Below are recalls and complaints reported to NHTSA for the 2022 Ford Bronco Sport. This information is consumer-reported and provided for general informational purposes only. Vehicles like this may qualify under California lemon law depending on their individual repair history.
The following recalls were reported to NHTSA. A recall does not by itself establish that any individual vehicle is defective.
Ford Motor Company (Ford) is recalling certain 2022 Bronco Sport vehicles. The fuel pump control module (FPCM) bracket may not be secured to the fuel tank assembly, which can lead to FPCM failure and cause an engine stall.
Reported consequence: An engine stall can increase the risk of a crash.
Remedy: Dealers will replace the fuel tank, free of charge. Owner notification letters were mailed December 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S66.
The following are consumer-reported complaints filed with NHTSA. These are unverified allegations and are not proof that any defect exists.
I was driving on the highway and my entire car shut down right in the middle of the highway and would not turn back on or shift into any gears. It was making horrible sounds and was really scary to be dead in the middle of the highway. The shop calle | Below recall was issued but Ford says that my vehicle VIN is not included. Dealer says I have to pay out of pocket to replace the leaking engine oil separator on my vehicle. Oil leakage was observed around engine area and could have had an increase r | At a little over 75,000 miles, I had a warning light come on that basically said there was a problem shifting between 7th & 8th gear and it put my car into safe mode. After getting it to a dealership, I'm told it needs a new transmission and was quot
The contact owns a 2022 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, there was an abnormally strong odor inside the vehicle, which made the contact feel ill. The contact associated the odor with carbon monoxide. T | The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); and the vehicle was taken to the dealer, where an interim recall repair was performed. The contact expressed saf | The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded
Allegedly reported: 1 injury (as reported to NHTSA).
I am reporting a premature transmission failure on my 2022 Ford Bronco at approximately 85,000 miles. The vehicle required a full transmission replacement after experiencing internal transmission failure described by a Ford service manager as “someth | See attached document for complaint. | The contact owns a 2022 Ford Bronco Sport. The contact stated that while driving at various speeds, the message "Power Train Malfunction - Reduced Power" was displayed intermittently. The vehicle was taken to the dealer, where it was test-driven, and
Recurring Safety Defect: Powertrain Cooling System Failure causing Engine Overheating, Coolant Intrusion, and Loss of Motive Power. The vehicle has experienced three catastrophic cooling system failures within a 9-month period, posing a crash and fi | I am filing this complaint regarding a recall affecting my 2022 Ford Bronco Sport. I received a recall notice concerning the possibility of the vehicle catching fire. Despite numerous attempts to resolve the issue, Ford continues to ignore the warn | I noticed my coolant level dropping about a year ago. I would fill up the coolant reservoir and the coolant level would drop within a few days. The issue was from the water pump leaking. I replaced the water pump with an OEM ford water pump. One ye
Allegedly reported: 1 injury (as reported to NHTSA).
The firewall on the passenger side was not sealed correctly causing water to enter behind the glove box affecting the blower motor and causing water to enter the vehicle. Causing mold under the carpet. The leak was confirmed at the Ford dealership | The hood latch and cabling mechanism continues to be a problem for Bronco Sport owners. I have dealt with the cabling detaching from the housing unit four times. This causes safety concerns because the hood cannot be opened when this issue presents. | The rear hatch on the Bronco Sport will intermittently open up if towing a trailer and traversing a driveway apron. The pressure from the trailer hitch is causing the rear hatch door latch to spring open. It’s also happened infrequently without the t
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had ex | The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 22V859000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exc
I have brought the car in both to Marin Ford and Serramonte Ford for a transmission fluid leak. They have confirmed there is transmission fluid pooling under the hood but are either unable or unwilling to repair the source of the leak. Car is still u | I have had multiple issues with my 2022 Ford Bronco Sport in the past 3 years and there have been multiple recalls. The ac failed at the 2 year mark and the rear brakes also started to make an odd noise intermittently when I would have the vehicle i | Brakes squeal when backing up.
