2020 Subaru Outback: Recalls, Complaints & California Lemon Law

Windshield cracked from a rock chip. Within 1 day, the crack had expanded to 12 inches across the windshield.

NHTSA #11627386

I have 2020 Subaru Outback and have had 14 windshield replacements/repairs. The windshield has spider cracked out of nowhere and has been unable to take the smallest impact without cracking in multiple locations. I have submitted multiple complaints to Subaru and was informed the issue is unique to my vehicle, but the car has never been inspected by Subaru, regardless of countless requests to do so. All but one windshield replacement has been submitted through my insurance, Subaru has covered one replacement. The last time I spoke with a Subaru representative I was informed it was not Subarus issue. No one was hurt during any windshield incidents but the quality and safety of the windshield is dangerous. Subaru has refused to thoroughly inspect my windshield and the safety of my vehicle.

NHTSA #11611877

We are on our 3rd broken windshield in 3 years. We do not drive the car very often or drive any extreme ways. This is more broken windshields than I have had in my whole life in just a few years having this car. There must be something wrong with the way it’s made.

NHTSA #11606327

[XXX] and I were driving to Sean’s for dinner on Friday night [XXX] when the sunroof glass exploded at approximately [XXX]. [XXX] was driving on the [XXX] . We heard a loud bang and thought we were in an accident. We noticed sounds from the sunroof so I slide the cover open slightly and saw a massive hole so immediately closed it again. We pulled off and used the emergency ramp to examine the damage and take pictures. We think the glass exploded for no reason as we did not see any debris in front of us and were not under an underpass. We did not find any debris or scratches on the car indicating an external object as the culprit. I dropped my car off with Subaru Carlsbad on June 17, 2025 and am waiting for an update. My service advisor was shocked by the occurrence as she had not seen something like this. I pointed out that the glass exploded outwards and asked her to check the cabin pressure vents as we found discussion pointing to those as a potential issue when researching online. We also heard complaints that Subaru has specifically excluded this piece of glass from the warranty so I let my advisor know that I hope / expect this to be covered under warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11667731

No warning, or dash lights. A/C stopped working. It’s 98 degrees outside, to me that is dangerous! Wagner Subaru said it is the actuator doors ($900 in diagnosing) they said it would cost $3600. It’s a 2020. There is no reason there should be a cost that high for that new of a car.

NHTSA #11676514

Vehicle accelerated without touching gas pedal, rpm’s kept increasing even while trying to brake.

NHTSA #11660871

The contact owns a 2020 Subaru Outback. The contact stated that while driving 65 MPH on the highway, the contact was alerted by the message “Eyesight Technology Failure”, before the battery shut down, causing the steering wheel to seize, forcing the contact to come to a complete stop in the middle of the highway. The check engine, air bags, and oil warning lights were illuminated. The contact stated that several other unknown warning lights and alerts were displayed on the instrument panel. The vehicle was jump-started, and the contact was escorted by a tow truck operator to the nearest dealer. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 37,168. The VIN was invalid.

NHTSA #11710788

Immediately stop every single traffic light

NHTSA #11690458

The contact's husband owns a 2020 Subaru Outback. The contact stated that the vehicle was difficult to start intermittently, but was able to be jump-started. There was no warning light illuminated. The vehicle was taken to Advance Auto, where the contact was informed that the battery and the alternator were in good condition. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 56,000.

NHTSA #11682818

My transmission has started to fail. The check engine light came on the error code read p0867, transmission fluid pressure. Other lights came on as well because it tripped the rest of the sensors because of the CVT failure. This seems to be a common problem in Subarus

NHTSA #11736752

I was reversing out of a residential driveway onto a county highway when the I had a complete loss of movement. Shortly after the total loss of power, the CEL illuminated. If I had been on the highway, the driveway is near a blind curve, I would've been sitting in the road with no way to move putting me in a dangerous situation. The transmission failed at right at the end of the driveway so I was able to put it in neutral and move the vehicle by hand. There were no symptoms or warning lights prior to the failure. I had it towed to the nearest dealership where they diagnosed a complete transmission failure and recommend a complete transmission replacement.

NHTSA #11732229

I'm writing to request assistance with my recall. This recall was first reported to the local dealership over one year ago. They have had me take the car back 4 times for inspection. Since that time as the problem has proceeded to get worse, which will now cost even more to repair, and increase the likelihood of the transmission damaging other parts of the drivetrain. Now I just received notification that they will not perform the recall as my vehicle doesn’t qualify. It has the problem of transmission slipping which is what the recall is for. I saw the pictures they took that looked exactly like the problem specified. I do not have $7000 dollars plus to fix the transmission. I can’t sell the car because the VIN will show the recall (which I’m sure they will try to just remove). All they have done is waste my time for the last year to do what? Gather enough evidence to try and get out of the recall?

