Below are recalls and complaints reported to NHTSA for the 2020 Ford Fusion. This information is consumer-reported and provided for general informational purposes only. Vehicles like this may qualify under California lemon law depending on their individual repair history.
The following are consumer-reported complaints filed with NHTSA. These are unverified allegations and are not proof that any defect exists.
Last month, while transporting my brother to his arm surgery in Chapel Hill, NC, I observed unusual and audible shifting behavior when engaging the vehicle's sport mode. This mode is typically utilized for extended journeys on highways and interstate | During a road trip, received an error message indicating "SHIFT SYS FAULT" after the vehicle would not shift out of park. Upon inspecting the vehicle, it was noticed that the transmission linkage cable bushing was missing. The error message had appea
In early October 2025, the vehicle was taken to an independent dealership service department for a routine oil change. Several weeks later, the vehicle appeared to be leaking fluid and began experiencing loud knocking/clacking noises, significant vib | My Ford started making a loud noise whenever the accelerator wasn't being pressed, after taking it to the mechanic, he said it is the cracked flex plate. After some light research, it was aparent that this is an issue that Ford's cars have, and ford | My 2020 Ford Fusion has experienced three separate flexplate failures, as well as transmission issues following the most recent repair. Failure #1: Occurred before I owned the vehicle (confirmed later in the vehicle’s history). The flexplate was rep
I have a check engine light on due to an issue in the emissions system. The issue is that the purge valve is stuck open. I know that this is an issue that you had a recall on for older models of the ford focus for this same reason. All the systems of | Check engine light keeps coming on saying evap emissions. Have replaced purge valve, gas tank inlet and solenoid. This is the 6th time for check engine light | Previously reported as a fuel pump issue, incorrect. The mechanic was incorrect. The fuel injectors failed releasing fuel into the engine and the entire system. High risk of fire.
HEAD GASKET FAILING, common problem in car. Broke down in the middle of busy Main Street and started smoking out of exhaust pipes. It has been confirmed by my service center that they now have 3 ford fusions, including mine, that they are replacing a | I only have about 45K miles on my car. I began to hear a rattling sound while vehicle is idling and more pronounced with the air conditioning on. I took it to the Ford service department at the dealership where I bought it and was told it was a crack | The check engine light came on. The car was regularly losing coolant but none was leaking out. I topped it off but the coolant level lowered again. My mechanic suspects it is a problem with the Ecoboost engine where the coolant leaks into the cylinde
The contact owns a 2020 Ford Fusion. The contact stated that while driving at various speeds or while the vehicle was idling, there was an abnormal clunking sound coming from the vehicle. There were no warning lights illuminated. The vehicle was take | The contact owns a 2020 Ford Fusion. The contact stated that after starting the vehicle there was an abnormally loud knocking sound coming from the engine compartment. The vehicle was taken to the local dealer who diagnosed that the flex plate was cr | Began to hear loud rattling noise under hood. Brought to Ford dealer who determined the cause is a failed Flex Plate. Car is operable but was warned this could result in catastrophic failure of the transmission. Vehicle has approximately 62,000 miles
The contact owns a 2020 Ford Fusion. The contact stated that upon rolling to a stop, the vehicle started shuddering while depressing the brake pedal. The contact stated that the message "Transmission Not in Park" was displayed. The gear shifter then | Automatic transmission failed No warning No smells no shaking no jerking no light on dash board until it went out that's when it jerk and still no check engine light just a wrench that popped up once | VIN: [XXX] Issue Category: Powertrain / Flex Plate / Transmission Failure Dealerships Involved: Freeway Ford – Bloomington, MN J.C. Lewis Ford – Savannah, GA Summary: I am requesting reimbursement from Ford Motor Company for repeated flex plate
The steering cable is connected to the transmission hub, and the fitting that connects the two has a gasket that wears away and falls out. This is a recall with vehicles that are made from one of the two plants that assemble fusions, however my vehi | Car shifts into 1st gear when traveling at higher speeds (45+mph), causing a significant jerk and almost causing a rear end collision to myself. Car also loses power and jerks significantly hardwhen shifting to reverse and drive from Park. Afraid to
The contact owns a 2020 Ford Fusion. The contact stated that upon starting the vehicle, the contact noticed smoke coming from the engine compartment. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed | The contact owns a 2020 Ford Fusion. The contact stated that upon starting the vehicle, her husband noticed white smoke coming out of the mufflers. The vehicle was taken to the dealer, where it was diagnosed that the engine short block had failed and | The contact owns a 2020 Ford Fusion. The contact stated the vehicle was started and the check engine warning light illuminated. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that there was coolant
Vehicle Make/Model/Year: Ford Fusion, 20XX (replace with your year) Component Affected: Suspension – lower control arm bushing or mount Summary of the problem: I am reporting a recurring and well-known issue with the lower control arm bushings on F | The ball joint broke off while driving and the car only has 44,000 miles. | At approximately 99,900 miles, my 2020 Ford Fusion began experiencing serious transmission issues, including rough shifting, hesitation, jerking, and difficulty accelerating, especially at low speeds or while merging onto highways. These symptoms cre
The contact owned a 2020 Ford Fusion. The contact stated that while driving at 70 MPH, the contact briefly lost control of the vehicle. As a result, he collided with the center guard rail on the drivers side of the vehicle. The air bags did not deplo | As I was crossing an intersection, a vehicle ran through a red light and hit the front of my vehicle. There was significant damage to the whole front end and my vehicle was shifted to the left due to the impact. My air bags did not deploy. I injured | The driver steering wheel air bag moves to easily that could cause to eventually go off
Allegedly reported: 3 injuries (as reported to NHTSA).
