Below are recalls and complaints reported to NHTSA for the 2022 Kia Ev6. This information is consumer-reported and provided for general informational purposes only. Vehicles like this may qualify under California lemon law depending on their individual repair history.
The following recalls were reported to NHTSA. A recall does not by itself establish that any individual vehicle is defective.
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Reported consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters are expected to be mailed April 29, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC302.
Kia Motor America (Kia) is recalling certain 2022 EV6 vehicles. A software error in the Shifter Control Unit (SCU) may disengage the parking mechanism, which can allow the vehicle to rollaway.
Reported consequence: Vehicle rollaway can increase the risk of a crash or injury.
Remedy: Drivers are recommended to park their vehicles on level ground and avoid parking on a slope/inclined surface whenever possible until the remedy has been performed. Dealers will update the Shifter Control Unit software, free of charge. Owner notification letters were mailed May 25, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC236.
The following are consumer-reported complaints filed with NHTSA. These are unverified allegations and are not proof that any defect exists.
Electrical propulsion failure resulting in 3 tow-ins. Vehicle goes into limp mode, slows to 20 mph on highway and then stops after about 2 miles. The issue appears related to the ICCU, fuse and 12V battery failures. History includes 6 attached ICC | The contact owns a 2022 Kia EV6. The contact received notification of NHTSA Campaign Number: 24V867000 (Electrical System) and the vehicle was repaired at the local dealer. The contact stated that four months later while driving 75 MPH, there was a p | The car has 41,000 miles and has experienced the second failure of the ICCU, so it will have a third unit in 3 years. The noteworthy issue is the risk associated with these failures. The unit failed on the freeway, and power was reduced to 20% (est
This make/model has a known ICCU issue. Ours went out just after warranty expired and the cost is 4,000. The EU and some Asian countries have extended the warranty of this fault due to how prevalent it is. | While driving the vehicle a short distance, I heard a loud pop from the back seat. The car immediately warned of an electrical system failure. The issue and symptoms are consistent with ICCU module failures, reported across the kia/hyundai egmp p | ICCU unit lost power and the car was unable to drive. Luckily I was parked when it happened but if I had been driving it would have been very dangerous. The part was replaced under warranty but they said it could happen again which really scares me
The ICCU failed which was part of the recall. Kia is unwilling to honor repairs beyond the 100,000 mile warranty which is unacceptable because there is still no resolution and it is subject to potential future failure. I need an extended warranty. | ICCU issue. Car showed zero percent battery after charging all night. No warning lights no errors | While driving in traffic I heard a pop, then the "Check Electric Vehicle System" warning came on the dashboard. After a minute or so the dash warning changed to "Stop Vehicle" and the car limped home but at a lower speed. This matched the description
The iccu failed on this car rendering the whole vehicle useless. This part is currently a recall and I was using a new ICCU with the software update per their recall solution. My second ICCU failed at approximately 40k miles. | Incident occured october 17, 2024. Was driving approximately 30mph on a local road when lights flashed to "check electric vehicle system". Was speed restricted to 25mph (on 45mph road) and was able to make it back home approximately 1 mile away. Car | Vehicle alerted Electric Vehicle System problem on the dashboard. Dealer determined the ICCU and a fuse needs to be replaced again. Dealer has declined to replace the ICCU under the current recall stating it was already replaced 8 months prior. Vehic
The ICCU system in my 2022 Kia EV6 failed for the SECOND time on the highway. The car threw an error telling me to "Check the electrical system" and "Pull over safely immediately" or something similar. Had I not made it to the shoulder, I would have | This electric vehicle failed to charge at level 2 charger at home. It charged at level 3 fast chargers however it registered a full charge at 125 miles and the level of charge in % and miles remaining fluctuated with sudden shifts. There were no wa | ICCU failed preventing the vehicle from being charged and killing the 12v battery.
I am reporting a recurring safety and reliability issue with my 2022 Kia EV6 GT-Line (VIN: [XXX] ). The vehicle currently has approximately 63,100 miles. The vehicle repeatedly displays a “Check Electric Vehicle System” warning message. This problem | The car stop working with this message "check electric vehicle system" I towed the car to kia service. They told me nee to replace ICCU unit. They replaced it for free, but still didn't have a car for few days. No loaner car offered. | Started car. Heard a pop in the back seat area and then an error message appeared on the dash.
While braking in parking lot with low speed and turning the steering wheel, all of sudden the vehicle reving up by itself and then accelerate forward uncontrollably. | The rear brake lights do no illuminate under heavy i-pedal and Level 3 regeneration when the throttle pedal is being touched. When moderating the rate of deacceleration with the throttle pedal, the brake lights do not illuminate even during rapid de
Allegedly reported: 1 injury (as reported to NHTSA).