NHTSA #11719700

The contact owns a 2020 Subaru Outback. The contact stated that the front passenger’s side mirror had started to detach from the vehicle without an impact to the vehicle, and the mirror had become inoperable. The vehicle was not yet diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 68,000.

NHTSA #11635838

The contact owns a 2020 Subaru Outback. The contact stated while the vehicle was parked in the garage, the contact became aware that there was a 12-inch-long crack on the windshield starting from the driver’s side of the windshield. The contact stated that there was no impact to the windshield that could have caused the windshield to crack. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 62,000.

NHTSA #11630375

The contact owns a 2020 Subaru Outback. The contact stated that while the vehicle was parked, the front windshield unexpectedly shattered. There was no impact to the windshield that could have caused the windshield to shatter. The vehicle was taken to the dealer, who suggested that the contact file a claim with the insurance company to replace the front windshield. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 90,000.

NHTSA #11600910

I am reporting a safety-related defect involving the Supplemental Restraint System (SRS) on my 2020 Subaru Outback with approximately 20,480 miles. Multiple SRS and occupant detection system warning lights illuminated. Dealer diagnostics showed multiple SRS-related faults including airbag ECU malfunction, occupant detection sensor communication failures (lost communication/mismatch), and SRS power/voltage-related faults. These systems directly control airbag deployment and passenger safety. The vehicle has not been involved in any accidents and has not been misused. The dealer advised the vehicle is not safe until repaired. Subaru of America declined assistance and closed my case, stating it is outside goodwill parameters, and is requiring me to pay approximately $1,200 to repair the airbag-related system. In November of the prior year, the vehicle had a battery failure and was serviced by a Subaru-certified dealer. During that repair, wiring work was also performed. Given the current SRS faults and the prior wiring/battery service, I am concerned this may be a systemic or related defect rather than normal wear. I am requesting NHTSA review this issue as a potential safety defect involving the SRS/occupant detection system.

NHTSA #11713606

I received letter from Subaru of America saying parts available for recall repair but when I went to the dealer they did not have the parts.

NHTSA #11668163

The contact owns a 2020 Subaru Outback. The contact received notification of NHTSA Campaign Number: 24V227000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA #11663915

I am on my third windshield in les than a year. The tiniest pebble will crack the windshield, or sudden changes to weather has now caused a stress crack. Seems to be poor weight distribution on the design. There is extensive customer complaints on line with the same issue. Insurance will only cover two a year. There were no warnings of this issue when the car was purchased. This is an expensive hazard to keep having issues with. They need to do a recall on a fix.

NHTSA #11659737

Problem component: exterior mirror on driver side It was raining, I was driving, I heard what sounded like a loud explosion by my driver side window. After the initial shock, I thought a tire had blown out, but car drove ok and no tire warning light came on. It was a rural road with no shoulder, only deep stormwater ditch along the roadside, so there was no place to safely pull over in traffic to assess what may have happened. I drove about 2-3 miles before I could pull over at a safe spot.There I saw that the back side of my driver side mirror had completely disappeared. Wires were exposed. It appeared to have exploded off for no apparent reason. The body of the car was completely fine, the white exterior paint of the car was perfect, the actual housing of the mirror showed no marks, there are no dings or cracks in windows. No sign of any debris hitting the car. I reported it to Subaru general headquarters, and gave them all the info. I have an appt with local Subaru dealer this week. The mirror and housing are still on the car, minus the back, which is gone. My husband returned to the scene a few minutes later and searched for the piece that had propelled off the mirror or for any debris that could have caused the mirror to explode. There was nothing on the road, so wherever the back of the mirror went, it must have propelled far off the road. Safety issue: because an explosion like that nearly caused me to lose control of the car. And the piece that propelled off the mirror could have hit another car. Additional info. at the time of mirror exploding: my windshield wipers were on, it was a warm day so my air-conditioning was on, good chance my front dehumidifier was on. Car is equipped with heated mirrors, but heat was off.

NHTSA #11624532

Windshield developed a crack for no apparent reason on the lower passenger side. Car was parked. Only unusual circumstance is that was a hot day.

