2023 Mazda Mazda3: Recalls, Complaints & California Lemon Law

Transmission failure when driving. Car was towed to dealership and diagnosed. Transmission and torque converter replacement required under factory warranty. Very long lead time for dealer to acquire replacement parts, about 4 months.

NHTSA #11724188

Cars lurches/jerks at low speeds when shifting 1-2 gears and sometimes rpm bounces up and down when downshifting.

NHTSA #11514104

On three occasions thus far when the vehicle was started and placed in drive the transmission slipped terribly, the engine rpms would race when pressing the accelerator and the vehicle would move at no more than a few MPH. The problem is intermittent but can be inspected. The problem has occurred on public roads when stopped at a light or stop sign and I was unable to move forward again after stopping. The problem was reproduced by the dealer. The dealer had the vehicle for 29 days for repair attempts and returned it to me one day before my states lemon law would have been triggered. There were several vehicle malfunction warnings displayed on the dash 10 to 15 minutes after the vehicle failed to move under its own power. I also purchased an OBDII code reader after the initial vehicle failure and was able to read transmission error codes on subsequent failures.

NHTSA #11513226

On 14th, 2026, while traveling at approximately 60 mph on the northbound 55 Freeway near the Katella exit, my vehicle suddenly began to shake violently without any prior warning. In response, I attempted to slow down by applying the brakes; however, the speedometer rapidly increased even as I maintained firm pressure on the brake pedal. Immediately afterward, the vehicle pulled sharply to the left, causing a complete loss of steering control and resulting in a collision with the center median barrier. Despite the force of the impact, the airbags did not deploy, raising additional concerns about potential safety system failures. At no point before the incident were there warning lights, alerts, or indications of mechanical or electronic issues. The vehicle had also undergone its regularly scheduled maintenance at the Tustin Mazda dealership on January 2nd, 2026, just prior to the accident. Given the sudden shaking, unintended acceleration, loss of braking effectiveness, steering failure, and non‑deployment of airbags, I believe this incident may involve one or more manufacturer defects affecting critical safety systems. I respectfully request that NHTSA investigate this matter. I also believe the vehicle’s Event Data Recorder (EDR) may contain information relevant to identifying the root cause of these failures.

Allegedly reported: 1 injury (as reported to NHTSA). NHTSA #11712753

The active braking support feature of this vehicle falsely warns me of an imminent collision. It happens pretty often, the system is obviously not quite smart enough. Last week, while accelerating away from a stop light in moderately heavy traffic, the active braking system APPLIED THE BRAKES in a panic manner, causing the vehicle to almost come to a complete stop, and I missed being rear-ended by the car behind me by inches. There appears to be no method to permanently deactivate this "safety" feature. I can turn it off through a series of menus in the infotainment system, but each time I start the car the system turns itself back on again.

NHTSA #11638015

My 2023 Mazda 3 started to have a more terrible and annoying rattle after 3000 miles. The engine will resonate and knock when it reaches a certain speed. The slow speed light throttle acceleration rattles. The most annoying thing is the multiple rattles inside, dash, door panels, and roof. It is like a can in the summer. What’s more terrible is that in the winter, its internal door panels, windows, and dash make a knocking sound like a screw is loose. I went to multiple Mazda dealers and it was obvious that they could not find and fix the issue. They either said they didn’t hear it or said it was a "normal noise". This is disappointing and unacceptable.

NHTSA #11628034

The contact owns a 2023 Mazda Mazda3 equipped with Bridgestone Tires, Tire Line: Turanza EL440, Tire Size: 215/45/R18, DOT Number: [XXX] . The contact stated that while inspecting the vehicle, it was discovered that the front passenger’s side tire had developed a sidewall bubble and the tire was replaced. Later the front driver's side tire had developed a sidewall bubble and was replaced. The contact later discovered the same failure had occurred on the replacement tire located on the front passenger’s side. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 2,500. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA #11598023