Vehicle locked up while driving. Has a new battery already. Full aux electrical function is fine but after shut down while driving will not restart, shift out of gear, roll or steer. All electrical works fine. To tow onto flat bed, had to drag the ti | On or around 17 May 2024, spouse was driving child to daycare. Residential speed limit was 35 mph, when dashboard alerts "Power terrain, Hill Assist, Backup Camera, Front Camera, 911 Service, Please Service Now, Shift System Fault, Parking Brake INO
Break stated feeling a thumping while driving, not breaking, ABS sensor came on dashboard. Car stated giving me a collision warning, pre-collision not available, hill assistant warning, Blind spot detection with cross traffic, and service advance tra | The contact owns a 2022 Ford Bronco Sport. The contact stated that while her husband was driving 35 MPH, the vehicle stalled. The contact stated that there was an abnormal grinding sound coming from the vehicle while reversing. The contact stated tha
The contact owns a 2022 Ford Bronco Sport. While driving approximately 50 MPH, the contact received an alert indicating that the engine was overheating, with the check engine warning light illuminated. The contact pulled over and became aware that th | Water pump, that was just replaced in June at Ford dealership, is leaking. This is ridiculous that Ford cannot put quality products in there vehicles. | The contact owns a 2022 Ford Bronco Sport. The contact stated that after inspecting the driveway, the contact noticed an abnormal stain on the concrete driveway. The vehicle was taken to a local dealer for routine maintenance and the dealer discovere
There has been a recall on this issue for 4 months with no options to have it fixed. The recall clearly states that a fire may start under your hood due to the issue, which seems like an issue that should be addressed asap. | My car has a recall since 07/16 and manufacture has not resolved the issue. | Recall 22S73 from Ford states that fuel injectors can crack and cause an under the hood fire. We have documentation showing that the dealer applied the recommended fix on June 26th 2023. On [XXX] I was driving and felt a fuel smell, a few seconds lat
At approximately 7:00 p.m., it was already dark, and I relied on my vehicle’s rear parking-aid sensor to assist me while backing out of my driveway. However, the rear collision/parking-aid sensor did not activate and provided no audible or visual war | The rear warning system stops working intermittently especially when the rear hatch thinks it’s open. So I ended up backing into another vehicle because I have neck issues and depend on the safety systems of my car.
I was driving to work in my 2022 Ford Bronco Sport when traffic ahead of me stopped suddenly. I was able to come to a complete stop. The vehicle behind me did not see the stopped traffic until the last second and rear-ended my vehicle at an estimated | Air bags failed to deploy when the car hit a tree. Issue has not be reproduced or confirmed by a dealer or independent service center. Vehicle has been inspected by claims adjuster only. There were no messages or symptoms of an issue prior to failure | The contact owns a 2022 Ford Bronco Sport. The contact stated that while driving at 15 MPH, he collided with the rear of a trailer on the front driver's side. The air bags did not deploy, and as a result, the driver was thrust forward into the steeri
Allegedly reported: 4 injuries (as reported to NHTSA).
