Ford Explorer 2020: Retiros, Quejas y Ley de Limón de California

POWER TRAIN

Vehicle stuck in park. But will go in gear but just won’t move. | On Tuesday April 7 as I was driving to work, as I was stepping on the break to pull into the parking lot and when the car hit 25 mph it jerked forward.; this was the first time I’ve ever experienced this so I didn’t think much of it. When I was leavi | Thank you for your time reviewing my complaint. I've answered each of your bullet points below. - the transmission is hard shifting in low gears however no warning/no dashboard lights to indicate issue. The vehicle is available for inspection upon r

POWER TRAIN,FORWARD COLLISION AVOIDANCE

On December 26, at approximately 7:08 p.m., I was driving on the Belt Parkway during a snowstorm. I was traveling in the middle lane and began to safely change lanes to the right. During the lane change, the vehicle’s four-wheel-drive system suddenly | Car was bought from Healy Ford in Goshen Ny in January 2023. Car drove fine for the first 6 months. Out of no where all the lights on the dash came on. Hill assist 4wheel drive fault power train malfunction. Collision assist I mean everything. Took i | Powertrain malfunction/ Reduced power Bill start assist warning Pre-collision assist not available

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA).

POWER TRAIN,ENGINE

on 2/27/26 I heard a knocking sound in my car, no warning lights came on, took it to local car place and was told there was no oil in the tank. I immediately made an appt to take it to River View Ford dealership for service. They looked at it on 3/2 | I own a 2020 Ford Explorer with approximately 85,776 miles. The vehicle has experienced two separate loss-of-propulsion events in traffic. On both occasions, the vehicle suddenly lost power while driving and stalled in the middle of a busy intersect | My explorer was very slow/unable to accelerate onto the highway. The next time I started it there was rattling and lots of non engine noises, along with all kinds of warning lights. I took it to the dealership. In his words ‘the turbo grenaded itself

POWER TRAIN,ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE

Ford ST 2020 just 37000 miles, the window from driver side can’t complete close when you try to roll up. When it all most close- it will automatically roll down. TPMS fails cause 4WD fault, ABS turn off and a lot of warning symbol turn on like pre-co | At this time, I am unsure if there is some kind of recall, but my alarm is going off alerting me that the lift gate opened but that isn't true once my vehicle is locked. Also, the headlights turn on by themselves as if i have pressed on the keyfob. I | While driving, vehicle gave Powertrain malfunction, downhill assist unavailable and Pre-collision warning system unavailable faults. The vehicle then came to a stop and would not move. Turning the ignition off and on allowed the vehicle to be safely

WHEELS

Wheels / Tire Pressure Monitoring System The tire pressure monitoring system (TPMS) on my 2020 Ford Explorer intermittently fails to detect the tire pressure in one or more tires. The system will show missing pressure readings or fail to display a r | Tire pressure sensor fault. A rear tire pressure sensor has defaulted more than once. As this is built into the wheel assembly, I believe this is a safety issue | The tire pressure monitoring system has failed. Per the dealership, each tire needs a new battery, which run around $150/each. The first sensor went out approx 1 month ago, with the other 3 going out shortly after. While this does not pose an immedia

FUEL SYSTEM, GASOLINE

The contact owns a 2020 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. There was no warning light illuminated. The vehicle was inspected using a scanner and provided an error code for the | The contact owns a 2020 Ford Explorer. The contact stated that while driving at various speeds, the contact became aware of an abnormal fuel odor inside the vehicle. There were no warning lights illuminated. The vehicle was inspected by a relative wh

POWER TRAIN,UNKNOWN OR OTHER

My got multiple warning messages while driving my 2020 Ford Explorer. My local repair shop ran test and determined it needs a new front axle disconnect actuator/shaft - TECHNICAL SERVICE BULLETIN 23-2174. Without this repair, several sensors are de | When this vehicle is put into reverse it does not engage the transmission at times. You either have to put it back in to park and back in reverse and/or floor it in essence push the throttle all the way down for it to engage. As that happens and it f

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

Air Conditioner turns ON by itself even after being manually TURNED OFF, happened multiple times. This occurred with the manual start and the vehicle running / moving. | What component or system failed or malfunctioned, and is it available for inspection upon request? Sunroof headliner assembly failed. The headliner fabric detached and came off the track without an prior misuse or manual operation, it simply fell loo | Back latch is getting stuck in secondary position when released. Module is intermittently not communicating.

SUSPENSION

On 1/11/2026 while was driving vehicle started making screeching sound. Stopped vehicle and a bolt came off from the rear arm of vehicle and unit was towed for service, which at this moment Ford dealer claimed could not not find any recall notice on | I was replacing the rear struts on 12/5/25. I noticed that both speedlogix vertical links were cracked in the exact same location. I called Speedlogix and they said they no longer carried those links (I see why). Asked for a refund and doesn’t appear | Have replaced rear tires three times in past year. Vehicle causes extreme wear on inside tread of rear tires. Vehicle is known to be prone to have rear axle fractures.