NHTSA #11537365

Vehicle: 2020 Subaru Outback Onyx/Limited/Touring XT (2.4L Turbo FA24) Component: Engine Lubrication / Oil Pan Sealant I am reporting a manufacturing defect involving the engine oil pan seal on the 2020 Subaru Outback 2.4L Turbo. Upon inspection of fluid accumulation at the transmission joint, a Subaru dealership diagnostic confirmed that the engine oil pan seal has failed. The dealership noted that engine oil is leaking and being forced rearward by airflow while the vehicle is in motion, saturating the transmission assembly. Technician Admission: The service department at the Subaru dealership explicitly stated that this is a "known manufacturing issue" with the FA24 engine series. Financial Concession: To acknowledge the nature of this premature failure, the dealership waived the $185 diagnostic fee, resulting in a $0 invoice (attached). Inadequate Coverage: Despite the dealership’s admission and a repair quote exceeding $1,100 (file is attached), Subaru has not yet issued a recall or extended warranty for this specific 2020+ turbo application, though similar issues with RTV sealant have plagued the brand’s newer engine platforms. The technician confirmed that the leak is significant enough that oil is traveling the length of the transmission. This presents a potential fire hazard if oil contacts high-temperature exhaust components (such as the turbocharger or catalytic converter) and contributes to environmental contamination. This is the Turbo (XT) model. Turbochargers generate much higher heat, which makes an oil leak significantly Subaru National Customer Service has advised me to file this complaint with the NHTSA. I am requesting that the NHTSA investigate the frequency of oil pan seal failures on the 2020+ 2.4L Turbo (FA24) engine to determine if a mandatory recall or extended warranty (similar to past CVT or engine seal settlements) is warranted to protect consumers from the high cost of a documented manufacturing flaw.

NHTSA #11728037

The factory 2020 Subaru Outback Wagon is built with a Thermo Control Valve that is, essentially, made out of a composite plastic. As this part is part of the engine cooling system, it is placed under both heat and pressure. While it controls the anti-freeze to the heater core in the passenger compartment, it is also attached under cover to metal fittings. While the car now has about 90,000 miles, this control valve cracked and began to leak anti-freeze on top of the engine. Without cooling, the engine would likely be ruined. Thus, the car required immediate service. When a fault like this occurs, by the way, the Subaru Eyesight System shuts down taking with it various safety features. I had the defective part replaced and it's replacement is not made of composite plastic but, rather and more appropriately, metal. It is my belief that the selection of the orignal part was a design defect ignoring the potential for differential expansion of the parts when exposed to such temperatures. Failure was inevitable. It is worth noting this is not an inexpensive repair as numerous parts have to be removed to access this valve. Likewise, the service representative made note that numerous other customers have had to have the same service.

NHTSA #11549421

At one year and 7,358 an engine oil leak had to be repaired, and still seepage and monitor is recommended. Then at three years and 28,175 the coolant bypass valve failed and was repaired. Both problems were covered by warrently, but as I live 60 miles from the dealer it was a hassle. I bought the car new in March 2020. I can not recommend Sabaru to people who ask about it and it is highly unlikely I would purchase another Subaru. However it is comfortable and practical and do not plan to sell or trade it for another car at this time. Now at four months after the latest repair it appears to be doing well, and I monitor the oil level.

NHTSA #11534622

Gas cap was not secured overnight. The next day every ADAS function both safety and convenience was disabled and their lights were on. Users guide said car should recover after a few miles of driving. 100 miles and multiple restarts later it did not. It was taken to the dealer where they cleared the error for free. Poor design that a loose gas cap could cause a collision due to lack of ADAS. Dealer said it is a known condition with all Subaru models.

NHTSA #11689824

ACC eye sight is intermittent. It normally fails within 5 minutes of operations and just turning the car on.

NHTSA #11611611

After an automatic software download update, the RAB off light came on. The RAB light comes on when the car is put in Reverse and provides the option to turn that function off. After the update, the RAB icon is no longer displayed. It is the only system so far that I noticed that malfunctioned after the software update

NHTSA #11607657

No warning lamps or messages. A driver in a pickup truck behind me came up close and signaled me to pull over. He got out of his truck, ran up to my window and yelled to me "get out of your car, it is on fire". I was completely unaware of any problem. I got out and could see fire coming from under the front of the car. We moved away and he called 911.

NHTSA #11718035

Only one issue was witnessed, that being when a fuel dispenser's auto shutoff clicked, fuel would shoot out and run down the side of the vehicle.

NHTSA #11635493

I was driving to a medical appointment in Ann Arbor Mi, and was in the area where [XXX] has a few big turns in the road .... like at ... [XXX] .All of he sudden the car started to accelerate a little on the turn so I attempted to brake the vehicle and I could not feel the brake pedal. I slowly moved into the right lane and frantically trying to slow the car down. I still could not feel the brake pedal and I believe when I hit the speed control off is when it slowed down and I was able to finally brake the car. It all happened in a matter of 10-20 seconds I would guess and it was absolutely terrifying. I have on occasion used the speed control to slow down the vehicle and wonder if that might have some connection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11686503

On November 21th, 2023, we were driving on a 30 mph street at 8:00 pm with no traffic and our automatic emergency braking system deployed on our 2020 Outback, we jolted to a stop for no apparent reason. This could have been dangerous if a car was behind us. Just had our oil changed with free inspection at Miller Hill Subaru 1 week prior. First incident. Will have the dealership inspect ASAP. The "Auto Start /Stop No Activity Detected" indicator message light came on afterward.

