose and failed to function properly. It frequently became entangled with the passenger wiper blade, causing visibility issues while driving. I have an appointment for this. The wiper arm itself has splines that match up with the wiper motors located between the hood and windshield. If an obstruction of snow or ice either holds the wiper blade down or prevents a full range of motion, the wiper motor easily strips these splines from the wiper arm, resulting in wiper arm failure, damage/bending of the arm(s) and cosmetic damage to the plastic A pillar trim (from wiper over extending past A pillar. The design of the vehicle wiper recess location prevents lifting the wiper arms if there is any snow or ice accumulation on the vehicle and the wipers are in the normal down position. Combine this with the lack of any melting capability from the windshield defroster or a dedicated wiper defroster, there is no way to ensure the wipers will function properly when needed during a snow or rain storm and freezing conditions.

NHTSA #11714843

I am writing to formally file a complaint regarding a sudden and unexplained crack that appeared on the windshield of my vehicle, which was parked in my driveway overnight. The vehicle was stationary, had not been involved in any accidents or incidents, and was not subjected to any apparent external impact Upon discovering the damage, I conducted thorough research and found that more than one owner of the same vehicle or same type of model have experienced an identical issue — a crack that originates at the very top edge of the windshield starting from the top and travels downward through the middle of the glass. The consistency in the location and pattern of the damage strongly suggests a potential manufacturing defect or a design flaw. This issue raises serious concerns not only about product quality but also about driver safety. Windshield integrity is a crucial component of vehicle safety systems, and such defects can compromise visibility and the structural strength of the car in the event of a collision.

NHTSA #11679666

Windshield washer nozzles spray so low on the windshield that the center and top won’t clean which makes driving unsafe.

NHTSA #11673029

When accelerating from a stop, the transmission fails to engage causing the engine to rev but not allow for movement until the gas pedal is disengaged then engaged again. This happens sporadically and I have not been able to find a pattern or reason for this issue. I have reported this to Hyundai and taken the vehicle in but the dealership was unable to reproduce the issue after driving the vehicle for 20 miles. This is a safety issue as the vehicle does not always accelerate as expected from a stop and could potentially cause an accident.

NHTSA #11696822

When making a right turn from a complete stop, the vehicle intermittently exhibits noticeable hesitation and reduced acceleration compared to normal straight-line launches. This has occurred approximately 5–6 times. The delay in power delivery creates an unsafe condition when merging from on-ramps into higher-speed traffic, as the vehicle does not accelerate as expected. This mismatch between expected and actual acceleration can lead to misjudgment of traffic gaps. No warning lights or diagnostic messages have appeared. The issue appears intermittently and specifically during right-turn launches from a stop.

NHTSA #11722281

Transmission. Less than 6 months of buying the vehicle, Hyundai replaced the transmission and now I’m still having problems..it revved up to 2.3 rpms but didn’t change gears then jerks into gear..not everyday but atleast once a week. I’m waiting now on the dealership to look at my car now..but they’re dragging their feet.

NHTSA #11642945

In TWO separate occasions, the middle row seatbelts have unbuckled on THEIR OWN. We have also had issues with the buckles NOT buckling OR unbuckling when prompted. (Like it’s stuck in the buckle to unbuckle or won’t click in) Other issue is the car will randomly tell me my child is unbuckled but they are NOT. Today, the sensor went on and off multiple times telling me buckled, unbuckled, over and over meanwhile my child was buckled. Why is it telling me she’s not buckled if she is….??? And why has the belts unbuckled on their own? (The first time it was my toddler in his car seat who CANNOT reach the buckle)

NHTSA #11701830

Both driver and front passenger seat belts are nearly impossible to snap it and it is just as hard to get them to release. Sometimes you think it is snapped together and it comes out going down the road. I have taken it to the dealer and they said the parts are on back order and have been for a long time. This is a serious safety issue. It looks to me like they would be on top of something like this. If there is an accident I don't trust the seat belts to protect me and my family. It has not been listed as a recall yet so I do not understand why they would be on back order for so long.

NHTSA #11720134

The contact owned a 2024 Hyundai Santa Fe Hybrid. The contact stated that while stopped in highway traffic, the vehicle was rear-ended as part of a multi-vehicle collision. The contact's vehicle was identified as the fourth vehicle in the crash sequence. The entire rear bumper area sustained significant damage. The first vehicle that originated the crash was distracted by his phone, which caused him to crash into the rear of the second vehicle, causing the second vehicle to crash into the rear of the third, resulting in the contact being rear-ended. No property damage. The air bags did not deploy. The vehicle was rendered inoperable, towed to a repair facility, and subsequently declared a total loss by the insurance adjuster. The driver sustained multiple injuries, including a ruptured right breast implant, two lower back herniations, and a neck herniation. A minor child occupant seated on the front passenger's side also sustained a neck herniation. The driver and minor child occupant received medical treatment following the incident. The contact also had her service dog in the rear, and due to the severity of the impact, there was difficulty removing the service dog safely from the vehicle. The contact expressed concern that the seatbelt system did not provide adequate restraint during the collision and related the issue to NHTSA Campaign number 26V218000 (Seat Belts). The dealer and manufacturer had not been notified of the failure. The approximate failure mileage was 30,000

Reportado presuntamente: 2 lesiones (según lo reportado a NHTSA). NHTSA #11731124

While driving my 2024 Hyundai Santa Fe on the interstate, the “Keep your eyes on the road” alert repeatedly activated even though the driver was attentive and looking forward. After multiple warnings, the system escalated to a message that the vehicle was about to be disabled, which created a serious safety concern. This happened even though the Driver Attention Warning feature is disabled in the vehicle’s settings. The issue appears to be caused by the steering-column driver monitoring camera system falsely detecting inattention. The constant alerts are distracting, and the threat of the vehicle disabling features while driving at highway speeds is dangerous.

NHTSA #11690706

After car is idle, when pressing the gas, the car instantly stops as if you have slammed on the break, feeling like you have driven into a brick wall. The intensity of the stop causes you to jerk aggressively in your seat. This has happened on more than one occasion. Without a seatbelt it would cause injury as well as the possibility of causing an accident with other vehicles. When this happens, there were no warning lights or messages shown to indicate an issue. The vehicle is currently at the dealership as of 9/20/2024, they are trying to replicate the issue however it has been more than 2 weeks, and they have not found a resolution. They have run diagnostics tests and there was nothing that indicated the issue with the vehicle. As of today, 10/9/2024, the issue has not been resolved and the vehicle remains in the dealers possession.

NHTSA #11618837

If I wear dark sunglasses, the forward collision avoidance turns off while using cruise control. If I wear lighter sunglasses, it is fine. Unfortunately, I have to wear darker sunglasses due to previous eye surgery. I am unable to utilize cruise control without compromise to my eyes because forward collision avoidance doesn’t work with darker glasses. This happens every time I test it and change sunglasses with differing shades of protection.

NHTSA #11608265

3 times now, I am driving and the vehicle goes into limp mode, the "D" on the dash is flashing but the vehicle sends no codes. The tech said the vehicle can immediately delete the code and they can't fix it if they can't duplicate it. It also hesitates when accelerating and is dangerous to myself, my 4 children and anyone driving around me when it goes into limp mode. There is no code, therefore they say they can't do anything about it.

