2020 Hyundai Kona: Recalls, Complaints & California Lemon Law

ENGINE

My car was taken in as a part of recall bulletin 203 for improperly heated piston rings treated pistons rings that result in premature engine failure and possible fire on 12/5/25. The knock sensor test was performed and the KSDS software was install | The contact owns a 2020 Hyundai Kona. While the contact’s son was driving the vehicle on the highway at an undisclosed speed, there was a knocking sound coming from the engine and the vehicle failed to stop as intended. The gear shifter was shifted i | Vehicle suddenly began shutting off upon braking and/or acceleration at any speed, idling very hard, and/or barely starting or dying immediately after starting and making a very loud whining noise while driving on an interstate. A mechanic ran a diag

UNKNOWN OR OTHER,ENGINE

Basically normal driving the car stalled. It slowed to a stall. I had to restart the car. This has happened a couple to times. | MY 6 MONTH OLD, HYUNDAI 2020 KONA THAT I BOUGHT IN JULY OF 2020 WITH ONLY 7000 MILES ON IT HAD ITS ENGINE FAIL AS I WAS DRIVING MULTIPLE TIMES BEFORE I WAS ABLE TO GET IT TO A MECHANIC. NO INDICATION LIGHTS CAME ON TELLING ME THAT THERE WAS SOMETHING

POWER TRAIN,ENGINE

The vehicle has ~51K miles. It has been maintained according to the manufacturer's recommended repair schedule. At low speeds (<10 mph) or when coming from a full stop the vehicle hard shifts. When driving up inclines at low speeds (<10 mph), the veh | The engine on my 2020 Hyundai Kona failed suddenly while driving, causing complete loss of power. There were no warning lights until after the failure. The vehicle was towed to a Hyundai dealership. Initially, the dealership stated the failure was r | My vehicle has a very rough idle-vibrating at idle or stopped and not shifting properly-gear slipping. There is sluggish acceleration or jerking and the problem worsens while at a stop light/stop sign or at times when making a turn. The RPM goes bet

ELECTRICAL SYSTEM

the headlights in this model Kona keep burning out after 9 months or so. I have replaced them multiple times in the last 5 years on both left and right sides. I use glove to put in the bulbs and are very careful not to let my hands touch the bulb. | Back up camera had not worked since purchase. It is now August been dealing with the dealership and Hyundai National with a case number and zero help to rectify this issue. It is not my fault the sales man who sold me this car left two days later. an | Since the October 2020 recall requirements, I have been told not to park in my garage (thereby exposing my car exterior paint and plastic to the elements) and I have not been able to use my battery at 100% (forced to change limit to 80%). I would not

ENGINE AND ENGINE COOLING

The contact owns a 2020 Hyundai Kona. The contact stated that the vehicle was consuming an excessive amount of engine oil. There was no warning light illuminated. The vehicle was taken to a local dealer, where the vehicle was diagnosed, and the conta | The contact owns a 2020 Hyundai Kona. The contact stated that while operating the vehicle, there was a knocking sound coming from the engine compartment. The vehicle was taken to the local dealer, who replaced the turbocharger, but the failure persis | The contact owns a 2020 Hyundai Kona. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact stated there was a pinging sound inside the vehicle. There were no warning lights illuminated. The vehicle was take

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

Ignition, speed and driving halts. I've had this Kona repaired a couple years ago and it took about 6-8mos to get my vehicle back, the this year 2025 the vehicle again is giving me problems. I thought of applying the lemon law however the week of t | When stopped at a light, I hit the gas and the car just sputtered. The car jolted and did not move, finally, hit the gas again it was able to move. It has happen before. My roommate's Dad told me I need to keep track of problem and file a report. I w

POWER TRAIN

The contact owns a 2020 Hyundai Kona. The contact stated that during a regular maintenance visit, the contact was informed that there was a leak coming from the front axle transfer case, which was initially unrepaired. The vehicle was subsequently ta | While driving under normal conditions, the vehicle’s dual-clutch transmission (DCT) failed to engage properly, causing a sudden and unexpected loss of propulsion. When the accelerator was pressed, the vehicle hesitated and did not respond as commande | The issue is when I'm decelerating to around 5 mph and go to accelerate again, there is a horrible grinding sound from the transmission and I can no longer accelerate. I then have to stop and re accelerate. This is dangerous if there is a car comi