NHTSA #11556399

While in a Dairy Queen drive-up lane, I stepped on the brake pedal and it went right to the floor. The car did not stop, causing me to hit the car in front of me. When backing away from the car in front, the brakes again failed and I hit the car in back. I moved forward again , swiping the car in front again. The cars were merely feet apart and my car was thankfully moving very slowly. Had I been traveling at a higher rate of speed there could have been serious injuries. Car was taken to an Auto repair shop where the mechanic experienced the same problem with the brake pedal. He says the pedal went to the floor and the car wouldn’t stop. Car is currently at a collision shop where they report that inspection of the brakes is normal. They also report that the brakes worked when they pulled the car into the shop. The car has not yet been moved to the Subaru dealer service department for inspection of the brake pedal. There were no symptoms, warning lights or messages before the incident and there were none found by the shop after. My car was built in the same time frame as those involved with Recall #19V664000 which involves the brake pedal mechanism although my VIN was not included. The car is available for inspection. I initially received a ticket but it was dismissed after the repair shop owner reported the same failure.

NHTSA #11666216

I had a fault/issue with the Electronic Parking Brake on my 2020 Subaru Outback that resulted in a vehicle fire. I had set the electronic parking brake, and received a warning light. I retracted the electronic parking brake and the warning light disappeared. I did this twice. The warning light stayed off. I drove the car and the passenger rear brakes caught on fire, damaging the brakes, the electronic parking brake motor, the brake caliper, the wheel bearing, the ABS sensor and all wiring to that wheel. I had the vehicle towed to the dealer. The dealer had the vehicle for over 2 months. In that time, my insurance inspected the vehicle. The dealer inspected the vehicle. The dealer had a Subaru (Subaru of America) factory tech visit and inspect. Subaru factory sent out a second tech (from quality control) to inspect the vehicle. The dealer tech and both Subaru factory techs could not determine the root cause of the failure. Subaru replaced all components damaged in the fire (at my cost) and sent me on my way without a determination of what caused the issue. Issue was well documented here... https://www.subaruoutback.org/threads/parking-brake-fault-caught-on-fire.551030/ I have attached a scan of the Subaru Dealer repair order.

NHTSA #11530400

As my husband & I were traveling to Augusta, GA on Memorial Day weekend with our niece, we approached the [XXX] outside Chattanooga, Tennessee in heavy traffic and heavy rain on Saturday [XXX] 2024 at approximately [XXX] When we stopped for a small accident ahead of us, the “auto stop-start engine” feature stopped the car engine as normal. However, almost instantly, all of the electronics in the car appeared to fail and the car would not restart. The dashboard indicated that Eyesight and RAB were disabled and to "check the owner's manual." Normal traffic quickly resumed around us, but we were stranded in the #2 lane with several close calls of a rear-end collision--not to mention the cars at risk swerving to avoid us. My husband is a retired firefighter & our niece is a nurse in Los Angeles. Frankly, we were terrified! We were stranded on the interstate in the #2 lane for about 20 minutes before being pushed into the "gore zone" between [XXX] & [XXX] by a TDOT truck. We spent about 40 minutes in the gore zone where we were nearly hit twice by cars driving across the zone. We were finally towed to Crown Subaru in Chattanooga, TN and arrived there about 11:40 a.m. The general manager of the dealership, Keith Aviles, told us there was a sudden, massive failure of a battery cell controlling the electronics of the car, and the battery was replaced. We never had any indication or evidence prior to this incident that there were issues with the battery. Also, we have never received a notice from Subaru about battery problems. However, we are now aware that Subaru settled a class action lawsuit to avoid a recall of these batteries. I have notified six friends who own Subarus. Three have had issues with their batteries, but were also unaware of the class action lawsuit. This is absolutely shocking for a vehicle manufacturer that touts safety to sell vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11590991

The automatic lifting of the rear trunk opens as it should, but then will start to close on you out of no where without pushing the close button. It is terrifying because it doesn’t sense a body there. The screen in the center console also will become inaccessible and black out making it impossible to use the touch screen. The usb ports/ connecting to iPhone will disconnect making Bluetooth unavailable. Extremely difficult when needing gps or on the freeway

NHTSA #11573273

The driver’s side (front left) power seat adjust motor has lost the inside end cap of the worm drive control assembly. Only the outside left rail will move. Subaru will not sell the part to repair, they only will supply the entire lower seat assembly for $1000. .