NHTSA #11736861

While driving my 2024 Hyundai Santa Fe, the vehicle experienced a complete dashboard and system blackout, as if the vehicle shut off and rebooted. This has occurred on two separate occasions. On one occasion, while stopped at a traffic light, the dashboard went completely black and restarted. After the system rebooted, the vehicle would not accelerate or move when the accelerator was pressed. I had to turn the vehicle off, restart it, and wait before it would drive again. The suspected malfunction involves the vehicle’s electrical/infotainment and related vehicle control systems. The vehicle is available for inspection upon request. My safety and the safety of others were put at risk because the vehicle lost critical dashboard information and temporarily lost the ability to accelerate while in traffic, creating the risk of being struck by other vehicles. The vehicle was inspected by an authorized Hyundai dealership (World Hyundai of Matteson). On December 23, 2025, I was informed by the dealer that a system/infotainment “glitch” had been identified and that a replacement part would be ordered. However, the part was never replaced. The dealer later stated that because the issue could not be duplicated during test drives (approximately 85 miles driven), the repair was not authorized. The dealer acknowledged the issue could not be reproduced on demand. The manufacturer (Hyundai) has not yet physically inspected the vehicle beyond dealership involvement. No police or insurance inspections occurred, as there was no crash. There were no warning lamps or messages prior to the failure. The failure occurred suddenly with a complete dashboard blackout and system restart. The first occurrence happened prior to December 23, 2025; the second occurred afterward. The issue is intermittent and unresolved. I am concerned that the defect must reoccur while driving in order to be repaired, posing an ongoing safety risk.

NHTSA #11710932

My vehicle was in for repairs at both a collision shop and a dealership following a minor accident. When I got the vehicle back, I found that the seat controls were not working, preventing me from moving the seat backward or forward. During a test drive, the car lost power despite the gas pedal being fully pressed; it wouldn't accelerate and then suddenly jerked forward. This could have caused an accident if I had been on a busy highway. Further testing revealed an abnormal noise at 1500 RPM in multiple gears. The vehicle has been towed back to the dealership, but there's no word yet on when it will be fixed. Hyundai has been contacted multiple times, as the car has been awaiting parts and undergoing repairs for over four months. They don't seem to be taking these safety issues seriously nor helpful in resolving the issue.

NHTSA #11624601

Our 2024 Hyundai Santa Fe Limited Hybrid, which was purchased brand new in Massachusetts in 2024 has been rattling at the passenger side B-pillar since [XXX] and has been in the dealership now 5 times for repairs and 16 service days. They have found that the vehicle is missing spot welds from point of assembly. Hyundai, as repair attempt #5, provided the dealership with documented instructions to hammer and chisel the frame 6.5 inches apart and insert foam NHVpads to see if the rattling would stop, it did not. Hyundai Techline instructed the dealership to repeat this step again. The dealership refused citing major safety concerns with the frame of the vehicle. All documentation including Hyundai Techline guidance is available and submitted with this complaint. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11730909

The contact owns a 2024 Hyundai Santa Fe. The contact stated that the vehicle's liftgate would independently open while idle without warning. The contact stated that while washing her vehicle on an inclined driveway, the liftgate opened without warning. In an effort to avoid being hit by the liftgate, the contact fell to her left side on a concrete driveway. The contact suffered pain and bruises to the left side of her body, with major pain in her left foot. The contact was home alone and managed to drag her body onto a chair before calling her husband for assistance. The contact's husband drove the contact to an urgent care facility, where an X-ray was performed; the X-ray showed no fractures. The facility stated that their equipment was not sufficient to treat her injuries, and they placed a boot on her left leg and referred her to an orthopedic doctor. The contact went to the orthopedic doctor, who performed another X-ray, which showed no fractures. The contact was given another boot; however, the pain remained days after the visit. The contact then went to her pre-scheduled primary care doctor's appointment, where her doctor saw her condition and referred her to another orthopedic doctor. While at her second orthopedic appointment, another X-ray was performed, which also did not show a fracture; however, the orthopedic doctor suggested an MRI scan. The MRI scan showed that the contact had suffered a left heel fracture. The contact also went to another facility for a CAT-scan, which showed that her heel was misaligned and that surgery would be needed to correct the left heel fracture. The contact had surgery for the heel fracture and had the foot wrapped and splinted; the contact was given several medications post surgery. The contact had been scheduled for a follow-up appointment to monitor the heel's progress. In addition, the contact sustained injuries to her left wrist, left buttocks, and left lower calf. Since the injury, the contact has had to use a knee scooter, a walker, and a wheelchair for assistance with her mobility. Neither the dealer nor the manufacturer had yet been notified of the failure. The vehicle had yet to be repaired. The failure mileage was unknown.

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11729920

The trunk will occasionally not open. The car and trunk are unlocked, and when you pull the handle to open the trunk the car beeps like it's trying to open it, but it will fail to open and will then give some failure beeps. This has happened to me several times, and I've read online this issue has happen to others too. This is a safety hazard and makes the trunk unusable when it happens. I have a video of the trunk not opening, but it doesn't look like I'm able to upload videos files to this submission.

NHTSA #11612883

When the power button on the seat is pressed to move the seat forward or fold it down, the second row captains chairs fail to stop from folding if someone or something is in the seat.

NHTSA #11726394

A child was exiting the vehicle from the second row driver-side seat, and the seat fold-up button (on the shoulder of the seat) was accidentally tapped. The seat began to tilt forward to collapse, squeezing a toddler in a rear facing child seat between the seat and the back of the front driver seat. Thankfully, the child seat bore the brunt of the pressure, but the incident clearly demonstrated an absence of sensors or logic to disallow the button to function when a child seat (using latch) is installed. We then tested the passenger seat in the second row and found that, even if a seat occupant is present, if the seatbelt is not buckled, the button WILL continue to operate and crush the passenger. That is to say the collapse function of the seat is uninhibited by the weight or resistance of a seated passenger. This is especially alarming given our elementary age children enter and exit the car on their own with little assistance requested from us.

NHTSA #11725023

My daughter was sitting down on the middle row and the button to fold the chair down was accidentally pressed. When she screamed bc she was getting smushed I jumped out of the vehicle and pushed the button to stop the chair from folding. Thankfully she was able to lay down sideways or I am sure the outcome would of been worse. She is so traumatized and does not want to even sit in the vehicle any more. She is only 8!!! This is traumatizing as a parent as well. This needs to be fixed !!!

NHTSA #11728156

The "take a coffee break" system is out of control. Encourages me to take a break repeatedly, even when i have both hands on the wheel and am staring straight ahead. It's distracting and frustrating, and cannot be turned off.

NHTSA #11695344

2024 Models appear to not allow disabling the "Consider taking a break" alert even when disabling the "Driver attention warning" feature. This alert appears to go off on imperfect roads at seemingly random intervals when the car "thinks" you are driving improperly. The alert is abrupt, jarring, and unsafe in my option. I have no idea why they would release a model where you can't disable it when in previous models you easily could. It appears this is a common problem from my research online and I don't think Hyundia has made any steps to fix this.