The AC charging for this car stopped working around [XXX]. After 3 trips to the dealership for repair I brought it back a 4th time and because the dealership was unable to repair it they gave me a loaner to use while they tried to figure out the prob | I purchased my car 08/08/2022, my car stopped charging by June 2023. I took it to the shop and was told, it was my charger. In August of 2023, I was told it was the ICCU. From 06/2023-12/07/2024, I had a total of 9 recalls on this car. Kia did not no
When attempting to level one charge the vehicle at home, the car returned a failure to charge error and would not charge. This was attempted several times using different outlets and the same error occurred. The car was brought to Gettel Kia in Brade | Integrated charging control unit (ICCU) failed. While my failure prevents ac charging, the unit is could also fail causing the 12v battery not to charge and the car to power down while driving on the highway. There were no indication of part failure. | I was driving and experience a loss in power and got the Check Electrical Vehicle System error message. As I was trying to get to safe location to stop, I got the Power Limited warning message and lost even more power then got the Stop Vehicle and Ch
Liftgate/Back Hatch consistently immediately automatically closes after opening, and has hit both drivers on the head before able to move out of the way. More detail: to open the back, one pushes a button, the rear hatch beeps, and then it automa | The sunroof glass exploded on a hot day while my wife and I were in the car traveling 55 mph with the air-conditioning on. The remaining glass edges were flared up and outward. The sunroof glass was fully closed and the cloth sun shade covered the gl | I received my car with tailgate misaligned, it could not be adjusted. There are some more out there like mine. I feel this is a safety problem that the area of the body where the hinges attach is not stiff or strong enough to open/close the heavy unb
Allegedly reported: 2 injuries (as reported to NHTSA).
The instrument cluster screen went black for no reason. Cannot see speed, turn signals do not work, do not know about any instrument issues, and blind spot camera doesn't work. | The driver cluster in front of steering wheel constantly goes from blank to partial screen to proper driver display. I have video of this happening. The speed, turns signals, odometer and blind spot information cannot be seen during the blank and par
The defogger system. The car window’s suddenly fog up while driving and not adjusting the system. Theres no warning the windows start fogging up. I adjust to just front defrost on high and it takes 10 to 15 seconds to clear the windows good enough | While driving at night under raining conditions with the auto highbeam enable the Kia’s HUD will get so bright at times that will white out the drivers view making nearly impossible to see. Kia’s is refusing the fix the issue because they can’t repl | I live in the Northern Latitudes in Washington state, on my drive this morning with temps in the low 40's and high humidity the heating/ventilation system just stopped working. My windshield immediately fogged up completely and I had near zero vis
After charging vehicle using L2 charger, (max 7kw) vehicle threw two error messages on screen. 1) “check electrical system” & 2) “stop vehicle and check power supply” Using an OBDII reader, the car provided error code P1A9096. I also noticed the car | Stop vehicle and check power supply light comes on. Car shows error message before battery dies while driving. And wont charge. If on the highway you have a few minutes before your battery completely dies although my battery is 100% | Issue with the car, not charging it was the ICcU module
I was unable to charge this electric vehicle which I normally do almost once or twice a week using my home level 2 charger. It also did not speak the message that "your vehicle is being charged" which it normally does when I charge the vehicle. I t | I completed recall in March of 2025 for the ICCU, it failed driving down a busy road in January 2026. Kia did complete the repairs, but only warranties for 12k miles. It seems from forums I am in that this is a common problem. It also caused me to | Car lost all power and came to a stop while backing out of a driveway on a residential street. It would not respond to any attempts to start it. None of assessories worked. It had to be towed to the dealership. The dealer said the 12v battery was a
Brake lights do not illuminate when using the Regenerative Braking System in the Kia EV6. The vehicle is fitted with a 'one-pedal-driving' system that allows the vehicle to slow down and stop without actuation of the brake pedal. When using this sys | The vehicle does not trigger brake lights when it is using Regen braking or the ipadel mode. This can cause a safety hazard for the person behind me to crash into me without the brake lights warnings | While driving with the hatch open, while carrying objects to long to place in car, (The drive was less than one mile and yes I had a red flag on my kayaks) I was driving in what is called 1Pedal driving. When coming to a stop light unbeknownst to m
There exists a serious manufacturing defect in that the brake lights do not turn on when the car is used in one-pedal drive mode and even a rapid deceleration occurs due to regenerative braking. This was documented by Consumer Reports and it presents | The brake light does not activate in a way that would signal to other drivers that the vehicle is stopping or slowing down, while using higher regenerative braking. The ipedal mode can have a significant amount of deceleration and not activate the b
While driving at speed, I heard a pop noise from the car. A few seconds later, I received notification to check vehicle electric system. The vehicle slowed down despite my increasing throttle input. I was able to limp to a parking lot where it was fl | Regarding NHTSA Recall No. \/ MFR Recall No. : 24V-867 \/ SC327, I have contacted Kia America by email who is avoiding to take action in rectifying the SC327 defect. From March 11th to March 15th 2025 I have emailed Kia several times to address the i | While driving, EV vehicle suddenly lost most of its power. Normal driving on 45 mph street until came to stop light. Would not accelerate over 28 mph upon light changing to green. 12v battery warning light came on.