The contact's daughter had rented a 2023 Mazda Mazda 3. The contact stated that while his daughter was driving at approximately 70 MPH, the vehicle veered off to the left side of the highway and side-swiped a cable system; the vehicle then crashed into the end cap of a guardrail. The vehicle then hydroplaned and hit a bridge pillar. The vehicle flipped as the contact's daughter was ejected from the vehicle and the vehicle landed on the roof in the grass next to the guardrail. The cause of the crash was unknown. The vehicle caught fire and was incinerated by the time authorities arrived on the scene. The contact's daughter was pronounced dead at the scene. The fire department extinguished the fire and a police report was filed. The guardrail, cable system, and a wooden road post were damaged due to the accident. Due to the extent of the fire, it was unknown if the air bags deployed. The vehicle was towed to an independent mechanic. The contact stated that the investigators could not determine the exact cause of the crash but believed that it was likely that the contact's daughter fell asleep; the contact contests the investigator's findings. Upon his investigation, the contact discovered that owners of previous year model vehicles had reported that the air bag and seat belt pretensioners had failed to operate in the event of a crash. The manufacturer had yet to be notified of the failure. The vehicle was destroyed. The failure mileage was unknown.

Allegedly reported: 1 death (as reported to NHTSA). NHTSA #11561121

I was driving on the highway and decided to switch int the left lane so I sped up and heard a big bang and what sounded like my bumper being dragged against the ground. I see on my dashboard that there’s an electrical and engine malfunction so I pullover and pop the hood. A bunch of smoke comes out and i see a little fire so me and my friends run and call the police. The police and firefighters arrived just as the fire was getting large and it had engulfed the front right side of my car. If the notification that there was a malfunction didn’t come on, I feel as if we could’ve been hurt much worse or even have died. I’m not much of a person that knows about cars and it sounded like my bumper was scraping and by the amount of times i’ve scraped my bumper, i believed it until I saw my notification. The vehicle is still being inspected for cause of fire and this vehicle has never had this problem before.

NHTSA #11545514

Automatic emergency braking suddenly engaged while driving on the highway. The car decelerated abruptly to a complete stop, causing the driver behind to rear-end me. There were no vehicles or obstacles in front of the car when the brakes engaged - the closest car was at least 100 feet in front of me. This collision was clearly the result of a faulty automatic emergency braking system. I do not feel safe driving the car knowing this malfunction could happen again, especially at highway speeds. Sudden unexplained braking presents a huge safety hazard to all drivers, increasing the likelihood for collisions and injuries. There were no warnings or symptoms prior to the unexpected brake system activation. After the brakes activated mistakenly, warning beeps and “BRAKE!” message appeared. Car has collision damage and has not yet been inspected by dealer. Police report filed.

NHTSA #11522759

While driving in snow storm I had to pull over and I noticed lights were covered with snow . LED lights will not produce heat to melt snow The lip above and the ledge below traps the snow and with the way the headlights are set up the snow sticks on the lights which affects visibility creating a safety issue. Same thing happens in rain. I have been to a parts store and a mechanic shop Both shops said this is a poor design. The lip and lower ledge trap the snow and LED lights will not melt the snow. This vehicle would be unsafe to drive in a snowstorm because of poor vision. Thank you

NHTSA #11530568

It is the infotainment system but please, hear me out. The manual states that one is able to change channels by using the controls on the steering wheel. That is not the case. It actually is another feature NOT described in the manual. So now in order to change the channel, one must take their hand off the wheel and fidget with a selector and look at a screen (and also hope they are in the right menu section). This is not how most cars with this capability act. This is something that even the manual doesn't describe. This is a hazard, albeit not spontaneous because it leads to distracted driving. I've been to the dealership twice about the issue. I've contacted Mazda corporate. There are anecdotes of others having the same complaint and how this is a hazard. My complaint to Mazda Corporate and the dealership requests to Mazda Corporate have been met with a "Oh well, it is what it is and we can't help you." sort of reply. -The component at this time can be inspected. -The feature leads to distracted driving. -Yes, two local dealerships have observed the issue and were puzzled as to why it says one thing in the manual about the feature and the system acts a different way. -No inspection by the manufacturer, but I have contacted Mazda USA corporate via chat and email. -No warning lamps or messages because apparently this is how it operates.

NHTSA #11527457