2024 Volvo Xc90: Recalls, Complaints & California Lemon Law

The trunk fails to open via kick correctly and then has closed in the midst of using the trunk space. It has not performed the “kick to close” function since purchasing the vehicle. We have two young children and this has brought a scare a few times. We love our Volvos but this has been our only concern.

NHTSA #11711963

Installation of GeoTab Telematics devices on entire fleet of 2024 Volvos (regardless of model) resulted in sporadic, unplanned and random acceleration, engine revving, transmission shifting, switching from electric (hybrid mode) to gas mode. Vehicle lurches and surges.

NHTSA #11584375

The contact leased a 2024 Volvo XC90. The contact stated while driving at various speeds, the infotainment screen and instrument cluster went black with the message "Critical Error - Pull Over When Safe". The contact stated that the failure had occurred several times at various speeds. The contact pulled over and turned off the vehicle. The vehicle failed to restart and was towed to a local dealer. The contact stated that the failure occurred often, and the warning light was ignored while driving to the dealer. The contact stated that occasionally, the system was independently rebooted when the vehicle stopped. The dealer diagnosed the vehicle several times and replaced several batteries; however, the failure reoccurred. The manufacturer was informed of the failure and dispatched technicians to consult with the technicians at the dealer; however, the failure persisted. The failure mileage was approximately 32,000.

NHTSA #11722469

Driving on highway. Selected another route on map, but the screen lagged in response. Screen then went dark, shut off electronics on dashboard and infotainment, and AC turned off; seems like car also slowed down. Able to pull over and wait for everything to restart. Safety put at risk: sudden change in environment causing attention to shift to safely getting off road incase car shut off entirely. Previously: Infotainment has been off at start-up before; never had this problem while driving, though. One incident in drive-thru where I pressed infotainment and whole car shut off. Vehicle has been taken to dealership services for annual and as needed, codes have been ran extensively, and no faults have been found. The concerning incident occurred an hour ago so I have not brought to dealership yet, but seeing online that the problem is not just with my vehicle.

NHTSA #11736039

A software update (version 5.0.5) was complete on my 2024 Volvo XC90 at the end of March. The software was marketed in emails to have an enhanced infotainment display to support a safer experience. Since the upgrade, I have experienced the opposite of enhanced safety. My infotainment screen and dash displays randomly go black and it restarts itself several times a day while driving. In addition to that, the blinkers malfunction when this happens. The most important safety issue is navigation outage on the displays. The inability to rely on the Google maps navigation within Volvo, or within CarPlay, results in my having to use my phone to input and view directions, taking my eyes off the road. It also disables to cameras when I need them. On 3/31 I emailed my sales rep asking if he'd heard of others having this complaint, he did not appear to be aware and asked me to make an appt with service center. I brought the car to Volvo on 4/2 where the service check-in employees did mention they were seeing many cars coming in with the same concerns. The technician was not able to confirm the issue but said they would contact Corporate and let me know of a response, which was 15 days ago. According to online searches, multiple other Volvo drivers are experiencing the same. Since we have become so dependent on the driver assistance features, and this issue is now occurring, I have become a nervous driver in a brand of car that is marketed as one of the safest vehicles in the world. I get worried that my BLISS or lane assistance or other driver assisted features will malfunction as well. No notifications from Volvo have been received thus far. I have not contacted the Corporate offices of Volvo yet. Please take this safety issue seriously.

NHTSA #11731827

URGENT SAFETY CONCERN: Intermittent Total Loss of All Vehicle Audio Alerts This issue has occurred multiple times and poses a serious safety concern. While driving, the vehicle intermittently experiences a complete loss of all audio output. This includes: •Turn signal indicators •Hazard warning sounds •Blind spot monitoring alerts •Park distance control tones •Navigation guidance •Audio system playback (music, radio, etc.) •All other safety-related audio warnings and notifications The vehicle becomes completely silent, eliminating essential auditory cues that are critical for safe operation. Temporary Workaround (While Driving): The only way to restore functionality is by performing a forced reboot of the infotainment system. This requires the driver to press and hold the home button until the system power cycles—a distracting and unsafe action that must be done while the vehicle is in motion. Please note that while rebooting does not disable the vehicle’s ability to drive, it temporarily resets multiple core systems, including the climate control and infotainment interface. This creates a significant distraction and impairs the driver’s ability to safely monitor vehicle status and surroundings. This malfunction poses a significant safety risk and must be investigated immediately.