I keep getting SHIFT SYS FAULT error. My car will not move out of P (park). I towed my car to repair shop on 2/11/2026 - 02/13/2026 the mechanic told me he replaced the bushing kit and the gear dial. Less than a week later on 02/26/2026 I got the sa | COMPONENT: ELECTRICAL SYSTEM, ENGINE I HAVE HAD THIS SENSOR THAT MAKES MY CHECK ENGINE LIGHT STAY ON 3 SEPARATE TIMES! THIS NEEDS TO BE RE CALLED I SEE MULTIPLE COMPLAINTS WITH THE SAME CONCERN | I don't know what failed, but my vehicle spontaneously combusted this morning in front of my apartment.and is a total loss. Fire Marshal's [XXX] ) Case# XX-XXX. The fire also destroyed the vehicle sittling next to it. We are lucky the building di
The contact owns a 2020 Ford Fusion. The contact stated while driving 70 MPH, the vehicle started pulling and veering to the right, while driving on uneven pavement. The power steering assist warning light illuminated while driving over 35 MPH. On an | The contact owns a 2020 Ford Fusion. The contact stated while driving approximately 60 MPH, the vehicle changed lanes independently. The vehicle was steered to the side of the road. The vehicle was taken to a dealer where it was diagnosed that the st
I purchased a used 2020 Ford Fusion from Carmax n 2023 with about 56,800 miles. A week later was involved in a nor side impact accident on the back end driver side, insurance paid for a dinted door and there was no other issues with the vehicle acco | Component or system that failed: Flex plate, engine electrical system, and alternator (possible related failures). The issue has been diagnosed by a licensed mechanic and is available for inspection upon request. Incident Description: On April 15, 2 | At first the check engine light was on and the car would not start. The dash would display all the lights and at one point it turned off while driving luckily I was going 20-30mph. Took it to the dealership and they said an Intake Valve had to be rep
Speed sensor radar on right front tire sending alerts to car all at once — Antilock Brake Fault, Pre Collision Assist not available, Hill start assist. Steering wheel gets heavy randomly. And brakes start slipping. This is a safety hazard I have a | CONSTITUENT WRITES REGARDING AN ISSUE WITH THEIR BRAKES ON THEIR 2020 FORD FUSION. | Brake fluid completely empty?
When these problems started it was only 6 months after purchase and I was already having issues with power train malfunctions and it didnt want to switch gears. I purchased this at roughly 47,000 miles and it didnt make it to 70,000 miles before I ul | The contact owns a 2020 Ford Fusion. The contact stated that while driving and attempting to make a right turn, the parking brake activated causing the vehicle to abruptly stop. The contact was turned off and then restarted the vehicle. Approximately
The entire media display gets stuck off or will freeze up, when I place the vehicle in reverse the rear camera comes on but parking assist, the rear sensors and cross traffic sensors won't work. Once I place the car in drive the display will either s | Issues with Ford Sync Infotainment system have been occurring for over a year now, with the latest being on May 25th. Backup camera stays on when in drive, and then turns to a blue or black screen that says contact dealer. GPS will fail randomly and
I am the second owner on my Ford fusion 2020 SE all-wheel-drive I got the car at 21,000 I had warranty since I had the warranty. I've been going for this power training code and having them check my car out all the time they always say there's nothin | 2020 Ford Fusion SE- Transmission problems. Only 98,000 miles on the car and have had issues with this transmission after a year of having it. Transmission fluid was good but there is a small leak, slipping gears, winding, and gear auto shifting back | THE TOUCHSCREEN DISPLAY IS NOT WORKING. IT TURNED COMPLETELY BLACK. I CANNOT CHANGE THE RADIO STATION. I SHUT OFF MY CAR AND TURNED IT BACK ON AND IT IS STILL NOT WORKING HAD TO HARD RESET THE SYSTEM CAR ALSO SHIFTS HARD IN AND OUT OF PARK AND REVERS
Finish on inside of wheels flacking off and rusting | WHEEL BEARING HAD TO BE REPLACED, HEARD SOUND WHILE IN MOTION AND SLOWED DOWN CAR. CAR ONE YEAR OLD AND LESS THEN 30K MILES
Shifter Cable broke in multiple vehicles of the same year make and model in our fleet of vehicles within a short amount of time. Car would not change gears properly. Issue confirmed and fixed by a local mechanic shop. No warning messages or other | Multiple vehicles of the same year make and model had the shifter cable fail within a short amount of time. car would not change gears properly. problem confirmed and fixed by local mechanic shop. no inspections. no warning lights or messages prio | Back up camera, and touch screen go completely out...the whole system will not come back on until vehicle is shut off and restarted. This has happened multiple times now.
Allegedly reported: 1 injury (as reported to NHTSA).
If your 2020 Ford Fusion has had repeated repairs for the same problem, you may have rights under California lemon law. Tell us about it and we will review your situation at no cost and no obligation.
This page is attorney advertising and is provided for general informational purposes only. It does not constitute legal advice and is not a substitute for advice from a licensed attorney regarding your specific situation. Viewing this page or contacting Lucky Lemon Law does not create an attorney-client relationship; such a relationship is formed only by a signed written agreement.
The recalls and complaints shown here are reported to NHTSA and are consumer-reported, unverified allegations. They do not establish that any defect exists in any individual vehicle, and nothing on this page should be read as asserting that the 2020 Ford Fusion is defective. Counts reflect items filed with NHTSA and may not be current. “May qualify” statements are general and do not mean any particular vehicle or owner qualifies.
Past results do not guarantee a similar outcome. Every case is different and depends on its own facts. Lucky Lemon Law is responsible for the content of this advertisement.