Below are recalls and complaints reported to NHTSA for the 2021 Ford Expedition. This information is consumer-reported and provided for general informational purposes only. Vehicles like this may qualify under California lemon law depending on their individual repair history.
The following recalls were reported to NHTSA. A recall does not by itself establish that any individual vehicle is defective.
Ford Motor Company (Ford) is recalling certain 2021-2023 Lincoln Navigator, Expedition, and 2022-2023 F-250 SD, F-350 SD, F-450 SD, F-550 SD, and F-600 SD vehicles. The windshield wiper arms may break, causing the wipers to fail.
Reported consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the wiper arms, as necessary, free of charge. Interim letters, notifying owners of the safety risk, are expected to be mailed April 13, 2026. Additional letters will be sent once the remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S24.Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 1, 2026.
Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.
Reported consequence: A detached wind deflector can become a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 30, 2025.
Ford Motor Company (Ford) is recalling certain 2021 Expedition, 2021-2022 Super Duty F-250, F-350, F-450, F-550, F-600, and 2020-2022 Lincoln Corsair vehicles. The rearview camera may display a blank or distorted image.
Reported consequence: Rearview camera failure can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera as necessary, free of charge. Owner notification letters were mailed September 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S05.
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Reported consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Ford Motor Company (Ford) is recalling certain 2021 Expedition and Lincoln Navigator vehicles. An engine compartment fire may occur while driving or parked, even with the ignition in the "Off" position.
Reported consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised to park their vehicles outside and away from structures and other vehicles, until the remedy is performed. Dealers will inspect and replace the battery junction box, as necessary, and remove a ground wire. On models equipped with standard-duty radiator fan motors, dealers will also install an auxiliary electrical box with a wire jumper. Repairs will be performed free of charge. Interim owner notification letters informing owners of the safety risk were mailed May 25, 2022. Owners will receive a second letter once the remedy is available. Currently the remedy is available for vehicles equipped with heavy-duty radiator fan motors, and those letters were mailed July 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S36.
The following are consumer-reported complaints filed with NHTSA. These are unverified allegations and are not proof that any defect exists.
The 10r80 transmission of this vehicle failed resulting in erratic shifting, slowing and stopping of the vehicle in traffic, having to pull over in the middle of traffic. Rapid acceleration and deceleration resulting in jolting the people in the vehi | Transmission harsh shifting. Common problem with ford on the 10r80. Was told from ford need new transmission | Most mornings when I shift the vehicle from Park to Drive the transmission slams into gear and it feels like the vehicle just hit a wall. Also when shifting from 4th through 8th gear the transmission shudders through the shift sequence and sometimes
The contact owns a 2021 Ford Expedition. The contact stated that while driving at 45 MPH, the engine overheated. The message “Drive Mode Inoperable” was displayed. The contact pulled over for 20 minutes, and the vehicle was restarted. The vehicle was | The contact owns a 2021 Ford Expedition. The contact state while driving 55 MPH, there were abnormal sounds coming from the engine and the transmission. The temperature gauge warning light was illuminated. The vehicle was taken to a Chevrolet dealer | It started with transmission issues and has since been nothing but trouble. Car has been in and out of shop, now the ac is out. Ford takes no accountability
Down to 3 gallons gas stopped and added to half a tank. Left vehicle running while filling. Pulled out of gas station and vehicle started to sputter, drove 50 more feet and vehicle died and would not restart. Confirmed unleaded and station had no r | The fuel pump failed without warning leaving the vehicle stranded in the express lane of a highway. This exposed the vehicle and occupants to serious risk of collision. The vehicle does not allow the transmission to shift to neutral to move the vehic | Fuel pump part number JL1Z*9H307*G failed at highway speed leaving vehicle stranded in express traffic lanes. But for the prompt response from FHP this would have resulted in a serious crash. The vehicle has almost never been operated below 30% of fu
The contact owns a 2021 Ford Expedition. The contact stated that while his wife was inside the vehicle with the vehicle idling, the vehicle vibrated and then turned off. The contact's wife attempted to restart the vehicle, but the vehicle failed to s | The contact owns a 2021 Ford Expedition. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The contact's wife had attempted to start the vehicle several times. The contact stated that when the vehicle was sta
I originally leased and have since purchased this vehicle. Since owning the vehicle, it sometimes has a harsh shift between gears. It is so harsh that I have mentioned it to at least two different Ford dealerships during the transmission warranry per | When driving down the road and it does not matter what speed I am going, is when this issue is happening to most. I will be driving and out of the blue the tachometer will just drop to zero (0) and I lose all power and the vehicle starts shaking vigo
Coolant leak possibly coming from the thermostat housing. | The contact owns a 2021 Ford Expedition. The contact received notification of NHTSA Campaign Number: 22V346000 (Engine) however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet av | The contact owns a 2021 Ford Expedition. The contact received notification of NHTSA Campaign Number: 22V346000 (Engine) however, the part to do the recall repair was unavailable. The local dealer was contacted, and an appointment was scheduled but th
Follow up to my previous complaint (11665325)see link below. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) | I’ve been having issues from day one with shifting gears, the vehicle makes a loud “thunking” noise and practically stops my vehicle in the middle of the road
The contact owns a 2021 Ford Expedition. The contact stated that while driving 60 MPH in the rain with the windshield wipers engaged, the driver's side windshield wiper arm was jerking. The contact stated that upon pulling over to the side of the roa | The contact owns a 2021 Ford Expedition. The contact stated while driving 30 MPH during the snow, the driver's side and passenger’s side windshield wipers ceased to work as intended. The vehicle was taken to an independent mechanic. The vehicle was n | The wiper arms keep popping off the motor. We can pop them back on, but they are still popping off.