NHTSA #11627889

The blind spot cameras work intermittently. When the cameras do not work a green video screen is displayed on the driver's video dash screen.

NHTSA #11623881

Vehicle was not driven for 2 days. The check engine light is one and says "active airflap issue" the flaps appear to be open when a/c is on and closed when vehicle is off. There is no debri or anything arount the air flaps. This could cause potential overheating and should not happen in a years time. We travel for my husband's job and this could be very dangerous. We thought we were buying a new RELIABLE vehicle.

NHTSA #11689964

Vehicle has about 4k miles. Received “transmission system error, check transmission oil immediately”. The vehicle barely drives. Has a hard time changing gears. Hyundai says there are no recalls and are not being helpful in getting help. They say everything is fine but it is clearly not working. Brand new vehicle and cannot get it fixed.

NHTSA #11657034

The issue I have is related to the transmission and exactly what is outlined in the Hyundai Santa Fe recall 236. My car was not included in that recall though. But the problem is exactly the same.

NHTSA #11618549

Bought in Sept 2026 with 30,000 miles. Would not stop when breaking at low speed but would jerk and accelerate, causing me to drive through red lights and stop signs. How to swerve to avoid collisionHappened about 6 times. Returned to dealer. States could not duplicate. Traded car in

NHTSA #11703900

The vehicle was purchased brand new and at near 8k miles the brakes became warped. It caused severe shaking on the highway and has continued to get worse. Hyundai confirmed the brakes were bad but refused to replace the rotors. Rotors on a new car should not be warped at 8k miles, cheap materials lead to that

NHTSA #11680171

When placed in "Park" the vehicle's brakes did not engage, which allowed the vehicle to roll backwards when I exited the vehicle. I was able to reproduce the problem again and I recorded a video showing the problem. When pressing "Park" on the electronic shifter, the dashboard displays that the video is in "Park". However, the brakes are not engaged as evidenced by the vehicle rolling backwards when I take my foot off the brake. After reproducing the issue a couple times (~ 10 minutes later) and documenting the issue with a video, the check engine light eventually came on and the dashboard displayed: "PARK malfunction. Engage parking brake when parking vehicle." Which quickly changed to the warning message: "Shifter system malfunction! Service immediately" The vehicle would no longer let me place it in "park" and it remained on in "accessory mode" and I was unable to turn off "accessory mode" since the vehicle could not be placed in park. However, neither of these error messages appeared the 3-4 times I was able to place the vehicle in "park" and then observe it roll back. The vehicle has been towed to Northwest Hyundai for inspection/repair. >> How was your safety or the safety of others put at risk? The car rolling uncontrolled is a huge safety hazard to anyone that happens to be in the path of the car. It is also a huge safety hazard to any occupants that might remain in the vehicle when the driver exits after placing it in park. >> Has the problem been reproduced or confirmed by a dealer or independent service center? Not yet. The service error that appeared prevented the car from being placed in "park". However, I was able to capture a video of the problem. >> Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, there were no error messages of any kind.

NHTSA #11591669

We just brought this vehicle in for the ongoing transmission problem (previously reported to your agency after the car self-accelerated), as well as the missed seatbelt recall that was not addressed at the last dealership. I advised the service advisor that the seatbelt recall needed to be fixed. The service advisor contacted us several hours later to tell us that they were replacing the transmission. 10 days later we picked up the vehicle after the transmission replacement, and the service advisor told us they did not do the seatbelt repair, citing lack of parts and/or special order. I asked if this was a safety issue and if I should leave the vehicle with them for longer, but was told not to worry about it, and to bring the vehicle back at another time. Fast forward to today, and the vehicle is rolling forward when we start it. This is worse than the way it rolled forward before the transmission replacement. Coupled with the disregard for the seatbelt recall, I believe there is a serious safety issue with this vehicle. I have notified Hyundai Corporate, as well as our attorney, and will be contacting the dealership to drop the vehicle off. I have a video recording of the car rolling forward during startup, but it appears I cannot upload it here. I have forward that video to the above mentioned entities, and am happy to share it with your agency as well.

NHTSA #11744065

We have had several transmission issues with this vehicle for over a year. On March 5th we dropped the car off for an oil leak, a malfunctioning middle row seat belt, and an on going transmission clunk and roll. The dealer repaired the oil leak, replaced the seat belt, (damaged the interior of the vehicle while doing so, then denied it) and said they were unable to replicate the transmission problem. The car went back to the dealer again on March 26 for the transmission clunk and roll. They kept it for 8 weeks, and said they couldn’t replicate the issue. I have confirmation that they didn’t even start the vehicle for 4 weeks. We picked up the Vehicle on May 22, and the issue persists. Yesterday, when pulling out of a gas station, the vehicle accelerated on its own until I intervened stepping on the brake pedal. When I typed in the issue to Google, I was made aware that the vehicle now has a front seat belt safety recall from April 6, which the dealer didn’t even advise us on or offer to repair. I am finding out about this on an interstate family drive and we are of course terrified of driving our vehicle now, based on the unintended accessories and now faulty front seat seat belts. I have asked Hyundai serval times for a buy back which they have refused. Corporate has asked us to bring the car back to the dealer this week, and we are about to sign papers with a lemon law lawyer tomorrow. I wanted to at least file this complaint so that it is in writing should something happen to us in our travels this week. This has all been so unacceptable with Hyundai. We bought this car new and it is paid off.

NHTSA #11739969

Hyundai - DAW - Driver Attention Warning / Forward Attention Warning System This issue warrants immediate consideration for a recall. Despite wearing glasses, sunglasses, or no glasses, the problem persists. I occasional do remove my glasses while driving, and the warning continues to sound. This occurs regardless of the time of day, weather conditions, or whether I am sitting upright or reclining. The warning randomly activates and deactivates, sometimes without any intervention. Occasionally, I simply allow the warning to sound without taking any action, and it remains active for a few seconds or until it triggers a warning that the system will be turned off, at which point it deactivates. I have attempted various troubleshooting methods, such as keeping my eyes open, adjusting my seating position, wearing and removing my glasses, and tilting them to minimize glare. None of these methods have proven effective in preventing the warning from activating or in making it deactivate. This is a persistent problem. Hyundai dealerships initially informed me that the warning might be an annoyance and their response was to simply refrain from using it. However, if a basic feature like cruise control in a 2024 & 2025 model is rendered unusable due to a design flaw (which this certainly is), it constitutes a clear violation of safety standards and should be addressed through a recall. The incessant alerts are highly disruptive and can be quite frustrating. For instance, driving with an arm in the 12 o’clock position triggers a warning, while wearing polarized sunglasses also results in an alert. The presence of a setting to disable the warning is a welcome feature, but the system’s persistent alerts can be overwhelming. The alerts continue even after taking a break. It is distracting and a safety hazard. Drivers should be able to adjust the sensitivity of the feature to turn off this feature. Currently, there is no way to disable or temporarily disable this feature.