Brake booster failed. Lost brake assist while driving. Car became unsafe to drive immediately. | Many Bronco Sports have had this loud roaring in the rear and Ford had several patches to this issue, but none fixed the issue. Ford instructed the dealership to not attempt any more remedies to this repair until Ford had a "fix". After calling the d | While parking in a parking lot of a local store I pulled into a spot and stopped about 2 feet from a bumper post. I removed my foot from the brake pedal to pull closer to the post. The car began to idle forward. When I was as close to the post as
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE). The contact stated that while driving around the neighborhood at slow speeds, the "Forward Collision Warning" sy | Potential systemic issue: I purchased the 2022 Ford Bronco Sport on 06Aug2025 which is still within its warranty period. During the test drive I identified the Pre-Collision Assist with Automatic Emergency Braking (AEB) wasn't operable. The dealershi | The collision warning alert goes of sporadically at the most random times when there is actually no threat at all around the vehicle. This will cause (as it is intended to do) the driver to reactively fully apply the break quickly, which could cause
First the battery was drained and needed replaced. Then message on center navigation screen displays “System Off to Save Battery. Please turn ignition off or start engine” when entering the car before trying to start it. Then I was notified of a reca | On Monday [XXX], I was driving my vehicle home when I received the following error messages while driving: -pre collision assist not available -service advancetrac -check park aid -service vehicle soon -front camera fault service required -front ca
On April 8th 2025 our vehicle went into "limp mode" for the third time in 6 months. The previous incidents were part of an active recall and we're repaired by a does dealership. This time it is supposedly the failure of a fuel pump sensor causing the | Over the past year my Bronco Sport has thrown two different codes, powertrain malfunction and collision assist unavailable, and put me in limp mode, 25 times. And the last several times it has gone into limp mode it is accompanied by a weird smell. I
The electrical components in my dashboard and computer system are shutting off while I am driving. “Charging System Service Soon” alert pops up but I have had my battery checked multiple times. The glitches are inconsistent and can happen 1-20 times | Driving on the highway for an hour the speed control kept switching from the speed limit to 20 mph and rapidly decelerating my vehicle. I would reset the speed then everything would repeat, it started 2 weeks ago with one instance. It happened 8ish t
Rats are attracted to the soy based wire coating. They ate every coating off every wire in the entire car, which cost a fortune to fix! I want a new car without that wire coating. I shouldn't be responsible for this mess! It's a known problem. My car | The contact owns a 2022 Ford Bronco Sport. The contact stated that while operating the vehicle, several unknown warning lights flashed on the instrument panel and then disappeared. Additionally, there was a soft, audible chime coming from the rear of | The contact owns a 2022 Ford Bronco Sport. The contact stated that the vehicle slightly hesitated while depressing the start button. There was no warning light illuminated. The contact then received notification of NHTSA Campaign Number: 25V019000 (E
This 2022 Bronco Sport was purchased from a Ford dealership "as is", but I purchased an extended warranty due to this. Since purchase the vehicle has been in the Ford Service approximately 60 days combined for the following: Tork converter replacemen | I take very good care of my car and I purchased it brand new in July of 2022. Out of nowhere a few days ago I had my car slipping of gear and won’t go forward or backwards and then my car proceeded to have the service light pop on and then my check e | Car had 3000 miles on it, started rough idling randomly then the check engine light came on and was flashing. Drove straight to the Ford Dealership in Elko, Nevada and barely made it the 5 miles as the car wanted to die, had gas pedal all the way to
I was trying to park my vehicle and it started blinking and saying park is not available, vehicle is not in park. Place the park brake before exiting the vehicle. I was on a downward slope, so I found an area where it was flat and tried to restart my | Every time road conditions are wet (rain, snow) the drive lane module gets wet and will disable entire transmission and several error codes come up stating power train failure. Hill start assist is disabled, 4wd is disabled, pre-collision assist is d
I’ve had my 2022 ford bronco sport for about 2 1/2 years I ordered it brand new and it made 8 miles on it when I drove it off the lot. Within the past month it’s completely blacked out my radio display while I was driving and wouldn’t come back on un | June 28th, 2024; the entire car turned off on its own while I was waiting for a red light. The engine was primarily off from the auto-start feature, like normal, except after I let go of the brake the entire car just shuts off. The start button would | Sitting in school drop off, car shut off by itself and is dead. What if that happened while driving? Completely frightening!
See attached document for complaint. | rear drive train unit Which is a known problem
I started a Turo business and because of the recall on the Ford 2022 bronco sport I haven’t been able to rent my car out for the last eight months. Turo will not allow you to rent a car that has a recall this recall has been going on for eight months | Dealer has not replaced. Also my brakes are always squeek8ng when I back up. I have had all new brakes put on car. Still does it | Transmission is going out. Costly repair $13,000 Seems to be a known issue but no recall? Let’s do better for your customers
Allegedly reported: 1 injury (as reported to NHTSA).