Travelling down interstate at speed and right rear quarter panel came loose, was flapping around behind and beside vehicle and partially tore free. This presents a high speed debris hazard. | Door latch mechanism freezes, unable to close/latch door. Ford has a known TSB for this issue, which was recently repaired. Door latch still freezing, so door will not close. Have to drive with bungee cord to hold shut. Totally unsafe for backseat | The right tail lamp on my 2021 Ford Expedition was loose, and the tail lamp completely fell off while I was driving. My safety and the safety of other drivers was put at risk when the tail lamp fell off because my tail lamp was not visible to other d
The “handless” rear hatch opening activates when not intended. This has caused a concussion to a driver while loading a vehicle. While this is not a “driving” system, it causes injuries to occupants immediately prior to driving. It is entirely possib | Issues started after the under the hood fire recall. When driving the vehicle the car will shut down and throw all lights on the dash. This vehicle has been in the shop for repairs, but not fixed. This is a safety issue due to the fact the the vehi
Allegedly reported: 1 injury (as reported to NHTSA).
The contact owns a 2021 Ford Expedition. The contact received notification of NHTSA Campaign Number: 22V250000 (Visibility) and 22V346000 (Engine) however, the parts to do the recall repairs were not yet available. The contact stated that the manufac | The contact owns a 2021 Ford Expedition. The contact received notification of NHTSA Campaign Number: 22V250000 (Visibility) and 22V346000 (Engine) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The | The contact owns a 2021 Ford Expedition. The contact received notifications of NHTSA Campaign Number: 22V250000 (Visibility) and 22V346000 (Engine) however, the parts to do the recall repairs were unavailable. The dealer was made aware of the issue a
On numerous occasions, when traveling at speeds 50mph and over, the vehicle failed to further accelerate when the gas pedal was engaged. This caused the rpm's to rev up to 7 and the vehicle to slow down. Our safety was at risk because the vehicle was | The contact owns a 2021 Ford Expedition. The contact stated that on two separate occasions while the cruise control was engaged at approximately 86 MPH, the RPM increased and the vehicle inadvertently accelerated; however, the contact’s husband was a | For the 3rd time attempting to pass other vehicles our transmission revved up to almost 5000 rpms and would not shift after making a huge clunking sound into an obviously to low gear. We had no power and the vehicle would not accelerate. I do have
The contact owns a 2021 Ford Expedition. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer, where the passenger's side catalytic converter was replaced; however, the failure recurred. The vehi | The contact owns a 2021 Ford Expedition. The contact stated while driving 45 MPH, the vehicle started jerking with an abnormal odor coming from the engine. The check engine warning light was illuminated. The contact was notified by a telephone App of
The contact owns a 2021 Ford Expedition. The contact stated that the vehicle was difficult to steer and was pulling to the left and to the right. There was no warning lights illuminated. The EPAS system was turned off by the owner. The vehicle was ta | Vehicle is making Clicking sound when steering. Also there was an electrical sparking sound in steering wheel that was found and fixed.