NHTSA #11671009

The contact owns a 2024 Volvo XC90. The contact stated that while the vehicle was parked, the rear-view camera became inoperable. The contact stated the rearview image was blank. The contact received notification of NHTSA Campaign Number: 25V282000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that several local dealers were contacted and confirmed that the contact would be added to a waitlist to have the recall repair performed. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 5,500. Parts distribution disconnect.

NHTSA #11675656

While in Reverse and in progress of backing out of a parking space, the live video feed of the rear-view camera froze. I did not realize the screen on the dashboard had frozen until I had already backed up several feet. Once I realized the video feed was a frozen, I stepped on the brake. This frozen video feed caused me to briefly back out of my parking spot blind and unaware if the area behind the car was safe. This was the second occurrence of this happening, after already having received a software update several weeks ago at the local Volvo dealership for a different recall notice to address the rear-view camera screen displaying "Camera Not Available" when in Reverse.

NHTSA #11669265

The contact owns a 2024 Volvo XC90. The contact stated that while reversing, the audible back over warning alarm did not active as designed. The contact stated that the failure was intermittent. The vehicle was taken to the local dealer who was unable to duplicate the failure. The contact stated that technicians from the dealer were sent to the home and witnessed the failure but stated that the vehicle had operated as designed. The manufacturer was notified of the failure, but no assistance was offered. The VIN was not available. The failure mileage was 1,000.

NHTSA #11549846

The park button does not always engage the park setting. Instead it takes 2-3 presses for park to engage. It happens several times a week when I am driving the vehicle multiple times per day. I come to a complete stop, press the park button, wait for my dash to show I’m in park, if it doesn’t, I press it until it does. This has resulted in the vehicle rolling forward several times while passengers were trying to exit the vehicle, because I had not first checked to be sure the park button worked. Huge safety concern. I have owned this vehicle since August 2023 and it has happened at about this frequency since I’ve owned the vehicle. For the first time, my vehicle actually trolled enough to hit an appliance in my garage. I have a maybe related issue with the infotainment system freezing since I’ve owned the vehicle as well. The screen will freeze and we have to reset it by holding down the clean screen button for like 20 seconds.

NHTSA #11674114

After pushing "P" button to shift into park, the car moves slightly several seconds after the button is pushed. This can be a hazard if someone opens to door and the car then moves.

NHTSA #11672740

Park fails to engage when pressing the P button adjacent to the shifter. It will, however, engage 100% of the time when applying additional pressure. The button doesn’t actually travel any further when applying the additional pressure, but park will engage. It’s even possible to push the button down fully, hold it for several seconds, and then apply additional pressure to cause it to engage. The tactile response of the button occurs too soon before activation.

NHTSA #11564688

On February 17, 2026 I was driving from Sacramento, CA to Oakland, CA (approximately 100 miles). At the start of the trip, I discovered that the vehicle’s heating and climate control system was not functioning. Specifically, the heater would not turn on, and as a result, the windshield defrost system would not activate. I attempted multiple times to turn the vehicle off and restart it to see if the system would reset, but the problem persisted. I also tried manually activating the front defrost using the dashboard controls; however, the defrost function would not engage. Weather conditions were approximately 40°F with heavy rain. Because the defrost system was inoperable, the windshield and windows became fogged over during the drive. This significantly impaired my visibility. I was unable to adequately clear the windshield, creating a dangerous driving condition for the duration of the trip. This malfunction directly impacted my ability to safely operate the vehicle in cold and rainy conditions. The inability to use the defrost system created a serious safety hazard due to reduced visibility.

