Below are recalls and complaints reported to NHTSA for the 2025 Chevrolet Silverado. This information is consumer-reported and provided for general informational purposes only. Vehicles like this may qualify under California lemon law depending on their individual repair history.
The following recalls were reported to NHTSA. A recall does not by itself establish that any individual vehicle is defective.
General Motors LLC (GM) is recalling certain 2025 Chevrolet Silverado EV work trucks. The pedestrian alert sound system may not produce sound at a sufficient volume. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Reported consequence: A vehicle that fails to make sufficient sound may result in pedestrians being unaware of an approaching vehicle, increasing the risk of injury.
Remedy: Dealers will update the software in the body control module (BCM), free of charge. Owner notification letters were mailed January 22, 2025. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242483530.
General Motors, LLC (GM) is recalling certain 2024 Chevrolet Silverado Medium Duty 4500HD, 5500HD, 6500HD vehicles. The air bag sensing and diagnostic module (SDM) may not have been activated during installation.
Reported consequence: Inactive air bags will not deploy in a crash, increasing the risk of injury.
Remedy: A Navistar technician will activate the air bag module, free of charge. Owner notification letters were mailed November 1, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242477760.
General Motors, LLC (GM) is recalling certain 2025-2026 Chevrolet Silverado 3500, and GMC Sierra 3500 vehicles with gasoline engines and dual fuel tanks (RPOs L8T and N2N). The rear fuel pump may not transfer adequate fuel to the front tank, causing an engine stall.
Reported consequence: An engine stall increases the risk of a crash.
Remedy: The vehicle's engine control module (ECM) will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 8, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N262544420. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
The following are consumer-reported complaints filed with NHTSA. These are unverified allegations and are not proof that any defect exists.
Navigational system is not functioning properly. On Star button remains in on position. All apps on dash will not connect to internet. Google Map cannot locate exact location of vehicle. Also phone app for the vehicle no longer communicating with the truck. Can only use key fab for minor functions. Can only use vehicle for short range driving, since long range driving plans cannot be determined.
NHTSA #11702362
Over the past three days, my digital gauge cluster and digital entertainment center have locked up while driving. This means I have no idea how fast I’m going no idea if my turn signals are working and no idea what percentage of charge I have left. The screen stays frozen, even after the card was turned off. I have to wait hours before the car decides to finally reset itself. I have a video I can upload if requested.
NHTSA #11669300
Fin on top of the truck covering key electrical components fell off after 3 weeks of ownership.
NHTSA #11654463
I feel asleep at the wheel somehow ended up hitting the car in front of me i know adaptive cruisae was on. After i hit the car i woke up and then ended up in a ditchg no airbags deployed or anything. I don't remember what happenedf up until i woke up. which was after i hit the car in front of me.
NHTSA #11745466
What component or system failed or malfunctioned, and is it available for inspection upon request? GM and dealerships have report extensive failures of the Telematics Control Module (TCM) that connects onstar and provides GPS navigation ability. There is currently no issued recall. Yes, this can be provided for inspection. How was your safety or the safety of others put at risk? Unlike 2024 vehicles, where Android Auto is supported, providing a safe, hands free workaround for the failure of the TCM, on 2025 models, GM deliberately removed support for Android Auto to force OnStar subscription services, even for basic navigation. This greed-based decision, along with undisclosed failures of the TCM and months of back order waiting list to fix, puts drivers at significant safety risk when forced to revert to other navigation solutions. It is guaranteed this decision (putting safe navigation behind a paywall, and the mass failure of this hardware) will result in loss of life due to forcing drivers to revert to legacy and unsafe practices, including being forced to use their phone in a non-handsfree method. They also removed basic lane keeping warnings and steering, traditionally free with the vehicle and now only available with a full onstar subscription. This liability is exclusively due to the push towards subscription models at the impact of public safety. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, dealership confirmed this failure and the extent of the failures across 2025 vehicles. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? All indications were normal except no data connectivity and GPS signal was also lost. As an officer in the military, I can't standby and let this deliberate impact to public safety continu
NHTSA #11722370
July 2025 RO (mileage ~5,500): Propulsion reduced power; AC loss/no cooling; charging failure; loose weather stripping; shark fin antenna loose; brake pedal clicking on stops; OnStar connectivity loss. July 13-22 2025 (mileage ~6,000): Electrical impairments; reduced acceleration/speed; vehicle not charging; weather stripping missing/loose; shark fin coming loose; brake clicking during stopping; no OnStar connectivity. September 11-October 20 2025 RO (mileage ~8,000-10,000): Intermittent transmission warnings; unexplained gear shifts; backup camera blackouts; infotainment/cluster glitches/freezes; repeated brake pedal clicking; hypersensitive safety system (abrupt hard braking/pulling). Recent unrepaired issues (December 2025, mileage ~13,000-13,100): Intermittent transmission warning light (on for 24 hours then off); unexplained shift to reverse while in Drive (rolled backward at stop light. no gear user input here to put truck in reverse. Had to restart truck to fix.); backup camera cutouts/blackouts while moving; infotainment/cluster glitches; repeated brake pedal clicking (5-6x per stop); hypersensitive safety system (abrupt braking/pulling to one side, overcorrections are safety hazard).
