Below are recalls and complaints reported to NHTSA for the 2024 Ford Explorer. This information is consumer-reported and provided for general informational purposes only. Vehicles like this may qualify under California lemon law depending on their individual repair history.
The following recalls were reported to NHTSA. A recall does not by itself establish that any individual vehicle is defective.
Ford Motor Company (Ford) is recalling certain 2024 Ford Explorer vehicles equipped with 3.3L Hybrid engines. The 12-Volt battery cable may chafe against the Belt-integrated Starter Generat (BiSG) and short circuit.
Reported consequence: A short circuit increases the risk of a fire.
Remedy: Dealers will install a tie strap between the battery cable and high voltage cable, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S61.
Ford Motor Company (Ford) is recalling certain 2024-2026 Explorer and 2024-2026 Lincoln Aviator vehicles. The trailer hitch assembly bolts may be loose.
Reported consequence: While towing a trailer, loose trailer hitch bolts can cause a loss of vehicle handling and control, or cause the trailer to detach. Either of these conditions can increase the risk of a crash.
Remedy: Dealers will inspect and tighten the trailer hitch bolts, or replace them as necessary, free of charge. Owner notification letters were mailed October 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA3. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
The following are consumer-reported complaints filed with NHTSA. These are unverified allegations and are not proof that any defect exists.
Purchased new from dealer. At 3500 miles, noticed rattling and clunking noise under front end, more noticeable at speeds less than 35. Took to dealer who diagnosed as worn struts, saying shocks and struts need to be replaced, but they need to order | The contact owns a 2024 Ford Explorer. The contact stated while driving approximately 30-40 MPH in cold weather, the vehicle started making an abnormal clunking and rattling sound near the wheels. The contact was unable to determine the source of the
Rear windshield wiper doesn't work. Earlier model years have been recalled for wiper motor issues. | Visual blurry defect in windshield glass in driver side | There is a distortion in the front windshield affecting my ability to see the front right corner of my vehicle. I was leaving a restaurant in the dark and the distortion affected the headlights to the point it didn’t appear there were any on the righ
Deputy was going to an incident and after arrival at the scene the patrol car began to smoke, and flames were seen within the wheel well. Deputy was not in the vehicle when the fire was discovered, and Fire responded and extinguished the flames - but | Inner fender liners are getting rubbed through by the tires creating large holes and exposing wiring harnesses and other components to the tire/wheel well area. We have seen this on about 5-6 of these same vehicles now.
If your 2024 Ford Explorer has had repeated repairs for the same problem, you may have rights under California lemon law. Tell us about it and we will review your situation at no cost and no obligation.
This page is attorney advertising and is provided for general informational purposes only. It does not constitute legal advice and is not a substitute for advice from a licensed attorney regarding your specific situation. Viewing this page or contacting Lucky Lemon Law does not create an attorney-client relationship; such a relationship is formed only by a signed written agreement.
The recalls and complaints shown here are reported to NHTSA and are consumer-reported, unverified allegations. They do not establish that any defect exists in any individual vehicle, and nothing on this page should be read as asserting that the 2024 Ford Explorer is defective. Counts reflect items filed with NHTSA and may not be current. “May qualify” statements are general and do not mean any particular vehicle or owner qualifies.
Past results do not guarantee a similar outcome. Every case is different and depends on its own facts. Lucky Lemon Law is responsible for the content of this advertisement.