Below are recalls and complaints reported to NHTSA for the 2025 Ford Explorer. This information is consumer-reported and provided for general informational purposes only. Vehicles like this may qualify under California lemon law depending on their individual repair history.
The following recalls were reported to NHTSA. A recall does not by itself establish that any individual vehicle is defective.
Ford Motor Company (Ford) is recalling certain 2025 Explorer vehicles. The bolts securing the front brake caliper may not be tightened properly, which can result in a loss of front brake function and possible wheel damage.
Reported consequence: Loss of brake function and wheel damage can increase the risk of a crash.
Remedy: Dealers will inspect and tighten the bolts as necessary. If bolts are missing, the brake caliper and pads will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed June 19, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S60.
Ford Motor Company (Ford) is recalling certain 2025 Transit, F-150, and Explorer vehicles. The connecting rod and rod bearing components may have manufacturing defects that can lead to engine damage and engine failure.
Reported consequence: A damaged engine can result in engine failure and a stall, increasing the risk of a crash.
Remedy: Dealers will inspect the connecting rods and replace the engine long block assembly as necessary, free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S55.
Ford Motor Company (Ford) is recalling certain 2025 Explorer vehicles. The powertrain control module (PCM) may reset while driving, which can damage the park system or cause an engine stall.
Reported consequence: A damaged park system can result in a vehicle rollaway when the vehicle is placed in park without the parking brake applied. An engine stall while driving can result in a sudden loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S35.
Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.
Reported consequence: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the transmission cross member bolts as necessary, free of charge. If the cross member bolts are missing, dealers will replace the cross member and install new bolts, free of charge. Owner notification letters were mailed January 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S03.
Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. A mounting bolt for the front subframe may have been tightened improperly.
Reported consequence: A loose subframe bolt may reduce the vehicle's performance in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and tighten the subframe bolts as necessary, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Owner notification letters were mailed May 21, 2025. Ford's number for this recall is 25S43.
Ford Motor Company (Ford) is recalling certain 2025 Explorer and Lincoln Aviator vehicles. The rearview camera image may fail when the vehicle speed reaches 10 MPH or greater. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Reported consequence: The loss of the rearview camera image while in reverse can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed on March 28, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C34.
Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. When towing a trailer, the tail lights on the trailer may fail to illuminate due to an improperly manufactured body control module. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Reported consequence: Trailer tail lights that do not illuminate as intended can reduce visibility to other drivers, increasing the risk of a crash.
Remedy: Dealers will replace the body control module C on vehicles with less than 9,000 miles. For vehicles over 9,000 miles, dealers will perform a functional check on the body control module C and replace it as necessary. Repairs will be performed free of charge. Aviator 2025 owner notification letters were mailed October 13, 2025. Explorer 2025 owner letters were mailed November 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C42.
The following are consumer-reported complaints filed with NHTSA. These are unverified allegations and are not proof that any defect exists.
When making a turn or going around curves the steering does not return to center and sticks in whatever direction you are turning | -EPAS malfunctioning and is available for inspection. -Steering sticks in turns and requires too much effort to return to center causing me to overcorrect which causes the steering to stick in the opposite direction and so on. This is not consistent | Steering drifts to left and will not return to center with out darting to the right when correcting , a constant movement back and forth to keep it in your lane !
My remote start would not work from inside of a restaurant so I went out to manually start the car. It started fine. It was very cold out so I thought that I would drive up next to the building to get close to the entrance. The parking lot was not sl | We purchased a 2025 Ford Explorer Active RWD and had a couple of issues with it. Twice when starting the car, foot on brake and when putting it into D the brake pedal drops a notch. It had some error codes as well and OF Course the dealer could fin
Brakes failed while coming to a red light. Turned to the right and into rock landscaping and pushed the ebrake to stop. Antilock brake failure came up and pre collision assist said was no longer available. Had to have it taken to Ford dealership. The | I bought the car in December and I was only able to take it out on the road in January, when it started to have problems with the software and brake system. I brought it to the dealer's workshop where I bought it, but they haven't solved anything and
As ZERO Recall data refreshed on Aug 09,2025 shows Unrepaired Recalls associated with 2025 Explorer. Please BROADCAST...THE FOLLOWING.. 2025 Explorer Safety Recalls* Missing o-ring supporting disc on bosch fuel injectors Recall incomplete Accesso | VIN: [XXX] Recall data refreshed on Aug 09,2025 0 Unrepaired Recalls associated with this VIN for 2025 Police Interceptor - Utility While the 2025 Ford Explorer is recalled,this model for 2025 Police Interceptor - Utility has additional incomplete
Ever since I bought that vehicle, it's had system malfunctions. I received three letters directly from Ford explaining the problems this vehicle had or could have. But he and the dealerships, where I took my vehicle for repairs, never did them. They | While traveling down the road - not turning or braking - several alerts and alarms started flashing on the driver dashboard on my 2025 Explorer. At this time, I completely lost the ability to slow the car down. The digital emergency brake made no c
See Attached Repair Order | The contact owns a 2025 Ford Explorer. The contact stated that after his wife had pulled into the parking spot at the residence and shifted into park(P) to turn off the vehicle, the contact stated that the cameras activated on the display screen and
I am writing to formally report a series of catastrophic and life-threatening mechanical and electronic failures in my 2025 Ford Explorer Active (VIN: [XXX] ]), purchased in Bogotá, Colombia. Despite immediately notifying the Ford Post-Sales Support | 6/2/25 tried to start vehicle, codes coming up and car would not start 6/6/25 car was in park running, starting chiming with alarms, the same alarms that came up a few days before.