My truck with dead at a turning light, it's still UNKNOWN what happened. I had 2 people try to give it a boost and it would not turn on, the gears were locked, and it had to be pulled on the tow truck. The brake lights signal was flashing, and the en | Engine makes intermittent metal crunching and scraping sounds at low speeds and when braking in stop an go traffic. And sometimes the sound would be heard the all the time when keeping the car between 25 to 30 mph.
Rear brakes moan when reversing at low speed. Has done this since day one. Also the transmission shifts are hard and hangs in sport mode and won’t shift. It hangs at almost 5k rpms and when I let off the gas no shift till 2300 rpms. Took it in and th | The contact owns a 2022 Ford Bronco Sport. The contact stated while reversing there was a squealing and grinding sound coming from the rear of the vehicle. The vehicle was taken to the local dealer who was unable to determine to cause of the squealin
On 12/22/2025, my fiancé and I purchased a 2022 Ford Bronco Sport from LaFontaine Ford in Lansing, MI. During the initial purchase, we were not aware of any recalls or vehicle defects with the Bronco Sport. Roughly one month later, the check engine | My car lost power on the highway. I took it to the dealership. They had the vehicle for 2 months and said it was repaired under warranty/recall. The same day that I received the car back, the same problem occurred. They kept it for a few days and sai
The contact owns a 2022 Ford Bronco Sport. The contact stated that while driving 60 MPH with the cruise control engaged, while slowing down to exit the freeway, the cruise control failed to disengage, and the vehicle continued driving at 60 MPH. Ther | The contact owns a 2022 Ford Bronco. The contact stated that while his daughter was attempting to park, the vehicle suddenly accelerated forward and crashed into the door of a building. While reversing from the building, the vehicle accelerated. The
Allegedly reported: 1 injury (as reported to NHTSA).
February 26, 2026, Concern: Ford Recall 25S76 / NHTSA 25V467 – No remedy available. My vehicle previously had an earlier Ford recall for fuel leakage and fire risk. The dealer installed a drain tube as an interim fix about 18 months ago. Ford has no | A manufacturer recall was issued for a defect involving the fuel system (fuel injectors), but no remedy or repair timeline has been provided. Due to the safety risk (potential fuel leakage and/or fire), I cannot reasonably use the vehicle without co | A manufacturer recall was issued for a defect involving the fuel system (fuel injectors), but no remedy or repair timeline has been provided. Due to the safety risk (potential fuel leakage and/or fire), I cannot reasonably use the vehicle without co
They sent me 2 papers about recalls and refused to fix it. Whatsoever, they tell me the fuel injection has to go out so they would fix it before even though they know it's bad. The second is a seat belt that click sometimes so basically they won't fi | 1. "Rear Belt Monitor Fault" warning popped up on my dash. My vehicle is available for inspection upon request. 2. This warning indicates that if i get an accident my life is at risk. 3. The light has come on each time while i am driving for the p | Continue to get "Rear Seatbelt Error." I can not safely transport children or adults as this is unsafe. Then, going to Ford to get it even looked at takes weeks, and during that time, they do not allow for a rental car.
