Below are recalls and complaints reported to NHTSA for the 2020 Volvo Xc90. This information is consumer-reported and provided for general informational purposes only. Vehicles like this may qualify under California lemon law depending on their individual repair history.
The following recalls were reported to NHTSA. A recall does not by itself establish that any individual vehicle is defective.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.
Reported consequence: Separation of the rotor and shaft may cause a reduction in braking assistance and a loss of the Antilock Brake System (ABS) and Electronic Stability Control (ESC), increasing the risk of a crash.
Remedy: Dealers will replace the hydraulic unit, free of charge. Owner notification letters were mailed October 22, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10120.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Reported consequence: Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.
Remedy: Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Reported consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
Reported consequence: A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.
Remedy: Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.
Reported consequence: An improperly tightened seat belt buckle may not restrain an occupant as intended, increasing their risk of injury during a crash.
Remedy: Dealers will inspect and tighten the second-row seat belt buckle anchorage bolts, as necessary, free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10259.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2016-2020 XC90 Excellence vehicles. Liquid or condensation on the rear seat control display may cause the front passenger seat to move back as far as possible.
Reported consequence: The rear passenger may become trapped by the front seat without the ability to cancel the seat's movement, increasing the risk of injury.
Remedy: Volvo Car will notify owners, and dealers will update the rear seat control display software, free of charge. Owner notification letters were mailed July 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10093.
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
Reported consequence: If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
Remedy: Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
If your 2020 Volvo Xc90 has had repeated repairs for the same problem, you may have rights under California lemon law. Tell us about it and we will review your situation at no cost and no obligation.
This page is attorney advertising and is provided for general informational purposes only. It does not constitute legal advice and is not a substitute for advice from a licensed attorney regarding your specific situation. Viewing this page or contacting Lucky Lemon Law does not create an attorney-client relationship; such a relationship is formed only by a signed written agreement.
The recalls and complaints shown here are reported to NHTSA and are consumer-reported, unverified allegations. They do not establish that any defect exists in any individual vehicle, and nothing on this page should be read as asserting that the 2020 Volvo Xc90 is defective. Counts reflect items filed with NHTSA and may not be current. “May qualify” statements are general and do not mean any particular vehicle or owner qualifies.
Past results do not guarantee a similar outcome. Every case is different and depends on its own facts. Lucky Lemon Law is responsible for the content of this advertisement.