NHTSA #11741652

when using lane following the system repeatedly warns you to pay attention, usually when in heavy traffic and after repeated warning shuts of the cruise and lane following system. when using the cruise control system the system will suggest you take a break. both problems appear to be associated with an in cabin camera. i have driven my vehicle almost 25,000 miles and taken two cross country trips. the warning system has almost never warned me of a real problem. 99 percent of the time it is a false reading by the camera and occurs under challenging driving conditions when the last thing you need it to be told to pay attention when you truly are. during this winter i have driven more at night and the vehicle is basically un drivable because of false notifications. this has repeatedly happened in the 14 months i have owned the vehicle - the date below is just for when it happened today. i am more than willing to share details and would welcome a call

NHTSA #11716017

Vehicle will not brake assist in the front even though all of the settings are selected it to work and assist in the event of needing to brake suddenly.

NHTSA #11726392

Vehicle Identification Number (VIN): [XXX] Make: Hyundai Model: Santa Fe Year: 2024 Description of the issue: •Component or system that failed: The vehicle’s brake system, including the emergency braking system, failed to slow or stop the vehicle at low speeds. The problem is available for inspection upon request. •Safety risk: This failure endangered my safety and others. While driving slowly in traffic, I fully pressed the brake pedal, and the emergency braking system activated, but the vehicle did not slow or stop, causing a minor collision with another vehicle. •Reproduction or confirmation: Prior to the incident, on two separate occasions, I noticed the brake pedal felt loose or like it “released” at low speeds, forcing me to press harder for the vehicle to slow. These issues were not previously inspected or documented. I was planning to have the brake issue inspected along with a current recall and other concerns, including a stiff seatbelt buckle and a door that was difficult to open, as soon as I had the chance. I have not received any formal recall notice by mail or email. I learned about the recall during routine maintenance at the dealership. •Inspections: The vehicle has not yet been inspected by the manufacturer but I plan to take it to an authorized Hyundai dealership asap for inspection. The accident has not been reported to the police or insurance yet but it will be first thing tomorrow. •Warning lamps or symptoms: No warning lights appeared, but there unusual brake behavior was noted on two occasions about two weeks before the crash. Thought this time was significantly worse, and by worse this I mean the vehicle didn’t brake. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11679733

One of the original OEM tires (Pirelli Scorpion MS KS NCS XL - 245/45R21) had the acoustic dampening foam on the inside of the tire fall apart. Dealership indicated that there was 'no impact damage or modifications found with the tire during inspection; meaning this was likely a manufacturing defect due to adhesion issue. Despite the problem and the fact that this tire has less than 12K miles on it at the time of the incident, the local Hyundai dealership, Hyundai corporate and Pirelli all refused to cover the cost to replace the tire. Hyundai dealer said to file a complaint with Hyundai corporate, Hyundai Corporate said that this was a Pirelli tire warranty issue (no paperwork provided about Pirelli tire warranty at time of purchase) and Pirelli indicated that only the local dealer or an authorized dealer of their tires can submit warranty claims, and that it is contingent upon a Pirelli inspection and prorated based on the remaining tread of the tire. This leaves the consumer in a difficult position having to bear the burden of the tire replacement cost upfront, and little chances of recourse as these 3 parties skirt responsibility of the OEM tire. When the acoustic foam fails, the car shakes violently at high speeds, for us this stats at ~50mph. There is no warning light that appears for this, dealer originally thought this was related to ice build up which did not rectify the problem causing us to have to go to the dealer twice for diagnostics. Online forums seem to point that this acoustic foam adhesion issue is especially common in colder climates. Symptoms of problem first appeared in early January, with full diagnosis confirmed early Feb.

NHTSA #11719072

I lease a vehicle (under one year old) equipped with low-profile Pirelli tires. After three months, one tire developed a sidewall bulge. I contacted Pirelli and was referred to Hyundai. The Hyundai dealership advised that Pirelli tires are not covered under Hyundai’s warranty and that Pirelli must authorize any replacement. I was subsequently informed that Pirelli declined coverage.

NHTSA #11680184

What component or system failed or malfunctioned, and is it available for inspection upon request? Unsure, but likely transmission. I no longer own the vehicle, it is at Tom Ahl Hyundai in Lima, Ohio. How was your safety or the safety of others put at risk? When the vehicle was put in reverse, without pressing the gas the car would rapidly accelerate and jerk as if it was going to stall. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the dealership. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The manufacturer was working on a fix but unable to figure out the issue, so I returned the car. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, no warning lights.

NHTSA #11721258

The contact owns a 2024 Hyundai Santa Fe. The contact stated that while driving behind a trailer at 61 MPH with the cruise control activated, the indicator was activated to switch to the left lane, and the vehicle independently accelerated to the set speed of 68 MPH. The contact immediately depressed the brake pedal to slow down. There was no warning light illuminated. The failure had occurred several times and now occurred whenever the cruise control was activated. The vehicle was taken to the dealer, who was unable to determine the cause of the failure; however, the contact was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 26,434.

NHTSA #11695768

System keeps saying that I am not watching the road, which I am. No eye glasses or sunglasses on. This causes the cruise control to suddenly disengage creating a safety hazard. SUV is up to date on software/firmware.

NHTSA #11673031

THE CRUISE CONTROL USES A CAMERA , THE IS SUPPOSED TO WATCH YOUR EYES , TO MAKE SURE YOU ARE WATCHING THE ROAD . UNFORTUNATELY , IF YOU ARE WEARING GLASSES ( WHICH I MUST WHEN I AM DRIVING ) THE LIGHT REFLECTING OFF THEM MAKES THE UNIT THINK I AM NOT WATCHING THE ROAD . FOR BACKROUND, I WAS A HIGHWAY PATROL OFFIGER FOR 30 YEARS . I AM VERY ATTENTIVE TO THE ROAD AHEAD OF ME . IT SEEMS HYUNDAI KNOWS OF THIS PROBLEM , WHICH SUDDENLY DISENGAGES THE CRUISE CONTROL , CAUSING RAPID DECELERATION OF THE VEHICLE . AT HIGHWAY SPEED , THIS IS VERY DANGEROUS . IT HAS BEEN NOTED ON MANY FORUMS , AND MY DEALER KNOWS ABOUT THE PROBLEM , BUT THERE IS NO WAY TO DISCONNECT THE CAMERA FROM THE SYSTEM . THIS IS REALLY AN ACCIDENT WAITING TO HAPPEN .

NHTSA #11625702

The contact owns a 2024 Hyundai Santa Fe. The contact stated that while stopped and making a left turn with the A/C unit activated, the rear windshield exploded inadvertently. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 23,572.

NHTSA #11655514

See attached document for complaint.

NHTSA #11610047

When I first start my car for the day, I get an error message, which says transmission error get transmission checked immediately. I’m unable to put my car into gear and when I try to go forward the transmission acts as if insufficient transmission fluid and does not accelerate properly and go into gear. I went to a Hyundai dealer in October 2024!to get the car serviced. The Hyundai dealer flushed the transmission system For a while I no longer got the transmission error message on the dash. A few weeks later I had the transmission error again and the car would not go into gear. I took the car in for a second time to be serviced by Hyundai dealer They said that they reset the software. About a week later I got the transmission error message again, along with the difficulty of engage in the transmission. The workaround I had for this was to turn the car off and turn it back on again and that would get rid of the transmission error message until the next day. I plan to take my car in to a Hyundai dealer this week and report to them that I’ve been having this transmission error message almost daily for the last week. This problem makes the car feel unreliable, and it is a potential safety risk to not be able to accelerate and change gear when operating the vehicle. The car also lurches foreard slightly after parking and turning off thr ignition.

