Ford F 450 2020: Retiros, Quejas y Ley de Limón de California

The contact owns a 2020 Ford F-450. The contact received notification of NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA #11722455

The contact owns a 2020 Ford F-450. The contact stated that after starting the vehicle, the engine ran for several minutes before the vehicle independently shut off. No warning lights were illuminated. The contact attempted to restart the vehicle however, the vehicle failed to start. The vehicle was towed to the residence. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact referenced NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL) as probable cause for the failure. The manufacturer was not notified of the failure. The approximate failure mileage was 184,000.

NHTSA #11645130

The contact owns a 2020 Ford F-450. The contact stated that while driving 60 MPH, there was an abnormal knocking sound coming from the vehicle, with the "Reduced Engine Power" message displayed on the instrument panel. The contact pulled over to the shoulder of the highway, and the vehicle shut off. The contact stated that the vehicle failed to restart after several attempts. Due to the failure, the vehicle was towed to a dealer where a diagnostic test was performed, and it was determined that the high-pressure fuel pump had failed. The contact was informed that the entire fuel system needed to be replaced. The contact then received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and informed the contact that the remedy for the recall was a software update. The contact was informed that due to the fuel pump failure, the vehicle was no longer qualified for the recall repair. The dealer referred the contact to the manufacturer who offered to cover 50% of the cost for the repair. The contact stated that the recall repair was not a permanent repair and that the recall remedy failed to adequately address the failure. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 40,000. VIN tool confirms parts not available.

NHTSA #11642508

The vehicle is experiencing very erratic shifts between gears. The transmission is slingshot shifting in all gears between 3rd through 6th. If this continues it will undoubtedly blow the transmission out. I work with this truck every day and if it blows it will very likely cause a very big safety hazard as I would very possibly have a load on my trailer and this could force me out of my lane. There is a ford customer satisfaction program number of 21B03 that directly applies to this issue but as of yet they are not approving the fix for it. There is also another safety recall on this truck number 22S22. That also covers this issue we are experiencing.

NHTSA #11609517

See attached document for complaint

NHTSA #11576238

The contact owns a 2020 Ford F-450. The contact stated that while driving at 65 MPH, the transmission experienced rough shifting. The vehicle then inadvertently decelerated and failed to exceed 50 MPH. The contact pulled over to the side of the road and restarted the vehicle. The contact then drove to the residence. The vehicle was later towed to the dealer, where it was diagnosed that there were metal shavings in the transmission and that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that the VIN was not included in Customer Satisfaction Program: 21B03 (Number One Planetary and Ring Gear Assembly). The failure mileage was approximately 97,000. The VIN was unavailable.

NHTSA #11550475

The contact owned a 2020 Ford F-450. The contact stated that while driving at 60 MPH, the steering wheel failed to steer in the intended direction. No warning lights were illuminated. The contact stated that the vehicle had driven independently sideways and then into a deep ditch before coming to a stop. In addition, the contact stated that the vehicle was uncontrollable. The vehicle was towed to a local tow yard. The vehicle was condemned as a total loss by the insurance company. The contact was unconscious and transferred to the local hospital. The contact sustained six broken ribs, a punctured left lung and a hematoma in the left leg. In addition, the contact had to have emergency surgery to remove the hematoma. The contact was receiving continued medical treatment due to the injuries. The contact stated a Police report was filed. The contact later received a recall notification: NHTSA Campaign Number: 25V626000 (Steering) however the parts were not available. The manufacturer was not made aware of the failure. The failure mileage was approximately 82,000.

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA). NHTSA #11693264

Vehicle caught fire. Fire in the engine compartment after heavy fuel smell/odor.

NHTSA #11681172

The contact owns a 2020 Ford F-450. The contact stated while driving 70 MPH, the vehicle vibrated and the vehicle briefly lost motive power. The vehicle returned to normal functionality once the accelerator pedal was depressed. The vehicle was taken to the dealer, who diagnosed a failure with the power train control module (PCM). The vehicle was repaired, but the failure reoccurred. The vehicle was taken to another dealer, who diagnosed that cylinder #4 had failed, and there was a misfire in cylinders #3 and #5. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure but informed the contact that the VIN was not under recall for the failure. A case was opened with the manufacturer. The failure mileage was approximately 87,000.

NHTSA #11638026

My horn started going off continuously, I got messages on my digital dash system, saying that my lane assist had a fault, my adaptive speed control was faulty, and other system. Safety features were inactive. Ford has an issue, and they acknowledge the issue of the fuse box under the hood randomly coming off, which allows water to get into the fuse system, and start corroding wires which start sending mixed signals and failures to the system.

NHTSA #11562735

My tailgate came open randomly while pulling a trailer. Ford knows about this issue, but is yet to make a recall and not sure they’re going to cover the damage done to my tailgate. The tailgate randomly came open when I had turned a corner, and when I straightened back out made my truck and trailer jumped all over the road because the tailgate contacted the trailer.