NHTSA #11588218

The drivers seat is loose, rocking back and forth significantly to the point it very noticeable while driving. The dealer states that this is due to the bottom seat frame being worn out. There are only 41,000 miles on the car, about 37,000 when I first noticed the information. This should not fail so early the car’s life. The dealer is replacing the bottom seat frame at a cost of $1310.

NHTSA #11608654

A small horizontal crack recently appeared on my Outback's front windshield while it was sitting in a garage overnight. The crack started from the passenger side and has now crept over to the middle of the windshield. Previous to this incident, the car had been sitting unused for over a month, so there was no opportunity for rocks or other debris from the road to cause the crack. This is the second time that the windshield has developed a crack out of thin air. I have replaced the windshield at least five times since owning the vehicle, in addition to having small chips from rocks repaired twice. These incidents are potentially dangerous and could possible interfere with the vehicle's automated systems such as collision detection and cameras.

NHTSA #11592368

A crack has spontaneously appeared at the base of my windshield after no apparent damage. The crack is spreading across my windshield and will affect my adaptive cruse control and automatic emergency breaking if it interferes with the Subaru eye-sight system at the top of my windshield. I have not taken the vehicle in for service but I did see this was an issue that lead to recalls on previous outback models but not currently a recall for the 2020 Subaru Outback. I do not have any current warning lamps or messages.

NHTSA #11518941

While we were at a speed of about 55 mph on a state highway, I had just selected cruise control when all the lights went on in the dash--including the warning lights for the brake, the check engine light--and power shut down in the vehicle as if we'd run out of gas. We were able to keep a very slow speed of about 20-25mph, but had to activate the 4-way flashers to alert other drivers that we were losing speed. We managed to get over to the shoulder and call for a tow. We feel this was a catastrophic failure of the vehicle, which endangered both of us. At least we still had power steering. At the dealer, the techs advised us that the issue was likely due to a failure of the electronic thermostat control. The car was in the shop for a week, and was repaired at no cost to us. The thermo control valve and all related parts were replaced. If not under warranty, this would have cost over $2K. We had no warning that this component was failing.

NHTSA #11539269

When we started vehicle, a wide array of systems shut down including cruise, Eye Sight, lane detection, auto high bean, adaptive light cornering - essentially anything “automated” or assisted - along with the heating. The car ran at a higher RPM at idle - 2000 vs a usual 700-800 - and rough shifted at speed. Again, as if the automatic transmission lost its sync. The water temp gauge was also off. Have since learned this was the “thermo control valve” and somewhat of a known fault on Outbacks of this year. We were lucky to reach home from the long trip we were on and to the dealership. At the dealership, the service team did not admit this was wide spread. Nor did they tell us there is an updated part from Subaru available. They intend to install the OEM part, which concerns us that in another 40-50k we will face the same $2k problem. We are unlucky that we just went over 60k miles, so this will not be covered under Subaru’s 60k drivetrain warranty. That Subaru is covering a cooling system problem under the guise of being drive train tells me they know they have something to keep quiet.

NHTSA #11509066

I was parking my car slowly until it suddenly accelerated. I hit a wall and car got totaled.

NHTSA #11725434

A fire started under the hood of my car while I was driving. There were no warning lights on in my car and the temperature gauge was in the middle where it usually is. Earlier in the day, I smelled gas, but I thought it was a different car as the smell of gas went away after a car that had a lot of exhaust coming out was no longer in sight.

NHTSA #11697021

Transmission is failing. Wheel bearing bad. This is a 5 year old car with regular maintenance. No warning lights.

NHTSA #11692235

Car stalled in traffic. The engine was cranking but it would not start. Had AAA tow off the road and to my home. Car sat for 10 days waiting for a fuel pump (thought this was the problem). After sitting for 10 days the battery was totally dead! New fuel pump installed battery was jumped but could not start the car. After 2 hours on the charger the battery still did not have enough energy to turn over the engine. Car is in a certified service shop (Wilhelm). Battery replaced and same starting issues with the new battery and the new battery is discharging at a very high rate even though the car is not starting. Bought the car used in 2023 so I have no knowledge of the history of the car. Service provider running factory diagnostic testing but so far no determination as to cause of the high rate of discharge. Verified that the fuel pump is fully operational. What we know is that with a fresh fully charged battery and a working fuel pump the car will not start and remain running. The engine stops and the battery drain is excessive.