NHTSA #11630858

Our 2024 Santa Fe while traveling 70mph on the freeway suddenly lost power and went into what Hyundai warranty described as "limp mode'. This happened 2x. The 1st time was June 26, 2024 and the 2nd time was June 29th 2024. Both times the high pressure fuel pump was diagnosed by 2 different Hyundai dealership service facilities.Both times were highly potentially serious risk situations- traveling at highway speeds in traffic when suddenly losing engine power, and having to navigate off freeway/highway with no acceleration, basically rolling/drifting off.

NHTSA #11603366

My 2024 Hyundai Santa Fe (VIN: [XXX] ) was manufactured on March 14, 2024, in [XXX] . The vehicle is currently experiencing dual-clutch transmission (8DCT) juddering, shuddering, and extreme hesitation when trying to accelerate from a complete stop at traffic lights and intersections. This creates a severe lag in acceleration, leaving the vehicle dangerously exposed to oncoming traffic. This component failure directly mirrors the mechanical hazards outlined in NHTSA Safety Recall 263. Because my manufacturing date falls just outside the official recall window, this vehicle has not received a formal recall remedy, yet it actively exhibits the identical, dangerous powertrain defects, suggesting the recall's production scope may be too narrow. Furthermore, in November 2024, the vehicle suffered a catastrophic safety failure where it completely lost all propulsion power for approximately 30 seconds while moving through the middle of a live intersection. Most recently, on XXX, right after being released from an extended 38-day service stay at an authorized dealership, the electronic infotainment displayed an active warning screen stating the car should be shifted to park while the vehicle shifter was physically and securely locked in Park. Time-stamped video evidence of this active transmission/braking sensor failure has been captured and preserved. The vehicle remains an active, uncorrected threat to my physical safety on the road. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11740922

I was trying to back up a few times and not being able to see some objects behind while looking at the rear view camera on my Hyundai Santa Fe 2024.

NHTSA #11738780

When the car is off and in park and you go to turn on the car on by pressing the brake and power button button, the electrical system doesn't register and wont turn the ignition on and the brake gets stuck and you cant start the car. The same thing happens when the cars auto ignition is turned off at a red light then you press the gas to go but it doesnt show the gear is in drive and the ignition turns off and wont turn back on. The major safety concern is when this happens at a red light or in traffic and my car stalls and I am at risk of getting rear ended. I have taken the car to the dealership twice now for the same issue. The first time they claimed it was fixed but it wasnt and now it is at the dealership again for the same issue and I have not received any remedy yet. There is no warning to this issue it happens out of know where and is extremely dangerous. The issue has been going on for several months.

NHTSA #11732250

Hola, he llevado mi coche al concesionario 4 veces las 2 primeras veces me dijeron que eran recall el auto en parking siguió caminado los volví a llevar después de 20 días dijeron que unos roedores se habían comido el harness ese fue el diagnóstico que me dieron hablé con el seguro y el seguro iba a pagar pa reparación cuando les pidió foto del problema cambiaron la versión de que no que disculpa que no está comido por roedores cuando ellos me dieron un papel que decía eso me cobraron 570 diales por otro diagnóstico ya el seguro no quiso arreglar eso pude una queja con Hyundai motor y nada nadie se hace responsable e llevado el auto a 3 talleres diferentes y nadie sabe que tiene el auto y el dealer cada vez que fuy me decía una cosa diferente que puedo hacer al respecto

NHTSA #11743243

This is related to the recent issue with a '26 Palisade Calligraphy and the stop sale due to the 2nd row seat killing a [XXX] . I just went out and tried this on my ’24 Santa Fe Calligraphy with the 2nd row captains chairs and the electric button on the top of the seat. First off, if the seatbelt is secured, the button is disabled. Our rear facing car seat is a Britax click tight which uses the seatbelt to secure it. If the seatbelt is not secured, the button works. I sat in the seat (adult male), reached back and pushed button, and the seat started to compress me while sitting in it. Once I started to resist, the seat stopped, but it did not back off. I had to use more pressure than expected. I had to reach back and push the button again to get out. I did the same test again this time using my arm and I had to put moderate pressure to get the seat to stop. More pressure than I expected was required. I don’t know many details on the tragic death of the [XXX] old but I believe they were in a rear facing car seat that was not using the seat belt and instead using the latch connectors to secure it to the seat. This means the button in the Palisade was operable (assuming it’s like the Santa Fe) and I can totally see the seat back coming down onto the rear facing toddler. Whatever fix Hyundai does for the Palisade needs to be done on the Santa Fe as well as it is dangerous for small kids with how it works currently. There has to be a way to detect pressure on the seat and render the button inoperable just like when the seatbelt is secured. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11725045

The vehicle experienced a significant failure of the Body Control Module (BCM). This resulted in multiple electrical malfunctions, including don't detected the Key, Despite the low mileage (12,000 miles), the electronic systems have proven unreliable, and the vehicle is currently undergoing warranty repairs at the dealership. "The sudden failure of electrical components could lead to a crash or leave the driver stranded in an unsafe location. I am concerned about the long-term reliability and safety of this vehicle’s electronic architecture." After arriving home and shifting the vehicle into 'Park', the car began to roll backward on its own. The vehicle continued to move until it struck my garage door. This incident occurred unexpectedly after the transmission was supposedly secured in Park. It was necessary to apply the brakes to make it stop. Although the physical damage was minor (scratches), this unintended movement represents a severe safety risk that could have resulted in a serious accident or injury." I've also noticed that it makes strange shifts in the transmission when going down a steep hill.

NHTSA #11730294

My 2024 Hyundai Santa Fe (VIN: [XXX] ) is suffering from a severe, systemic vehicle-wide electrical network failure. The main digital instrument cluster screen has suffered four separate total blackouts (XXX), completely eliminating all driver visibility of the speedometer, odometer, safety malfunction telltales, and critical warning alerts while operating the vehicle at highway speeds. The vehicle has also experienced continuous battery collapses, recurring navigation freezes, and malfunctioning proximity key fobs/electronic door locks that fail to secure or unlock the vehicle.Most severely, on XXX, a defective, short-circuiting heated seat element experienced an uncontrolled thermal spike and caused physical thermal burn injuries to the right side of my body during an out-of-state trip. Photographic evidence of the physical body burns has been preserved. The authorized dealership was presented with this defect during an extended 38-day shop visit immediately following the incident but was completely unable to diagnose, or repair this severe electrical safety hazard. The vehicle remains unsafe to occupy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11740926

2024 Hyundai Santa Fe purchased new in May 2024. On three occasions since December 2025, while driving, the dashboard went completely black as if the vehicle shut off. The Hyundai startup logo then reappeared while the vehicle was still moving, and the vehicle lost acceleration. The most recent event occurred at highway speed, approximately 65-70 mph, requiring us to coast to the shoulder. No warning lights appeared before the event. A video of the most recent incident is available. Dealer inspected vehicle but could not duplicate the problem and reported no error codes.