AIR BAGS

TL* THE CONTACT'S CLIENT OWNS A 2020 HYUNDAI KONA. THE CONTACT STATED THAT THE CLIENT WAS GONG THROUGH AN INTERSECTION AND ANOTHER DRIVER RAN A RED LIGHT AND BROADSIDED THE CONTACT'S VEHICLE. BOTH THE CLIENT AND HER PASSENGER WERE INJURED AND HAD TO | 2020 HYUNDAI KONA. CONSUMER WAS IN AN AUTO ACCIDENT WHERE THE AIRBAGS DID NOT DEPLOY. *LD THE CONSUMER STATED THE VEHICLE WAS INVOLVED I AN ACCIDENT WHERE THE SIDE CURTAIN AIRBAGS DID NOT DEPLOY. THE PASSENGER WAS SEVERELY INJURED. *JS*DT*JB

Allegedly reported: 4 injuries (as reported to NHTSA).

ELECTRICAL SYSTEM,ENGINE

In May 2023 after washing and vacuuming my car, it would not start. The battery appeared dead. I waited and tried periodically, and after about three tries, It started. This happened a couple more times, but always restarted and appeared to recharge | BOUGHT NEW CAR JULY 2020, WAS GOOD FOR A LITTLE WHILE THEN STARTED TO HAVE LOUD TICKING NOISE UNDER HOOD. BROUGHT CAR IN FOR SERVICE AT 3100 (APPROX) MILES HAD A FEW ISSUES AT THIS SERVICE, MAIN WAS NOISE. WAS TOLD MECHANIC LOOKED UNDER HEARD NOISE (

STEERING

I was hearing a weird sound when turning the steering wheel and it reminded me of the same noise that happened before in March 2020 when the column and housing (part number 56390-39000)as well as bolt-safety lock (part number 81919-31000) were replac | TRYING TO PULL OFF THE FREE WAY TO THE RIGHT AND IT DECIDED TO GO LEFT IN FRONT OF A TRUCK. IT LIKES TO TAKE CONTROL. SCARY. I HAVE NOT HAD THE CAR EVEN 2 MONTHS. | TL* THE CONTACT OWNS A 2020 HYUNDAI KONA. THE CONTACT STATED WHILE DRIVING 35 MPH, AN UNKNOWN WARNING LIGHT FLASHED ON AND OFF INTERMITTENTLY. THE CONTACT LOOKED IN THE OWNERS MANUAL AND BECAME AWARE OF A FAILURE OF THE ELECTRIC STEERING SYSTEM. THE

FORWARD COLLISION AVOIDANCE

I was driving on the highway and there was no one around me and the forward collision warning went off. The car then braked on my behalf going 70 mph on the highway. THis has happened twice so far. | FRONT-COLLISION WARNING LIGHT KICKS ON WHILE GOING 45-50MPH. NO OBSTRUCTIONS. BRAKES ENGAGE, STUCK IN 4TH GEAR. MUST PULL OVER AND RESTART CAR TO RESET. OCCURS INTERMITTENTLY, BUT HAS HAPPENED AT LEAST WEEKLY FOR THE LAST 6 WEEKS. IN AND OUT OF D

UNKNOWN OR OTHER

On 3/29/26 my Kona caught fire while parked in the front left side of the engine and burned completely within eight minutes. This is not an electric car. Prior to that I drove the car all day with no incident. It was later in the evening around 5:40 | Car keeps stalling no matter what speed you're driving. Took the car to NTB and they said nothing is wrong with it. It continues to happen even in busy highways where someone almost ran into the back of me. Not safe to drive. Concerned as numerous fo | The air conditioning system has a drain for condensation. If it gets plugged up, from debris, algae, etc., it accumulates and sprays it into the passenger cabin. In my auto it sprays considerable water onto the floor boards of both the driver side

Allegedly reported: 1 injury (as reported to NHTSA).