NHTSA #11673168

Vehicle had 45,000 miles on it when right rear wheel bearing failed. It was covered under 5 year/60,000 mile warranty and was repaired today by a certified Subaru dealer and I no longer have the bad part for inspection. Safety risks would be anything that occurs from a bad wheel bearing like wobble, seizing, overheating, and more damage to other drivetrain components. You could hear the wheel bearing noise at 20 mph constant while driving, only getting louder with increased speed. No warning lights were present on the dash. I feel like at 45,000 miles, a wheel bearing should not be failing.

NHTSA #11637528

The Subaru front camera incorrectly detected a hazard. The automatic braking system engaged and locked the steering. I skidded off the pavement, causing damage to the car. At the time of the accident, the blind sight warning lights flashed on the dash signaling that they were disabled. I was going very slow in a driveway. No personal damage just property damage and damage to the car. I have let the insurance company know about the issue and the collision center. I have had periodic instances where the warning signals of blind sight disabled have come on the vehicle. I informed Subaru in August 2024 about the issue at my last maintenance appointment. There is also a software update required on the vehicle. I asked Subaru to update the software in August 2024, but I was told by a service technician that it was not possible to update . I had to make a separate appointment for the software update as it took a long time.

NHTSA #11634070

Defective windshields. The vehicle has been in my possession for 4 years. During these 4 years i've had 5 windshield replacements. 2 of which have been from rocks. 3 of which I have no idea what caused the damage, it seemingly happened out of nowhere while driving. This is well known (but not well dealt with) issue with Subaru vehicles with eyesight. People on multiple forums have the same issue, as do many people I know personally. Its a shame nothing has been done about this despite countless reports and complaints. This is a safety hazard.

NHTSA #11628153

After completing an OTA software update the screen would not load and entered continuous buffering disabling all environmental and safety functions.

NHTSA #11627582

The contact owns a 2020 Subaru Outback. The contact received notification of NHTSA Campaign Number: 24V227000 (AIR BAGS); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that on a separate occasion, while reversing, the rearview camera displayed a distorted image, compromising the back-over prevention system. No warning lights were illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired due to the cost. The manufacturer was not notified of the failure. The contact related the failure to NHTSA: 20V766000 (BACK OVER PREVENTION) however, the VIN was not included. The failure mileage was 61,000. Parts distribution disconnect.

NHTSA #11662773

The contact owns a 2020 Subaru Outback. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the thermo-control valve. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 90,000.

NHTSA #11609935

Hi: When I was driving yesterday, the engine warning light and brake warning light both turned on. The car was like frozen on the road cannot be moved no matter how to press the gas pedal. The police helped to call tow and move my car out of the road. The tow driver left my car at a flat parking lot. On the lot, when I tried to restart my car, the car started to shake side to side and up and down. I can feel some part is dislocated and one piece of heavy thing was swaying in the car. The engine warning light was on for two times during the last two years. First time when I sent the car to the dealership, they performed the check and fixed it by free. The customer service person told me the problem is the sensor failing and the fixing was free. So, I guess it is the system defect and the manufacture already knew it. So the repairing was free. However, with one year, the situation happened again. The second time I sent the car for fixing, the service person told me it was the same problem of sensor failing but they charged me around two hundreds dollar for the second time fixing. Yesterday, the same situation happened again with the brake warning light on at the same time. It is almost another one year after the second time I sent car for repairing. My most concern is the car completely suddenly stopped during the driving. If I was on the highway, serious collision may happen and I am already passed away.

NHTSA #11599179

Rear trunk door won’t lock when closed and open up while driving. It’s unsafe as I have to constantly keep an eye in rear view mirror to see if door popped open by itself. Took to service station and they said it’s tied to battery and it is preventing door to close because trunk door takes power to open. I do not understand how trunk door locking close cannot be independent of battery. It is quite unsafe for vehicle occupants and poses danger to other vehicles driving behind.

NHTSA #11598286

I have a occupancy sensor error which has turned off the airbags on the passenger seat. I looked up the issue and found an open recall with Subaru regarding this issue. I spoke with multiple case managers to resolve the issue. They said they have reported the issue to NHTSA but it is not an active recall because they have yet to find a solution. So they have no responsibility to fix the issue at this time. They are unwilling to provide me with an alternate option than driving my car with the exact issue they issued the recall for.