NHTSA #11725263

Incident Description: I am reporting a recurring and dangerous safety defect involving the ADAS (Advanced Driver Assistance Systems) on my 2024 Hyundai Santa Fe Hybrid. On multiple occasions, the vehicle has exhibited uncommanded steering input. Even when the Lane Keeping Assist (LKA) system is manually disabled by the driver, the vehicle software overrides this command and re-activates the system without driver input, causing unpredictable steering behavior. System Failures & Error Codes: The vehicle intermittently displays a "Check Forward Attention Warning System" failure. Dealership diagnostics have confirmed the following historical fault codes related to module communication: •C164286, C168886, C16B902, C28B981 Related Safety Recalls: This vehicle is currently subject to Recall 265 (NHTSA 24V561000) for main floor wiring harness chafing and Recall 288 (NHTSA 25V808000) for rearview camera wiring tension. I believe the uncommanded steering and camera failures are direct results of the electrical interference or harness damage described in these active safety recalls. Safety Risk: The uncommanded steering override creates an immediate risk of a crash, especially in high-speed highway conditions where the vehicle may unexpectedly pull against the driver's intent.

NHTSA #11718119

My seat belts and rear safety camera are not functioning. I have been dealing with my local dealer who seems not to care and Hyundai Corporate for 3 months to try to resolve thissafety issue and have gotten no where

NHTSA #11734840

The contact owns a 2024 Hyundai Santa Fe. The contact stated that the camera had become inoperable. No warning lights were illuminated. The contact received notification of NHTSA Campaign Number: 25V808000 (Back Over Prevention). The dealer was recently contacted and informed that the parts were on backorder. The manufacturer was not contacted. The failure mileage was approximately 16,000.

NHTSA #11725759

The contact owns a 2024 Hyundai Santa Fe. The contact stated that the anchor in the third row detached. The vehicle rolled while in the drive position. The vehicle failed to accelerate. While reversing, the vehicle jerked. No warning lights The vehicle was taken to the local dealer on five occasions and was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 20,000. The VIN was not available.

NHTSA #11740884

The contact's girlfriend owns a 2024 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently swerved from side to side. The message “Consider Taking A Break” was displayed and the Driver Attention Warning (DAW) warning light was illuminated. Additionally, the Automatic Emergency Braking activated while driving near a vehicle or object, slamming the vehicle to a stop and causing the cruise control to deactivate. The message "Keep Hands On Steering Wheel" was displayed even though the contact's hands were on the steering wheel. The contact also stated that the front and rear driver's side doors were vertically bent from a manufacturing defect. The contact stated that his girlfriend feared for her safety while driving the vehicle. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was made aware of the failure and a case a filed. The failure mileage was approximately 10,000.

NHTSA #11740318

-I had just exited from the highway and was driving into my town. While doing so, I had both hands on the steering wheel and suddenly the car started beeping and flashing warnings/ alerts indicating that my hands were not on the steering wheel, which they were. Within seconds the car began to deaccelerate and pull me off the road to my right hand side. I initially had no control over the vehicle. Then again- without explanation it began to register hands on the steering wheel and I was able to resume control of the vehicle. I believe the lane assist feature was on at the time. It all happened very quickly. Had I still been on the highway as I was moments before, there was enough traffic that I would have been pulled into another vehicle or caused an accident if people saw me suddenly rapidly deaccelerating/braking in front of them because they would have no warning and a very tiny amount of time to react. Then, in an other instance that followed shortly thereafter, my boyfriend was driving with one of the lane assist on. While driving, the weather changed and it began snowing and freezing rain that was freezing when it hit the windshield. The lane assist began to have trouble seeing the lines on the road since the snow and ice were obscuring them somewhat. It began to beep and gently correct the car- which was not appropriate in this case (we understand that the road conditions were beyond its abilities to safely discern things accurately). My boyfriend who had two hands on the wheel trying to carefully navigate this sudden burst of weather so at not to slide. He tried turning it off, but it wasn't turning off, and couldn't troubleshoot it without taking his hands off the wheel. He instructed me to turn it off through the settings menu in the infotainment system, which seemed to disable it. Prior to these dangerous problems, I had experienced some seemingly sensor- related malfunctions with the tire pressure monitoring system. I'm out of room to write more.

NHTSA #11716466

Something is wrong with the front windshield. Since I bought this SUV the last year, I've noticed that the wipers are very noisy and the windshield gets dirty very frequently. The last week, the windshield cracked for no apparent reason. I called the dealer and their response was that it's not covered by the warranty and I have to claim it from my car insurance. They also have no explanation for the wiper problem and the stains that appear on the windshield.

NHTSA #11701026

Original letter to Hyundai below. The car is currently at a dealer again for repair of the same issue. Fuel pump replaced in Nov 2025 but issue has returned in March 2026. Videos of the issue recently occurring are available. Good morning, We had our 2024 Santa Fe Hybrid lose power while merging onto the freeway in November 2025. I was pressing the accelerator and it did not do anything, just kept rapidly decelerating. Pulled the car to the shoulder and turned it off completely and back on, and the car started up with the engine running which was unusual- typically the car starts up in silent electric mode. It would not accelerate past a few miles per hour. This has now happened on multiple occasions, disappearing for a few days only to return. It has gotten very dangerous to lose speed and acceleration into a busy freeway and almost caused an accident yesterday. We were thankfully close to a dealer (Glassman Hyundai in Southfield, MI) and were able to limp it a mile down the shoulder at low speed to drop it off. However, they are telling us they have no loaners available to provide us which seems unacceptable with a car under warranty with 18k miles on it. Is there anything you’re able to do to assist? Are there any known fixes for the issue that can be reported to the dealer? Thanks, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11730044

Auto dimming headlights. The headlights have stopped auto dimming. I feel like this is a safety issue because if you have them on you have to push the switch forward and then pull backward to change them back to dim. It is not something that happens occasionally it is every time they are on. Not only is it dangerous for me but also on coming vehicles. I have taken it to the dealer and was told they were waiting on some way to test what the problem is.

NHTSA #11720142

I was riding on a suburban street and ran over a branch I did not see due to rain and darkness. I went back and looked at the incident and the branch did not seem like it was that big but I quickly lost power and my car stalled and I could not get it restarted. I later found out that that branch took out my hybrid battery connection under the car which rendered the car useless. It is a 5000 fix. I don't know why such an important part is exposed under the undercarriage of an AWD SUV. I was traveling at 27 MPH. If I had been on a highway it would have been very dangerous to have stalled out so fast. Once it was stalled the battery drained very fast from me running my hazards so that the tow truck driver had to jump it to get it to go from neutral to park and my parking brake is electric so I couldn't activate the parking brake either. I would also like to say that the headlights on this car are severely underpowered.

NHTSA #11698379

Everytime with Acc active it activates the Driver attention camera system which never works in sunlight camera reads wrong and disable Acc while driving on freeway all the time due to sun reflection cant even wear polairized glasses Acc never works.