NHTSA #11719209

At certain times during the day and evening the rear windows are hazy and sometimes hard to see out of.

NHTSA #11736825

Several times a month the infotainment system on my car completely freezes. When this happens, my blinkers do not work, my CarPlay does not work, I cannot use voice commands, I cannot play the radio or answer calls, the backup and parking sensors do not make an audible sound. The only way to fix this is to hold down the home button to restart the entire system which does take a few minutes so not ideal to do while driving. Turning the car off and back on does not even fix it. This is an extreme safety issue, as when this happens I am driving without the use of blinkers until my system finishes restarting. Not only am I unable to use blinkers, but I am unable to make calls over Bluetooth or CarPlay which is incredibly dangerous in the event of an emergency. I am unable to park or backup and be able to hear the beep of the sensors. I cannot hear the audio of my gps. It happens out of the blue and is so unsafe.

NHTSA #11677665

Air conditioning is not working within one month of purchase. In 110 degree heat in Arizona , this is a safety issue. This has also occured on another new volvo xc90 in Austin , Texas. At least two failures on brand new volvo xc90.

NHTSA #11610344

Pressing P button does not engage the parking brake 100% of the time. Multiple times I have pressed the P button when concluding a drive and pulling into a spot with the normal friction brakes engaged, and nevertheless the car keeps rolling once the brake pedal is released, until the P button is pressed again in a much more deliberate fashion. This is a big safety issue. Pressing the P button with normal force should cause the parking brake to engage. At this point I now bypass the P button and switch the car off, which I know works 100% of the time to auto-engage the parking brake. Volvo needs to address the failure of the P button to perform its function.

NHTSA #11590899

While parking my vehicle in the garage, I pressed the P (park) button on my center console and proceeded to exit my vehicle. As I was exiting, the car began to roll backwards. I was knocked to the ground by the open driver’s door, unable to reenter the vehicle. The vehicle began rolling causing me injury to my legs, elbow and feet because I was essentially trapped under the side of the vehicle as it was moving. The vehicle continued to roll. Hitting items on my garage, including my second vehicle parked in the driveway, before coming to a stop by hitting a neighboring chain link fence. The vehicle sustained damage to driver’s door, rear end, and front left panel. I’ve looked online and have seen several forums of similar issues with the Volvo P button not engaging, and vehicles rolling/lurching unexpectedly.

Allegedly reported: 1 injury (as reported to NHTSA). NHTSA #11553522

The Infotainment Head Unit (IHU) on my 2024 Volvo XC90 has experienced repeated total system blackouts, spontaneous power-cycles, and critical thermal failures while operating at highway speeds (46–77 MPH). The IHU displays a "Cooling Infotainment System" critical warning and fails completely, resulting in total loss of the federally mandated rearview/backup camera (FMVSS 111 violation), GPS navigation, and all safety interfaces while in motion. The dealer confirmed the defect and attempted repair twice but only performed software resets rather than hardware replacement. The dealer documented "FIXED FAILED." Failures have continued and worsened after both repair attempts. Video documentation exists for all incidents (Exhibits A–H, dated May 2–7, 2026, odometer 41,900–42,151 miles). The vehicle's own diagnostic system issued a Critical Thermal Warning on the driver cluster while navigating traffic, confirming a hardware cooling defect. Two failures occurred during active driving maneuvers including a reverse maneuver and highway operation on I-20, creating immediate safety risk to the driver and public. The component is available for inspection. The defect has been confirmed by the Volvo dealer. A Texas Lemon Law complaint has been filed.