I brought my 2025 Explorer in on 12/19/2025 for a recall check. I mentioned to the Service Advisor that the left rear inner wheel well skirt was detached from the quarter panel. After the car was looked at, he came to me and said that they can be rep | My 2025 Ford Explorer has a wind noise that Ford has admitted to having an issue with. My case number is CXH04811376. In the upper corner of both the drivers and passenger side front window there is a loud wind noise that begins at speeds of 40 mph a | The contact owns a 2025 Ford Explorer. The contact stated that while the vehicle was parked in a parking lot, while attempting to exit the vehicle, the front driver’s side door panel separated from the door frame. The vehicle was taken to a local dea
Parked vehicle on snowy driveway, went to back to unload personal items from liftgate, and vehicle began sliding backwards towards me. Ran to the driver‘s door, got in, put on brakes, started vehicle and pulled it forward. Put it in park, and as I wa | Stopped at traffic light when changed to green pushed on the gas started to roll backwards . Got it stopped and pushed on gas would barely go sounded like transmission slipping. Finally got it thru the stoplight and it started again. Got it home call | Automatic Return To Park safety feature failed to stop vehicle from forward rolling causing vehicle to crash into open garage. The drivers door hit side of garage frame, closing onto my left leg causing calf muscle pain and bruising.
Allegedly reported: 1 injury (as reported to NHTSA).
My vehicle originally showed more than 10 open safety recalls in the FordPass app and at the servicing dealer. I saved screenshots of each recall. After Ford performed a remote over-the-air software update, all but one recall suddenly disappeared fro | “I rented vehicle VIN [XXX] from Budget Rental Car in Panama City Beach, FL (Reservation #XXX, Rental Agreement XXX). I later discovered the vehicle had an unrepaired federal safety recall (NHTSA Recall 25V543 / Manufacturer Recall 25C42) involving
The contact owns a 2025 Ford Explorer. The contact stated while driving 65 MPH, there was an abnormal windy sound coming from the driver's side-view mirror. The vehicle was taken to two different dealers, where it was determined that the turbulence w | The contact owns a 2025 Ford Explorer. The contact stated while driving at an undisclosed speed, there was an abnormal sound coming from the doors and windows. No warning light was illuminated. The vehicle was taken to a dealer to be diagnosed; howev
Alignment went bad 23489 miles and took to dealer. It was inspected and found out the front cam bushings and bolts were already worn out and had to be replaced both sides. Plus realignment after. Cost was 544.00 dollars had to pay because alignment f | The contact owns a 2025 Ford Explorer. The contact stated while driving at an undisclosed speed, the contact heard an abnormal rattling sound coming from underneath the vehicle. A dealer was contacted. The vehicle was then taken to the dealer where i
The contact owns a 2025 Ford Explorer. The contact stated that while driving at undisclosed speeds on several occasions with the cruise control activated, the vehicle inadvertently accelerated to 70 MPH. The contact stated that the unintended acceler | Gateway module does not work. I've had my 2025 vehicle since 11/21/2024 (over 7 months) and it has never worked. I have not had a safety update since 05/2024 when it was at the factory. There has been many OTA updates and updates that need to be pre | The system control display (radio screen) and the digital instrument cluster reboot (screens go black) approximately every 10-minutes while driving. During the screen going black, driver is unaware of speed, condition of vehicle. It is unknown if saf
The contact owns a 2025 Ford Explorer. The contact stated that on the first day after the vehicle was purchased, the pre-collision camera failed to function as intended. The contact stated that the alarm failed to beep as intended when a person or an | I am concerned that the Forward Collision Warning and Automatic Emergency Braking are not working sensitive enough to assist in preventing a collision. I had a 2021 Explorer with these features on it and it would give an audible warning at least 8-10
Ever since the last recall got resolved the car has failed to go into the gear it’s set to. Such as it fails to go in park when you shift it into park. This is a serious issue as I have now almost rear ended cars in parking lots a few times because o | The expansive and overly complicated electronic display has moving menu buttons. By that I mean when you use a feature such as the heated seats or radio source and make a choice, the next time you go there to change something the buttons are in a dif | Instrument panel and center dash monitor: Multiple times, one and/or both have had a blacked out screen during power up and after engine start. The screens never come on or they go dark after powering up the vehicle. Safety concerns: This limits
Front side windows (driver and passenger side) have a quality issue that creates a distorted, wave-like view when looking out the window. This results difficulty viewing objects seen in the side mirrors. Also, when viewing anything out the side windo | Since new. Thousands of dots or specs are visible in the window upon sun up of sun down. This is not the snow flake safety campain that Ford has. Others have the same complaint on social media. | Driving to park in garage and camera system came on the display screen, non-functional, displaying a black screen and message with "There's an issue with your camera system" - please see dealer for service. *This has happened twice, once on [XXX] at
If your 2025 Ford Explorer has had repeated repairs for the same problem, you may have rights under California lemon law. Tell us about it and we will review your situation at no cost and no obligation.
This page is attorney advertising and is provided for general informational purposes only. It does not constitute legal advice and is not a substitute for advice from a licensed attorney regarding your specific situation. Viewing this page or contacting Lucky Lemon Law does not create an attorney-client relationship; such a relationship is formed only by a signed written agreement.
The recalls and complaints shown here are reported to NHTSA and are consumer-reported, unverified allegations. They do not establish that any defect exists in any individual vehicle, and nothing on this page should be read as asserting that the 2025 Ford Explorer is defective. Counts reflect items filed with NHTSA and may not be current. “May qualify” statements are general and do not mean any particular vehicle or owner qualifies.
Past results do not guarantee a similar outcome. Every case is different and depends on its own facts. Lucky Lemon Law is responsible for the content of this advertisement.