Driving the vehicle in the dark on the interstate at 75 MPH and vehicle dash and all lights except front day time driving lights turned off. Almost hit a deer that was dead in the road. This is a recall that was already “fixed” in the spring. Local F | Overnight my electrical system went from working perfectly to not at all. I couldn’t unlock my car using the fob or the unlock button on the driver door and had to manually access the inside of the vehicle. When inside, no lights of any kind were on,
I went to start my car it did not start but repeatedly kept trying to start itself over and over the car locked up completely i couldn't push the brake or anything it wouldn't stop it disappeared from my app..the car cranked itself repeatedly until i | I start my car and can’t even get a mile without the service engine light coming on saying engine is over heating & that my coolant is over temperature. I’ve brought this to the dealership 3 times now and all they have done is reset my codes because | The contact owns a 2022 Ford Bronco Sport. The contact stated that the battery had drained. The vehicle was jump-started. While driving 60 MPH in traffic, the vehicle stalled with several unknown warning lights illuminated. The vehicle was towed to t
On [XXX], the vehicle overheated during a commute, resulting in a blown radiator cap and an empty engine coolant reservoir. Coolant levels had been properly maintained up to that point. The following day, engine coolant was again low, though no visib | There is a repetitive water pump failure in my 2022 Ford Bronco Sport. After 3 replacements, they believe they know what is causing it and even though all the failures occurred under warranty they want to charge $2700 for a decontamination in the coo
The contact owns a 2022 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the contact turned on the heated steering wheel feature, and 30 seconds later, the steering wheel cover began to catch on fire with a blue flam | The contact's wife owns a 2022 Ford Bronco Sport. The contact stated while his wife was driving and making a left or a right turn, the steering wheel locked inadvertently. The contact stated that while forcefully turning the steering wheel, the steer | The steering has developed a clicking/wind up noise while turning around 4000 miles. The vehicle is available for inspection. The vehicle was brought to the dealer twice. The noise was able to be heard, and seems to be an issue with a few bronco
The contact owns a 2022 Ford Bronco Sport. The contact stated that while reversing at an undisclosed speed, there was an abnormal sound coming from the driver's and passenger's side wheels. No warning lights were illuminated. The vehicle was taken to | The contact owns a 2022 Ford Bronco Sport. The contact stated that while in reverse(R), the vehicle made an abnormally loud and squealing sound upon depressing the brake pedal. The vehicle was taken to the local dealer, where the contact was informed | The contact owns a 2022 Ford Bronco Sport. The contact stated that when the vehicle was shifted into reverse(R) and reversing at approximately 4 MPH, the contact depressed the brake pedal, and the rear brakes made an abnormally loud sound. The contac
There are at least three separate chips on windshield caused by very small gravel on different occasions. The windshield should not be chipping so easily. The most recent happened yesterday and immediately spread. The cost of these windshields are pr | Car was parked and windshield cracked from driver side over half the windshield. No damage indicators. | I got in my car to find a 12” long crack in the windshield. Upon inspection, I noticed a small chip in the top black part of the windshield that appears to have caused the crack. I had driven it the previous day and was not aware anything had hit the
The contact owns a 2022 Ford Bronco Sport. The contact stated while his son was parked in the driveway, the rear passenger’s side window failed to roll up as intended. The vehicle was taken to an independent mechanic where it was diagnosed that the r | The contact owns a 2022 Ford Bronco Sport. The contact stated that the side door mirrors had degraded, impairing visibility while driving. The vehicle was taken to the dealer, where an unknown recall was performed; however, the side door mirrors were | I was driving on the highway, when I got a small crack in the windshield on the passenger side. When I was able to stop and inspect the vehicle, there a crack about an inch long. A few hours later after I returned home, I went to retrieve something
If your 2022 Ford Bronco Sport has had repeated repairs for the same problem, you may have rights under California lemon law. Tell us about it and we will review your situation at no cost and no obligation.
This page is attorney advertising and is provided for general informational purposes only. It does not constitute legal advice and is not a substitute for advice from a licensed attorney regarding your specific situation. Viewing this page or contacting Lucky Lemon Law does not create an attorney-client relationship; such a relationship is formed only by a signed written agreement.
The recalls and complaints shown here are reported to NHTSA and are consumer-reported, unverified allegations. They do not establish that any defect exists in any individual vehicle, and nothing on this page should be read as asserting that the 2022 Ford Bronco Sport is defective. Counts reflect items filed with NHTSA and may not be current. “May qualify” statements are general and do not mean any particular vehicle or owner qualifies.
Past results do not guarantee a similar outcome. Every case is different and depends on its own facts. Lucky Lemon Law is responsible for the content of this advertisement.