The Engine is shutting off completely. I am getting the message "Shift to P. the Restart Engine" This happened as the light changed to green. Heavy morning work traffic was behind me and I had never seen this before and called Ford Service manager an | There is an issue with the auto start/stop where the engine is turned off completely when the vehicle is stopped for any reason. For example, when the car is stopped in a traffic jam it shut off completely which means I have to shift the gear to Park | The contact owns a 2021 Ford Expedition. The contact stated that upon starting the vehicle, the check engine warning light illuminated. The vehicle was taken to the dealer who diagnosed the vehicle and determined that the soy-based electrical wires h
Transmission is slipping and hard shifting or fails to shift. I noticed it at hot temperatures but does it now constantly. Airbag is starting to come out of the perforation below the Ford symbol on the horn. I'm concerned it will deploy while dr | The contact owns a 2021 Ford Expedition. The contact stated that as his wife had attempted to park the vehicle, she placed the gear shifter into park(P) and let her foot off the brake pedal. Once she released her foot off the brake, the vehicle abrup
The 360 degree backup camera displays a black screen when activated in both reverse and forward parking mode. This causes myself & any other driver to not have clear vision around the vehicle while in reverse posing a severe safety hazard. This probl | Back up camera stays lit after putting the car in Drive. After 30 seconds or so it goes off and the screen goes black. You cannot push any buttons on the screen, related to the radio or climate controls. Ford doesn't know how to fix it because its no
The contact owns a 2021 Ford Expedition. The contact stated that after shifting into reverse, she became aware that the rearview camera was not functioning as needed and failed to display an image. No warning lights were illuminated. The vehicle was | The reverse camera system does not display any images, i.e., the screen is black/blue (depending on night/day) and provides no view of what is behind the vehicle. The motion and parking sensors are still providing input, but the driver cannot see wha | Backup camera does not always work and cuts out. Also, the 360 view cameras cut out. It is hard to see in the back during low light conditions with tinted back window. Afraid would hit someone or something when backing out in public parking spaces
LED Daytime Running Light on passenger side headlight is fading and has purple hue at times. This presents poor visibility to other vehicles and can create confusion due to inconsistent appearance for oncoming traffic. | Passenger side front headlight failure. The LED turns purple. Appears this is a common problem on vehicle with this type of headlight assembly F series as well. Dealers claim they don't know about it but a quick search to find its a common issue. Av
In the fordpass app, we get a notification that the vehicle has turned off certain function due to inactivity in order to reserve power. However, we will have just driven the vehicle. This message should only populate when the vehicle is inactive for | This recall was issued in January 2025, we are rolling in to month 4 here, this vehicle is used for business and cant drive it while it has an open recall per insurance, we have lost out on almost 4 months of income on this vehicle along with loan pa | My car continues to have electrical problems since 14 months after my purchase. I have reported it to Ford service multiple times as well as Corporate. Each time the same problem happens, I report it here as well. This is the 5th time that this has
The contact owns a 2021 Ford Expedition. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the moonroof. No warning lights were illuminated. The failure had occurred on several occasions. The conta | The contact owns a 2021 Ford Expedition. The contact stated that while the vehicle was parked, the contact noticed a puddle of blue windshield washer fluid on the ground underneath the vehicle. In addition, the contact stated that the washer fluid wa | The contact owns a 2021 Ford Expedition The contact received notification of NHTSA Campaign Number: 22V250000 (Visibility) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the ma
In cold weather the doors will become unlatched and open. This has happened to all 4 doors, driver side, passenger side, rear driver and rear passenger. We will be driving and the doors will randomly become unlatched and fly open. We have small chi | Vehicle panoramic sunroof shattered imploded while driving for no visible external cause. | The vehicles jerks when shifting, pops out of gear while driving, takes a long time to find the next gear, is delayed when doing from R to D. Yesterday, 05/14/2025, I took a left turn and drove maybe .2 of a mile and the car jerked very hard and popp
Allegedly reported: 1 injury (as reported to NHTSA).
If your 2021 Ford Expedition has had repeated repairs for the same problem, you may have rights under California lemon law. Tell us about it and we will review your situation at no cost and no obligation.
This page is attorney advertising and is provided for general informational purposes only. It does not constitute legal advice and is not a substitute for advice from a licensed attorney regarding your specific situation. Viewing this page or contacting Lucky Lemon Law does not create an attorney-client relationship; such a relationship is formed only by a signed written agreement.
The recalls and complaints shown here are reported to NHTSA and are consumer-reported, unverified allegations. They do not establish that any defect exists in any individual vehicle, and nothing on this page should be read as asserting that the 2021 Ford Expedition is defective. Counts reflect items filed with NHTSA and may not be current. “May qualify” statements are general and do not mean any particular vehicle or owner qualifies.
Past results do not guarantee a similar outcome. Every case is different and depends on its own facts. Lucky Lemon Law is responsible for the content of this advertisement.