STEERING,POWER TRAIN

After maintaining a speed, accelerating just a bit, the steering wheel vibrates until i increase the speed. Twice I have had it into the shop after I purchased it and the Ford dealership said there is nothing wrong. It cost me the 2nd time. There | Front axle boot defective and leaks grease causing steering instability and possible powertrain failure. Dealer charged $475 to fix/replace the part. Upon further research on-line, it is apparent that thousands of 2020 Ford Explorers exhibit the s | WHILE DRIVING ON THE HIGHWAYTHE 'STEERING FAULT SERVICE NOW LIGHT' CAME UP ON THE DASHBOARD WHILE TRAVELING 75 MPH MILES ON ODOMETER 900. AFTER STOPPING THE CAR AND RESTARTING IT THE 'STEERING LOSS STOP SAFELY' MESSAGE POPPED UP ON THE DASHBOARD

EXTERIOR LIGHTING

The driver side headlight low beam will not work. Dealership said 1700 labor to replace. I have looked into this and several other ford explorer platinum owners have same issue. | Headlight Assembly. Low beam is "out". Check headlight assembly message appears on dash. Was told by Ford that the whole unit needed to be replaced for $1000+. Weeks later it started working normally again. How can it suddenly work when I was told th | Passenger headlight, LED low beam has gone out. Daytime running lights, high beam, and turn signal still work. Tried replacing the module and it's the headlamp that is bad.

SUSPENSION,POWER TRAIN

Vehicle suffered a catastrophic drivetrain lock-up while traveling at approximately 25 mph. The rear wheels physically halted, creating an immediate loss of control and safety hazard. Upon inspection, the Rear Drive Unit (RDU) was found to have a fai | I have 68,000 miles on car and car suddenly started making a thumping sound and jerking when braking. Slip also when driving at low speeds. The Dealership says it needs a new Transmission. I have searched online and found this is a common problem fo | The contact owns a 2020 Ford Explorer. The contact stated that while driving at various speeds, the vehicle felt misaligned and made an abnormal rubbing sound. The vehicle was taken to the dealer, where the failure could not be duplicated; however, t

POWER TRAIN,VEHICLE SPEED CONTROL

Since purchase as a preowned vehicle, we noted this vehicle is equipped with a faulty transmission/tcm software design that is dangerously unpredictable and creates erratic driving conditions. This passenger SUV Is equipped with a 10 speed automatic | Vehicle did not want to shift above 35 mph. When letting off gas - harsh downshift (with no break lights) at 25mph. Diagnosed transmission problem - repaired- Ford dealership rebuilt transmission. No warnings or messages prior to failure. | With no previous problems, over the course of the past two days the transmission has begun to hard and delayed shift in multiple gears between 10 to 75 mph. When slowing down to go through tolls this morning, as I accelerated, there was a sudden loss

ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE

Three alerts appeared on my dash after starting my car. These alerts are “Pre-Collision Assist Not Available,” “Service AdvanceTrac,” and “4WD Fault Service Required.” This has been an ongoing issue with this vehicle which directly affects the safety | The contact owns a 2020 Ford Explorer. The contact stated that the parking assist was inoperable, and the reverse automatic emergency braking was inoperable. The vehicle was taken to the local dealer where it was diagnosed that the sensors needed to

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

On highway was accelerating to pass another vehicle the transition froze , engine revved with no acceleration ( transmission skipped) this has happened several times over the 5 years. The lasted event we documented the date and mileage it happened d | Fuel purge valve not working properly causing the vehicle to not start after filling with gas, needing to keep vehicle running while filling with gas, safety issue. Turbo faulty causing car to loose power while driving and towing. Safely concern for | I have recently have experienced engine failure with the 2020 Ford Explorer 2.3 ecoboost engine. I was driving on a 4 lane highway, specifically on a bridge, and I experienced loss of power and acceleration. At that time, the engine light came on.

VEHICLE SPEED CONTROL

The contact owns a 2020 Ford Explorer. The contact stated that while driving 75 MPH with cruise control activated, the vehicle unintendedly decelerated while the accelerator pedal was depressed. No warning light was illuminated. The local dealer was | The contact owns a 2020 Ford Explorer. The contact stated while driving at 65 MPH with the cruise control engaged, the vehicle occasionally exceeded 85 MPH and accelerated independently. No warning light was illuminated. The vehicle was not taken to | The contact owns a 2020 Ford Explorer. The contact stated that while driving from a complete stop and depressing the brake pedal, the vehicle made an abnormal grinding sound and accelerated unintendedly. The contact depressed the brake pedal, but the

ELECTRICAL SYSTEM,VISIBILITY/WIPER

Vehicle: 2020 Ford Explorer XLT Date of Incident: October 24 2025 Approx. Mileage: 82000 Affected Component: Visibility / Defroster / Rear Window Glass Description of Problem: While the rear defroster was on, the rear window of my 2020 Ford Explore | Water has been leaking on my passenger side front floor, and now the blower motor has completely seized. Ford quoted me over $1,000 for a blower motor! I have requested asking for satisfaction warranty for this to be covered via email, with no respon | The button to adjust rear view side mirrors malfunctioned. The side mirrors no longer adjust or respond to the button.