NHTSA #11736880

To Whom It May Concern, I am submitting this complaint to report a repeated and unresolved safety defect in my leased Volvo vehicle involving rear passenger door lock failure, which has resulted in minor children being trapped inside the vehicle on multiple occasions Vehicle Safety Issue: The left rear passenger door fails to open from both inside and outside, despite the child lock not being engaged. This creates a serious safety risk, particularly during emergencies when occupants must exit the vehicle quickly. Incident History: [XXX]: Rear door would not open from inside or outside, trapping my two children (ages [XXX] and [XXX] ). At the same time, the infotainment system froze and the backup camera was not functioning. I reported this to Volvo service. [XXX]: The same issue occurred again, resulting in my children being locked in the rear seat. One child was experiencing leg pain, and it was extremely difficult and unsafe to remove him through the front door. The dealer stated the rear lock assembly was replaced. [XXX]: Despite prior repair and assurances, the rear door failed again, trapping my child inside the vehicle. I have video evidence showing the door cannot be opened from outside. In addition, on a separate occasion, the vehicle completely froze and could not be unlocked using either key. AAA was required to jump-start the vehicle, and I was informed that a required software installation had not occurred. Safety Concern: A rear passenger door that cannot be opened from inside or outside presents an immediate safety hazard, especially involving children, medical emergencies, accidents, or fire. A non-functional backup camera further increases the risk of injury while reversing. This issue has occurred three times, including after a component replacement, indicating a recurring defect rather than an isolated incident. I am reporting this issue so it can be reviewed for potential safety investigation and corrective action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11709427

Safety Complaint – Volvo XC90 Electrical and Airbag Malfunction Issues I am reporting ongoing safety concerns with my Volvo XC90 related to electrical malfunctions and unexpected engine shutdowns while driving. The vehicle has suddenly turned off multiple times, including: •Once before merging onto a highway, •Once while entering a roundabout, and •Once while driving in traffic. Each incident occurred without warning and created a hazardous situation with the potential for a collision. Additionally, the vehicle displayed an airbag malfunction warning once, raising concern about the reliability of the vehicle’s safety systems. The vehicle has been serviced multiple times, but the issues persist. I am requesting a formal investigation into these failures, as they pose a significant safety risk to the driver, passengers, and others on the road.

NHTSA #11691492

Some critical functions on the center display console instrument panel are freezing up while driving - we are unable to change the drive mode while the car is in motion. This has not happened before, and it is glitching a lot lately. The display has been extremely slow and unresponsive, and the problem is multiplied as all critical functions of the car are controlled through the display panel. There were no warnings issued when we tried to change the drive mode. We had to pull over to the roadside, turn off the car for 30 seconds, then restart the car to fix the issue. We have [XXX] and [XXX] ) in the car, so this is becoming increasingly risky to drive this "safe" car by Volvo. We have reported such issues with the display to our Volvo service unit multiple times, and the car has been returned to us with such issues still lingering (despite the service reloading/updating the software multiple times) for the last 6 months since March of this year. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11687349

The safety sub system completely stop working periodically. When it occurs: - the blind spot indicators do not light up when a car is in blind spot - turn signals stop making sound. Not sure if they still function - collision system stops making sound. Sometimes stops showing near objects and walls. This has happened about 7 times since purchase of the car, and requires a full computer reboot to fix it. It’s random, so you don’t know it’s failed until driving and something doesn’t work. I don’t have pictures but I have a video of it I can share if someone wants to see some of the issues. It just happened again today, and happens maybe once every couple months

NHTSA #11675202

Instrument cluster failure and turn signal malfunction while highway driving. No interior sounds, including no lane change warning or near collision warning signals, and no audible confirmation of signal; no exterior blinker activated despite use by driver. Instrument cluster went blank. Safety at risk and accident occurred: approaching car from rear passenger side hit front right side of our car because there was no exterior signal and no audio or visual alerts in our vehicle about lane change or blind spot. Signal and instrument cluster failure: the car is at the manufacturer/dealer for the third time for similar issues with our vehicle (2 prior times they stated the issue was fixed). Manufacturer reports that they're sending a team to investigate given that this most recent episode lead to an accident.