NHTSA #11562737

RECALL ON MY F450 with no remedy, Ford will not give me an equivalent replacement - this is putting lives in danger. All of the dash engine lights will come on, no ABS, no traction control, no brakes whatsoever, power loss, will not go over 2k RPM. Then truck will not go into park when it does stop. It is an extreme danger to myself and others to not be able to drive or brake my truck. Ford is “too busy” to even diagnose the problem even though it is clearly because of the recall. This needs to be remedied before someone gets hurt.

NHTSA #11473337

Sudden acceleration while braking. While towing a gooseneck trailer aprox. 25,000 lbs, with the truck in tow/haul mode and the exhaust/engine brake turned on, started down a long winding 8% grade, could feel the engine brake working as normal, holding the truck from gaining speed, as the truck entered the second turn, the truck lunged forward gaining a lot of speed causing me to quickly stab the brakes, the truck continued this type of on/off cycle with quickly acclerating while standing on the brakes to try and control it until I leaned over and swithched the engine brake off, making it necassary to ride the brakes down the grade to maintain a safe speed and not lose control. By the time we reached the bottom, smoke was coming from both the truck and trailer brakes and the stopping power was nearly gone. The truck has done this intermittently without warning and is a major concern for safety. A search on truck forums show a number of people with the same concern. Dealer has been able to reproduce the problem, but does not have a solution. I beleive its a defect in the new 10 speed transmission and tied to the ongoing vibration / shake / hop / bounce we are experiancing.

NHTSA #11471521

Front tires on F450 Super Duty are all chopped up, and needing replacement after only 20,000 miles.

NHTSA #11461644

Vibration at highway speeds aprox. 15,000 miles that continues to worsen to a slight vibration at idle and vibration/bounce/hop at aprox. 30,000 miles, to a violent shake at aprox. 45,000 miles, making it very hard to maintain the control needed to stay in your lane and extremely hard to come to a stop in an emergency braking sitiation. When towing or hauling the defect seems to worsen. The vehicle has been to two dealerships that has kept the vehicle over 90 days, replacing or repairing a large list of components, they are always able to reproduce and confirm the defect, but have not been able to repair it.

NHTSA #11471498

225/70R 19.5 Cont Hybrid HD3. Truck is a 2021 F450 dually pickup. Mileage on the OEM tires is about 20,000 miles. The tire "blew out" while pulling a horse trailer with 7 horses on board. I personally checked tire pressure before departure. Our driver was able to get to safety without harm. Had the blow out occurred on a front tire, the results could have been catastrophic. Road side assistance told us he has had 3 other tires, same truck, same tire, same age, blow out in the last 7 days. I know from your site and consumer reports, Continental has a huge recall campaign for blow outs. ALSO there is "0" inventory of this tire for us to replace our bad tire, due to high failure rates. I have called Continental about this. They deny any problem nor responsibility. 0 contrition Contact there is manager "Rod" at 618-242-7398.

NHTSA #11433785

On two separate occasions, while towing a 5th wheel trailer, the tailgate opened by itself, coming in contact with the 5th wheel while turning. There was no warning or indication that the tailgate had opened. The tailgate was not opened by a person or by a bumping the keyfob -- it opened completely on its own.

NHTSA #11429194

Unknown. So, on May 30th, 2021 my passenger side main battery blew up for no reason. I took it to Autozone and we checked the system and everything seem fine and had the correct voltage. On July 3, 2021 my truck started smoking. I pulled over, put the truck in park and shut off the truck. I looked around trying to locate the cause of the smoke but couldn’t. I opened all the doors to air out the truck. Everything seemed to be fine at the time so I got back in and started driving. I got about 200 yards and then smoke started to come heavily out of the vents on the left and right side of the stereo. I pulled over again in a safe area away from cars and building, put the the truck in park and shut off the truck. I looked in the vents where the smoke was coming from and noticed flames. I grabbed my keys, ran to my trailer, grabbed a 7 gallon jug of water, ran back, called 911 and proceeded to try and put the fire out. While talking to 911 they asked where I was and address. I didn’t know but they kept insisting. I stopped located a number on a building and told them. Turned around after 30 seconds or so and the entire dash was engulfed in flames. I grabbed my computer, Xbox, and dogs. One dog got scared and ran into the trailer it took me about a min to get her out. I looked back at the truck and the whole truck at that time was engulfed in flames

NHTSA #11424280

Kept smelling faint diesel fuel odor would come and go while driving for 11,000 miles, never saw a leak, then became worse and saw drops on driveway size of a dime. Found a steady drip of fuel only while running from fuel filter under hood above valve cover, replaced filter and leak stopped. Closer look found heavy stains from fuel leak on top of engine. Has been that way since new. Leak now fixed. This could be a fire hazard. Glad I found it.

NHTSA #11419124