NHTSA #11598077

On [XXX], I was driving east on [XXX] on the North side of Toledo Ohio close to the intersection with [XXX] . The "Check Engine" warning came on, all the vehicle "Eyesight" functions were automatically turned off, and Pre collision braking and Pre collision throttle control features were activated. There was no danger of a collision at this time, but all of this left me stranded in the middle of this busy four lane highway. I was able to literally crawl to the shoulder of the road. I was not hit, but it was just good fortune that prevented that. This is where my safety was at greatest risk. After about 10 minutes during which I started and stopped the car numerous times, the pre collision braking and throttle were deactivated and I was able to drive the car. I located the nearest Subaru dealer (Yark Subaru Toledo, Ohio) and drove there. The cause of the Check Engine light was diagnosed as a failure of the Thermal Control Valve. I had received a letter from Subaru dated May 1, 2024 stating that this part might fail and extending the warranty for this part. That letter specifically stated that nothing needed to be done until the part failed. There was no mention of the fact that the car would be disabled when it happened. Part was eventually replace on July 1, 2024 two days later. Since then I have spoken to 3 people at Subaru of America seeking to understand why a Check Engine situation caused the vehicle to be disabled. I also asked the Service Advisor at Yark Subaru to explain. They have all been friendly and attentive, but they cannot or will not give an explanation. My main concern is that a Check Engine situation may cause this Pre Collision shut down to happen again. Based on the danger I was in when this happed, I think that there should have been a recall and the Thermal Control Valve replaced before failure. To be clear, the repairs were completed under warranty and Subaru has sent me a $350.00 coupon for future service. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11602880

This was December2023Clicking noise when turning. "Rear swaybar bushing replaced (have gap in them when loaded)" also replaced 2 front Axle/CV Boots. Said they were worn. Additionally today, 5/3/2024 got in my car and there is a crack in my windshield that occurred overnight. Crack comes from bottom corning on drivers side up about 12 inches.

NHTSA #11586755

Thermo Control Valve assembly has failed resulting in loss of use for the following: Rear Automatic Brake, Eye Sight lane keeping, loss of heat in cabin and failure of coolant to circulate within engine possibly leading to engine failure, loss of cruise control and check engine light coming on. Reference TSB [XXX] . Without cabin heat vehicle is not useable in current cold temperatures (Currently 22 degrees Fahrenheit in Ohio on December 14, 2023). Dealer has confirmed part failure. Issue must be addressed to continue operating vehicle so I paid $1185.87 out of pocket to repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11560096

On 12/6/2023, as I slowly turned right into a parking space, my car suddenly surged forward and accelerated without my input to the gas pedal. The brakes did not work, and there was no resistance from the brake pedal when I repeated to push it. The car continued to accelerate for about 80 ft as I focused on steering to avoid hitting other cars parked in the lot. The car ran over a curb, up a grassy area, and crashed into a row of trees. The airbag did not deploy. I sustained neck muscle strain/whiplash, and bruises to my chest and right knee. My safety was at risk, as well as anyone or anything that was in the car's path since I had no control over the acceleration or the brakes. The car is a 2020 Subaru Outback with about 44000 miles. It is in a body shop and they have not yet determined if it is safe to work on. So far, they have observed the engine race when the car was turned on. There were no warning signs prior to the acceleration. When I called the Subaru dealer service department, I was told that they never heard of this before and it had to have been my fault. They said I could bring it in after the body damage is repaired, and that I can pay for a diagnotic report. However, they expect that the report will not show anything.

Allegedly reported: 1 injury (as reported to NHTSA). NHTSA #11560354

The automatic braking system detection the RB system as it’s identified on the Subaru Dash heater, failure airbag deployment, all disabled repeatedly removal of the battery connections for a period of 30 minutes reset it but failure has repeated

NHTSA #11556860

Automatic Braking system has almost caused a rear-end collision 5 times, because it thinks a shadow is an object. We’ve brought the car to the dealership but they told us twice that they can’t replicate the problem. That doesn’t change the issue. I don’t want to wait until we have a collision and have to go through physical therapy and repairs to address this. Front headlights are blinding other drivers causing them to flash their brights at us regularly on the freeway and local roads which then blinds us and causing us to slow down and break. The dealership say that the lights can be adjusted but this is a serious risk to us and something that happens every night. It’s stressful to drive the car anticipating this all the time. We’ve replace the starter last year and having issues again. The car struggles to start. Last year they said this was a known issue and also replaced the battery. But it’s happening again. This indicates a more complicated issue in the electrical. I don’t want to have to replace the starter every year.

NHTSA #11556311

Per Subaru there is something wrong with the Cockpit Control Module (CCM) that is causing a constant / parasitic draw on the battery. This results in the battery being dead within 4 hours, leaving us constantly stranded. Because the CCM also controls the electrical system, many of the safety features (auto breaking, lane departure, etc) turn off randomly. This is the diagnosis from our local Subaru dealership: COCKPIT CONTROL MODULE IS DRAWING 2 AMPS. WITH COCKPIT UNPLUGGED THERE IS STILL A 1 AMP DRAW. WILL NEED TO REPLACED CCU THEN FIGURE OUT WHERE THE OTHER 1 AMP DRAW IS. UNABLE TO DIAGNOSE WITH MULTIPLE SYSTEMS DRAWING I have opened a case with Subaru of America, but with no resolution.