NHTSA #11635810

The system that starts the vehicle, called a igs failed yet again. This failed at 700 miles in downtown chicago on the street blocking traffic. Now several months later today going on a trip and the vehicle dies in the middle of the street blocking traffic. Was unable to restart the vehicle again. Attempted to contact Volvo Customer Service and was on hold over 25 minutes without talking to someone. Tried to find a way to put vehicle into neutral to safely move out of the way, but this vehicle has no way to manually overrride it. It posed a safety risk and could of easily caused an accident.

NHTSA #11611871

1. When the air condition is turned on there is knocking/banging/thumping noise. It starts with a whinning noise and then gets thumping noise and then starts again with a whinning noise followed my a thumping noise. It can go over 15 to 20 mins and then stops and restarts again. Yes, it can easily be reproduced. 2. The whinning and thumping noise while the car is driving can cause a safety issue where something could explode (the way it sounds) or air condition can simply not working as we approach summer. 3. Yes, its been reproduced, I've sent them the videos, i was at the dealership to reproduce and they acknowledge there is an issue. Weaver brother volvo had created an internal case to Volvo Technical Assistance, case number: RTS-US831535. The reply was they are aware about this issue and they are investigating it. The issues seems to be on the expansion valve and they are still investigating it. This was dated August 6th, 2024. 4. No warning lamps or messages or other symptoms. June 26th, 2024. The issue was reported to dealer around July, 25th 2024.

NHTSA #11662431

We drove this vehicle to a family event in chicago. We pulled the vehicle out of the parking garage and pulled into a downtown street in front of a hotel to load the vehicle up. Once the family was loaded the vehicle up the car would not start it had 700 miles when it failed. we were stuck on a busy street trying to start the car. I called roadside assitance and someone came out with a jump pack, but the battery was not dead. I was in the pouring rain trying to figure out what was wrong. They did hook a computer up to find several faults in the computer. It did also indicate a left turn signal fault. also talking with roadside assistance the agent said that was the 2nd call he had with no start issue. finally it did start but the check engine light was on the whole trip home, had to cut our trip short and drove as far as we could in fear the car would not restart. It kept coming back with the left turn signal fault and did not shut off the car even pumping gas in fear of not restarting then all of a sudden with cruise control on the car just jerked itself amd almost pulled us off the freeway. now it has been at the dealer all week researching forums this seems to be a common issue

NHTSA #11582432

Since purchasing this vehicle in October 2023 I have had multiple issues with the fuel door not opening, the turn indicator light not working, the backup cmera and sensors continue to engage the rear brake intervention system when there's nothing behind the vehicle.

NHTSA #11603372

I am reporting a serious and ongoing safety defect involving my 2024 Volvo XC90. The vehicle has experienced intermittent unintended acceleration, intermittent loss of safety and alert systems, and false obstacle detection that triggers unexpected braking or steering input. These events occur randomly and without warning, and are not tied to a specific driver, key, driving condition, or user behavior. At times, the vehicle accelerates on its own without driver input. At other times, the vehicle detects objects that are not present, causing the car to suddenly stop while reversing or swerve to avoid perceived obstacles that are not actually in the roadway. These events occur unpredictably and create a risk of collision with surrounding vehicles, pedestrians, or objects. During these occurrences, safety systems and alerts may become unavailable or inoperable, leaving the driver without audible or visual warnings. Audio alerts and system feedback have also stopped functioning during these events, further increasing the safety risk. The vehicle has been brought in for service approximately 8–9 times for various concerns, including these safety issues. Despite repeated service visits, the problems remain unresolved. Restarting the vehicle sometimes restores functionality, but the defects continue to recur unpredictably. This vehicle is used to transport young children, and these failures present a significant risk of serious injury or death. The unpredictability of the unintended acceleration, false braking/steering, and loss of safety systems makes the vehicle unsafe to operate. I am submitting this complaint due to concern for my family’s safety and the safety of others on the road, and because the manufacturer has not resolved the defect after repeated attempts. These issues have occurred since we received the car in September 2024

NHTSA #11714266