NHTSA #11706907
On Star Telematics Module is failed and on backorder and no ETA according to dealership and ONSTAR. This is a safety issue as GPS is unavailable, SOS is unavailable, Cannot Locate Vehicle if lost or stolen. The company is very slow in response and this seems to be a global known issue.
NHTSA #11707963
See attached document for complaint.
NHTSA #11703795
Onstar no longer working and the Onstar Module that needs to replaced is on backorder with no time frame of getting the part. Happening to many GM vehicles with Onstar.
NHTSA #11699314
Observation: "While operating the vehicle in Reverse (R) with the One-Pedal Driving (OPD) mode enabled, the expected aggressive regenerative braking deceleration is disabled or significantly reduced compared to when driving forward in Drive (D). Safety Concern: "This creates an unexpected driving experience where the car continues to coast/accelerate without input when the accelerator is released, requiring the driver to use the traditional friction brake pedal to stop the vehicle. This goes against the driver's established muscle memory and expectation from OPD in Drive, creating a potential safety risk, especially in tight maneuvering situations where quick, expected stopping is necessary." Suggested Action: "Review the design choice to disable/reduce OPD-level regenerative braking in Reverse to determine if a gradual or driver-selectable level of regen braking could be safely implemented to maintain consistency with the OPD driving 'norm' and prevent unexpected coasting."
NHTSA #11692484
While driving, the infotainment display went blank except for hvac display and became unresponsive. Within two minutes the instrument panel froze. Speed no longer updated. Turn signals no longer worked. Vehicle could not be powered off. Drive, reverse and park shifting worked. Camera displayed when shifted in reverse. System reset after plugging into charging station for a few minutes. Occurred multiple times over the last two weeks.
NHTSA #11656227
There are two systems that are a hazard and dangerous on the Silverado EV. The First one is the Automatic High Beams. The Auto high beams will continuously flash other drivers on the road. This can blind other drivers and possibly case a crash. The other Dangerous safety feature on the vehicle is the Automatic Emergency Braking. The AEB feature when crawling behind another vehicle in bumber to bumper traffic will randomly just slam on the brakes unnecessarily which could cause a rear end collision. When this happens, There is no need for emergency braking as I am in full control of the vehicle. It will just slam on the brakes and the vehicle will come to a complete sudden stop. I have reported the issues to the manufacturer and instead of correcting the issue, They've advised to turn the features off. This defeats the purpose of the vehicle coming with these features. General motors needs to be required to correct these deficincies with a software update.
NHTSA #11637021
If your 2025 Chevrolet Silverado has had repeated repairs for the same problem, you may have rights under California lemon law. Tell us about it and we will review your situation at no cost and no obligation.
This page is attorney advertising and is provided for general informational purposes only. It does not constitute legal advice and is not a substitute for advice from a licensed attorney regarding your specific situation. Viewing this page or contacting Lucky Lemon Law does not create an attorney-client relationship; such a relationship is formed only by a signed written agreement.
The recalls and complaints shown here are reported to NHTSA and are consumer-reported, unverified allegations. They do not establish that any defect exists in any individual vehicle, and nothing on this page should be read as asserting that the 2025 Chevrolet Silverado is defective. Counts reflect items filed with NHTSA and may not be current. “May qualify” statements are general and do not mean any particular vehicle or owner qualifies.
Past results do not guarantee a similar outcome. Every case is different and depends on its own facts. Lucky Lemon Law is responsible for the content of this advertisement.