The contact owns a 2022 Kia EV6. The contact stated that while driving approximately 64 MPH, the left side of the steering wheel seized, and the vehicle aggressively jerked to the left into oncoming traffic. The message “Smart Cruise Disabled” was di | This has happened multiple times: driving along, no cars in front of me or along the side. FCW suddenly appears along with emergency braking kicking in. I can be doing 35 mph or 60 mph, doesn't matter what speed. Scares the heck out of me, and cr
Several months ago, a bit of road debris hit the front grill and broke a piece off. Soon after that I began receiving messages of 'check vehicle electrical system', 'active air flap warning', and another that at this point I do not recall. The overal | While driving along the courtney Campbell causeway there was a loud explosion shaking the car out of control. I was able to pull off the road and inspect the roof, where the exploding sound occurred. I found the glass panoramic sunroof had fractured
The vehicle lost the ability to charge on Level 2 and Level 1 charging. I took it to the Kia dealer and they told me it was the ICCU, took then a week to repair. | Perhaps 1 year into owning this car the apple carplay connection started going in and out-- it takes perhaps 10 to 15 seconds for it to start working again. I've tried different phones and cords. This issue is getting worse, sometimes 6 times in a 20 | Sunroof glass spontaneously exploded outwards while driving on the highway with a loud boom
After driving the car for a while, when the car is parked and the car is still ON, the car began displaying - Check Lane Assist warning. From that point, the Smart cruise is not working. The warning displayed for more than 20 days. It happened to me | The amp for the audio system has failed. Because of this, the audible alerts associated with the vehicle safety system cannot be easily heard. The systems are still functioning but the audio alerts are not. The exterior EV pedestrian alert sounds are
The car will cannot be charge as per advertised. It's stop charging after 45 min. and keeps repeating. Took the vehicle to dealership and they cannot solve the problem. I also wrote a letter to Kia of America via certified mail but no respond. | The vehicles audio AMP has failed, and various warning sounds are not audible. Kia motors and dealers are scheduling long times for appointments and parts taking a long time to be replaced. There are a lot of owners that are having the same problem.
I am reporting a recurring safety defect. While driving the vehicle the Integrated Charging Control unit (ICCU) failed and caused the vehicle to lose power and stop in the road. I feel strongly that this ICCU issue and subsequent failure should be ma | When car is on HDA mode. Drive assist. And speed under 20 miles on Highway. Car make sudden stops and it is also called ghost stop. Very dangerous and will likely to cause rear end collision.
When heavy regenerative braking is used, the car decelerates very quickly. Despite this, the brake lights do not turn on. This is very dangerous as the regenerative braking can be used to completely stop the vehicle. People driving behind me need to | The headlights on the 2022 Kia EV6 do not provide enough illumination for proper night driving. They are full and barely shine enough for 10 feet out from vehicle. This causes concern for object avoidance and proper identification from oncoming traff | No distinct incident. The headlights on this car are very poor. My front visibility is extremely limited, especially to the right, since I got this vehicle in August 2022. I have had some narrow misses with pedestrians I couldn't see. These are t
If your 2022 Kia Ev6 has had repeated repairs for the same problem, you may have rights under California lemon law. Tell us about it and we will review your situation at no cost and no obligation.
This page is attorney advertising and is provided for general informational purposes only. It does not constitute legal advice and is not a substitute for advice from a licensed attorney regarding your specific situation. Viewing this page or contacting Lucky Lemon Law does not create an attorney-client relationship; such a relationship is formed only by a signed written agreement.
The recalls and complaints shown here are reported to NHTSA and are consumer-reported, unverified allegations. They do not establish that any defect exists in any individual vehicle, and nothing on this page should be read as asserting that the 2022 Kia Ev6 is defective. Counts reflect items filed with NHTSA and may not be current. “May qualify” statements are general and do not mean any particular vehicle or owner qualifies.
Past results do not guarantee a similar outcome. Every case is different and depends on its own facts. Lucky Lemon Law is responsible for the content of this advertisement.