NHTSA #11682031

Driver Assistant cruise and steering components relating to the warning system. The system notification is turned off in the settings; however, the issue overrides the setting. Cruise control and steering assist shuts off after brief but consistant warning to keep my eyes on the road. My eyes are on the road. I can do nothing to stop it from warning. It may happen up to 20 times in a distance of 9-20 miles. This has occured since purchase and occurs everytime the car is driven. While passing on interstate highways the system may shut off. Acceleration stops, steering assist shuts off. Four dealerships have seen the vehicle and a claim was issued by Hyundai America. A Service manager finally, after many request, rode with me after a year of many service appointment resulting in a change of passenger facing camera. No change occurred in the system, it continues to behavior the same a prior to the camera change.

NHTSA #11681828

Vehicle Information: 2024 Hyundai Santa Fe Hybird SEL VIN: [XXX] Purchased date: [XXX] (Less than one year) Mileage at incident: 12,753 Incident date: [XXX] Dealer: Kengarff Downtown Hyundai Summary of Problem: I am filing this complaint because of a serious safety concern caused by clear dealership negligence and potential engine failure. During a routine service, the dealership failed to add engine oil, but recorded in the service invoice that it was added. I unknowingly drove the vehicle 3–5 miles without oil, and multiple DTC error codes (P052400, P001100, P001400) appeared. The oil warning light, which should have alerted me, did not activate. Although a later borescope inspection stated there was “no immediate damage,” since then, the vehicle has shown: Significant loss of power and acceleration Abnormally high RPMs, even when the car is stopped Louder engine noises RPM is increasing suddenly while driving downhill without acceleration This vehicle is less than one year old and costs over $40,000. I should not be forced to drive a new car that may have hidden or delayed engine damage. Safety Concern: I have a [XXX], and I cannot risk sudden engine failure, stalling, or fire while driving. This is not only a reliability issue, but a serious safety hazard for my family and others on the road. Attempts to Resolve: Reported to Hyundai corporate, case opened. The dealership admitted the mistake but denied responsibility after the inspection. Hyundai corporate stated “no action until further inspection,” despite clear evidence of negligence. I continue to experience performance and safety issues. Requested Action: I urge NHTSA to investigate this incident and hold Hyundai accountable for both the dealership’s negligence and the potential safety defects (oil light failure, possible hidden engine damage). Consumers should not be left to drive unsafe vehicles, especially when children’s safety is at stake. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11686430

when accelerating at high speeds, over 70 mph, the car will sometimes appear to slip into neutral, and we are not able to accelerate at all. And then will need to coast to a stop, pull over, shut the car and restart. this has happened five times in the past year and always after one hour or more of driving at high speeds

NHTSA #11677170

I was driving on the freeway at 70MPH it was dusk. The traffic was light and I was exiting the freeway. Two lanes exit and then split each direction. There is a car next to me but is not coming into my lane and nobody in front of me. Suddenly a collision alarm starts going off the vehicle brakes and the emergency steering notification lights up on the dash and the vehicle swerves to the left almost hitting the median. After this occurred the transmission started having issues at speeds under 15mph with shifting. It would rev up to about 3500rpms then lunge.

NHTSA #11673090

The contact owns a 2024 Hyundai Santa Fe. The contact stated that while driving at 5 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. In addition, the contact stated that the Auto START/STOP feature was activated, and the vehicle stopped. The contact stated that the failure occurred while parking the vehicle in the driveway. The Auto START/STOP feature was activated before the vehicle crashed into the garage door. The contact stated that the failure had occurred twice. The contact stated that the second failure occurred while driving approximately 35 MPH, and the brake pedal was depressed; however, the vehicle failed to stop. The contact stated that the brake pedal was depressed to the floorboard and the vehicle stopped. The vehicle was taken to the dealer; however, the failure was not duplicated. The manufacturer was not made aware of the failure. The failure mileage was approximately 9,500.

NHTSA #11700417

this truck has repeatedly gone in for service over 6 times for multiple issues. The worst issue which they cannot fix is the vehicle going into limp mode while driving . Loosing all acceleration then racing on its own . This is a very dangerous problem when on the highway.hyundai service keeps telling me that the diagnostic is not showing a problem. This can be caused due to many things including transmission electrical or computer problems. I have reported to the office of consumer affairs and they claim hyundai dealership in myrtle beach has not responded to them. meanwhile i am driving in a very scary situation not knowing when this will occur. This happens at random times with no warning. This has happened at least 10 times in the last few months.

NHTSA #11664524

The contact owns a 2024 Hyundai Santa Fe. The contact stated that while pulling into an automatic car wash and depressing the brake pedal, the brake pedal travelled down to the floorboard, and the vehicle failed to respond. The vehicle then drove into the car wash while the car wash conveyor system was not engaged. The contact stated that the failure recurred while driving 2-3 MPH in a parking lot, and the vehicle rear-ended another occupied vehicle. There was no damage or injury sustained. Additionally, the contact stated that while driving 5 MPH and pulling out of a parking lot, the brake pedal was depressed, but travelled down to the floorboard, and the vehicle failed to respond. The contact pumped the brake pedal, but the vehicle failed to respond and rear-ended another occupied vehicle. The contact sustained cuts on the left leg from hitting the leg against the dashboard while pumping the brake pedal. The contact's vehicle sustained scratches on the front end, and the other vehicle sustained damage on the bumper plastic cover. A police report was filed. Both vehicles could be driven away from the scene. The air bags did not deploy. There was no warning light illuminated. The vehicle was taken to the dealer for diagnostic testing on several occasions; however, the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11684980

I purchased a brand new 2024 santa fe xrt back in March of 2024. And around December my front end started shaking and I had bad vibrations in my front in when I was finally able to get it into the hyundai dealership in January they told me it was my front 2 rotors where warped my vehicle only has 13k miles and shouldn't have rotor issuses. Even though it was covered under warranty all the dealership did was resurface the rotors and said the vibration is gone. They also said if it does it again just to bring it back but a new vehicle shouldn't have warped rotor issues with less than 15k miles.

NHTSA #11639512

The contact owns a 2024 Hyundai Santa Fe. The contact stated that while the vehicle was idling at the dealer, the transmission became inoperable. There was an unknown warning light illuminated. Additionally, the contact stated that there was a hole in the front driver's seat. The vehicle was taken to the local dealer, but the dealer declined to service the vehicle or honor the service plan. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 2,600.

NHTSA #11654399

On December4th 2024 my car rolled forward into a barrier post. I stopped to get air in my tires and the Parking Allert went off as I got near the barrier post. I then parked my car. I left my car running and driver door partially opened. I dropped the valve cap between the spokes of the last tire being filled. So, I got into the car and backed up about three feet to get the cap. Parked the car got out and it rolled forward into the barrier post. I was completely out of the car but just by my driver door. I tried to get back in but it was too quick. Subsequently, I drove to work to let my supervisor know i would need time to go to the dealership. I was concerned air bags would deploy since that didnt happen. Also because the car didnt stop on its own felt the integrity of systems were questionable. So, I repeated the steps at work like the incident. Except, I stayed in the car. The car beeped and the dash said Shift to P when my door was open and placing in drive and reverse. I NEVER got any indications of such when the car hit the barrier. I found the two DTC's that showed on my Hyundai App were related to DTC U110387 and U110382. I had 99 miles on the car having purchased it with 15 miles on it. The original date of these DTCs is Aug 27th, 2024, with a last reported Aug 30, 2024. I see recalls 24V529000 and 24V246000. I don't know if they are related. but this has to be addressed. My car is at the dealership being repaired and my insurance rate will no doubt go up and the value of my car down. This isnt right.