NHTSA #11555354

A well-known failure of the Thermal Control Valve (TCV) occurred, which disabled many or most of the safety features on the car in addition to crippling the heat output in the cabin. Additionally, depending on which way the valve sticks, it could overheat the car and ruin the engine, or worse. Car is under 4 years old and repair estimate is nearly $1900. There is a technical safety bulletin [XXX] that outlines a redesigned TCV. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11560041

I was driving and car accelerated without warning. Hit partially open garage door, only stopped after hitting and damaging back wall of garage. Significant damage to car, items in the garage and garage wall. There was no warning whatsoever. As of yet the car has not been assessed as to the cause of the malfunction.

NHTSA #11545058

The contact owned a 2020 Subaru Outback. The contact stated that while coming to a complete stop at a red light, an abnormally loud noise was heard coming from the vehicle, and then black smoke came from underneath the driver's side hood. Additionally, a fuel odor was detected while driving. No warning light was illuminated. The contact parked and exited the vehicle with two minor passengers while flames erupted from the engine compartment. No injuries were sustained, and no medical attention was received. The fire department arrived on the scene and extinguished the fire. A fire department report was filed. The vehicle was towed to a tow yard, where it was deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was 44,882.

NHTSA #11532050

Car lurches when put into gear, Transmission make loud chirping noise when place into gear from park, transmission shudders when turning. Car has had all recalls updated. Symptoms have been reported to dealer numerous times. Currently vehicle is at Subaru Dealer in Temecula Calif. Dealer states a know transmission problem is being addressed thru a Subaru Engineer. Have been without the vehicle for approx 3 weeks.

NHTSA #11534218

While driving my Subaru Outback, I encounter a problem where the Starlink Multimedia system abruptly goes black. Shortly after, the driver information center also goes black. Although the car continues to run, the cruise control, if engaged, and the EyeSight safety system shuts off as well. Both systems then undergo a reboot.

NHTSA #11525777

While driving on the NYS Thruway (I90), I started to pass a Tractor Trailer, I put my blinker on and began moving to the right to pass. There were 2/3 cars in back of me also passing. I was using cruise control and I began to put my foot on the accelerator to finish my passing and move over to the right hand lane to let the other vehicles pass me. However, upon accelerating, my car started to drop power, multiple lights displaying simultaneously indicating a potential problem. (Eyesight Assist, Vehicle Dynamic Control, Brake & Engine Lights), the vehicle started jerking back and forth and I lost all but maybe 5 miles of power. My choice at that time was put my blinker on and try and move to the right - letting the Tractor Trailer pass me on the right and HOPE there was not another vehicle behind so I could move over safely at that crawling speed or go to the left into the gully. This could have been a multiple car collision and maybe fatalities due to the speed and loss of control of my vehicle. After towing to the nearest dealer, they determined it was the Thermo Control Valve. I see now that there is a "service bulletin" and design change of this component and that other Subaru drivers have been affected the same way. This is a very serious situation. I ask, why no recall from Subaru. I have been without my vehicle now for 4 days and may not have it back until next week. I am very fearful of driving that vehicle again.

NHTSA #11525241

I pulled into my driveway, came to a stop and planned to back up a short distance to be nearer the front walkway. Before I could shift into reverse the car started to accelerate forward. I slammed my foot onto the brakes which had no effect on the acceleration. The car stopped when the lower bumper hit and ran up onto a large boulder on the edge of the driveway. The car was partially wedged on the top of the boulder but I was able to back it off the boulder, park and turn off the car. I have scheduled an appointment with the service department on February 1st, at the dealership where I purchased the vehicle in June 2020. Of note, I had a routine oil change and service check at this dealership on January 16 with no engine problems noted.

NHTSA #11503961

The contact owns a 2020 Subaru Outback. The contact stated that their daughter was driving approximately 35 mph when the dashboard displayed that an electronic power steering failure had occurred. The driver then lost control of the vehicle and ended up going over a curb hitting some rocks on the landscaping. The air bags did not deploy due to only the undercarriage being the only part that hit the curb and rocks on the landscaping. The vehicle was towed to the dealer. A police report was filed. As a result, the transmission as well as other parts of the vehicle to be damaged. There were no injuries or medical attention needed. The dealer diagnosed that the steering gearbox needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 37,000.

NHTSA #11508669