NHTSA #11630741

We purchased our '24 Santa Fe hybrid on 9/18/24 new with no problems. On 10/8/24, about three weeks later, I was stopped at a stoplight after exiting the freeway. When the light turned green, I accelerated and felt a clunk, then the car would not accelerate past about 30 mph. Several warning lights came up on the dash. I could hear the engine revving, but it felt like it wouldn't go into the next gear. I thought I could make it to the dealership, which was only a few miles away. But at the next stoplight, I was stopped in a turn lane, and when I pushed on the gas nothing happened. I tried shifting back and forth from park and restarting the car, but nothing helped. The car would not accelerate at all. CHP shut down the intersection and helped me push the car to the side of the road, where I waited for a tow truck. The car was towed to Folsom Lake Hyundai, where it was purchased. Warning lights said "Check hybrid system," "Transmission control system" and "Driver assistance system." The app listed these codes under POWERTRAIN issues: DTC P198500, DTC P178400. We picked up the car from the service center on 10/11/24. They said a wire came loose from the oil pump, so they reattached it according to factory direction and it's fixed. 5 days later, on 10/16/24, the car stalled again. This time on the freeway. I entered the freeway and accelerated, then felt a similar clunk and got the same warning lights. This time, the car would not accelerate at all. I stopped on the side of the freeway and was towed to Folsom Lake Hyundai again. It took almost 2 weeks to repair, but they said the same thing happened again. The same wire came loose, causing the car to stall. Their solution was to reattach it again and wish me luck. They said maybe I drove on a bumpy road, but there's nothing else they can do but reattach it and get it out the door. I do not feel like this is an adequate repair and we are now worried that the car will stall again in the coming days.

NHTSA #11623316

car try to stop in highway, automatically acceleration doesn’t work and speed drop Down even try to push gas paddle it doesn’t run goes very slow speed goes down 30 m/h feel very danger and very scary!

NHTSA #11619027

Hi vibration after 55mph, tire balancing and wheel alignment doesn't help

NHTSA #11734398

Brand new vehicle purchased through Clement Hyundai. Within a couple hundred miles, multiple times vehicle goes into neutral on its own while driving. Have to stop the vehicle and turn off engine to try to get it into drive to get off the road. Takes several attempts to get into drive. Major safety hazard! Repaired once by Jefferson City Hyundai. Same problem happening again. Car not drivable as it is a safety concern. Have found multiple online forums wherein people are having the exact same problem.

NHTSA #11614785

We had notice that my wife's 2024 Santa Fe Hybrid Calligraphy AWD, is shuddering and vibrating at low speeds 20 to 40 mph always. Probably now is a little more accentuated. There is nothing on the steering wheel, but in the whole vehicle. Because this is not new, and I am not always driving this vehicle, I need your assistance as soon as possible.

NHTSA #11688658

The media screen console part of my 2024 Santa Fe has been glitching since July. Dealer has already looked at it and said there’s nothing to fix… now the screen flickers AND the audio glitches over and over the same few seconds.. then turn the car OFF and the audio stays playing over and over. Cannot turn off the media console or adjust volume. Screen goes out when using backup camera. I mostly have videos of these issues as you can’t tell in photos what’s wrong.

NHTSA #11617279

The contact owns a 2024 Hyundai Santa Fe. The contact stated while operating the vehicle, there was water leaking into the cabin of the vehicle from underneath the instrument panel onto the accelerator pedal. Additionally, while operating the vehicle, the engine and outside the vehicle were extremely hot, and the temperature gauge had malfunctioned. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The manufacturer was not contacted. The failure mileage was 100.

NHTSA #11605722

The infotainment screen on my 2024 santa fe hybrid started flickering around 3k miles and right now at around 4.5k miles, 95% of the times it stays dark and unresponsive, 5% of the time it comes on but constantly flickers and only works the other 5%. We have no way to monitor reverse camera and for a car with lots of blind spots, this has become a safety hazard. I tried the small reset button next to the right knob on the center console but no results. There's an open Reddit thread on other owners expressing the same concern. This is nothing short of a major safety malfunction that could lead to potential damage to property and/or loss of life

NHTSA #11610759

While I was driving, my new 2024 Hyundai Santa Fe suddenly experienced issues with the digital dashboard panel and a loss of speed. The dashboard went haywire, and my speed dropped from 60 mph to approximately 25 mph on the highway. The vehicle also struggled to accelerate from a standstill. After shutting off the vehicle and waiting a few minutes, the dashboard appeared to reset, and everything returned to normal. I immediately returned the vehicle to the dealer, but they could not find any issues as no codes were displayed. The abrupt decrease in speed while driving is a significant concern, as it could have resulted in a rear-end collision on the highway.

NHTSA #11598423

Forward attention warning camera continues to malfunction stating camera is obscured even when not. If cruise is allowed to be engaged the camera will randomly decide it doesn’t detect your face and will hard brake to stop the car. This has happened multiple times to me, narrowly avoiding collision from behind. Hyundai refuses to address the issue because their technicians can’t duplicate the issue so they state the car is safe to drive. Camera becomes hot to the touch much like an overheating cell phone. At times camera can be covered completely and will not detect it’s obscured. This camera is a big safety hazard rather than providing any safety. Someone will die if this is not addressed-the manufacturer doesn’t seem to care to fix the issue. I’ve reported this to the dealership from the 1st week I’ve owned the car. My car has been at the dealership for this issue almost half of the time I’ve owned it. I have seen many others with the same issue in Hyundai forums-their issues have always been dismissed as not a safety issue by Hyundai as well. How can a car that will brake from a high speed or any speed for that matter be safe-just because it “thinks” you aren’t looking forward but are looking forward.

NHTSA #11611729

Involved in a car accident 4/24 going 60 mph, driver cut over and made contact near driver side door, causing us to also slam into a concrete wall on passenger door. After 3 months and up to 29k in damages, insurance declared our car a total loss on 7/23/24. On 7/25/24 the recall was released. No airbags deployed but I had 2 airbag safety codes on my phone (after accident) I didn’t have the car for. 4/11 and on. POA was signed on 7/24/24 releasing car to at fault party’s insurance. Hyundai said they can’t do any investigation on the car to determine if it was a fault. Collision site and dealership was surprised airbags did not deploy. The final damage reported was the inner most pillar that was “last line of defense, cannot be repaired must be replaced” per collision site, had a crack all the way down. I was 30 weeks pregnant and now dealing with ongoing back issues and my toddler was in her car seat. Going that speed with that much damage and hit on both sides should have deployed airbags. Also interesting timing our car was totaled 2 days before official recall. All seatbelts in car “deployed” but side airbags did not. No airbags did

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11606225