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

The contact owns a 2020 Ford Explorer. The contact stated that while reversing, the vehicle stalled. The vehicle jolted forward while parking. The brakes were locking up. While driving 5 MPH, the steering wheel locked up. The 4-WD fault light was ill | I have a previous file for this situation already submitted reference # 11626064. Since that filing I have had an additional occurrence of the same description. I also found a recall for 2021 explorers which sounds to be the same as what I have exper | I was on [SSS], right before [SSS], traveling back from visiting family for the weekend. My vehicle suddenly lost all power while I was in the fast lane doing highway speeds. Luckily I was able to get over to the sliver of shoulder while there was no

POWER TRAIN,ELECTRICAL SYSTEM,SERVICE BRAKES

The wiring is faulty. We have had electrical issues since buying this vehicle. The car is not old- I turned my car on put it into reverse and all these lights popped up saying there’s electrical issues and it can’t work and the brakes legitimately di | WHEN SHIFTING INTO DRIVE, VEHICLE WILL RANDOMLY HAVE A HARD BRAKE PEDAL AND VEHICLE WILL LURCH FORWARD WITH INCREASED RPM. USE OF E-BRAKE OR PUTTING TRANSMISSION IN PARK REQUIRED TO STOP MOVEMENT. PLACE TRANS IN PARK AND RESTART OF ENGINE AND PROBLEM

POWER TRAIN,UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

issued started happening when I tried to get into my car and my keyfob was not working. then notice the number pad was working and was able to get into the vehicle. Once inside, vehicle did not want to start. I turn on and off the headlights and t | * The component that appears to be malfunctioning is the driveshaft and/or related transmission system. I have experienced repeated issues such as abnormal jerking when switching gears, grinding or clunking noises, and jerking through the drivetrain

POWER TRAIN,UNKNOWN OR OTHER,ENGINE

Nearly all loss of engine power while driving on on a highway. Ford states these are the necessary repairs. The mechanic supervisor Verbally told me told me possible Engine coolant in cylinders 2 and 3. I requested photos, however none have been pro | THERE ARE MANY ISSUES WITH THIS VEHICLE. THE FIRST ISSUE IS THAT WATER IS COMING INSIDE OF THE VEHICLE AND POOLING UP ON THE PASSENGER SIDE FLOOR. THE SECOND ISSUE IS WATER INSIDE THE PASSENGER TAILLIGHT. THE THIRD ISSUE IS THE ALLWHEEL DRIVE SENSOR | CAR WAS IN DRIVE OR REVERSE BUT WOULD NOT MOVE, LIKE THE GEARING WAS NOT ENGAGED. PRESSED ON GAS IT FINALLY TOOK OFF ALMOST HITTING ANOTHER CAR. TOOK TO FORD, THEY FIXED SO THEY SAY, BUT IT HAS HAPPENED 4 MORE TIMES. YESTERDAY, WAS IN PARKING LOT

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

The contact owns a 2020 Ford Explorer. The contact stated that the vehicle was taken to an independent mechanic for a routine oil change. While driving at 35 MPH, the vehicle began to make an abnormal knocking and squealing sound. The vehicle began t | The contact owns a 2020 Ford Explorer. The contact stated that upon rapid acceleration at various speeds, exhaust fumes from the tailpipes would enter the cabin of the vehicle. The contact also stated that after heavy rains, water-filled the spare ti

UNKNOWN OR OTHER

Sunscreen failure on panoramic roof. At approximately 55,000 miles on car the sunscreen stopped going back in correctly, with very little use. Now it falls down into the backseat and blocks the view of the rear window of the car if opened. It’s a hug | Scenic sunroof shade has drooped and sagged down impeding my visibility in the rear view mirror to check traffic while backing out and seeing my grandchildren in their car seats | The chrome overlay on the driver side interior door handle is chipping and caused an injury to my finger. The chipped chrome broke off and became wedged in my skin and also resulted in a 0.5in scratch. The injury was extremely painful and required me

Reportado presuntamente: 10 lesiones (según lo reportado a NHTSA).

ELECTRICAL SYSTEM,LANE DEPARTURE

First my radio will not come on when you first start the explorer. Then you turn it off and turn it back on then the radio will start to work. Then blind spot stop working will the radio. They said they fix the problem by updating the software in the | Back up Camera goes blue or blank screen, we have called the Ford Dealer, we took it into their maintenance. Can’t find issue We just received a recall in mail , we called the Ford Dealer today about our backup Camera recall. THEY told us they know n

ENGINE AND ENGINE COOLING

The contact owns a 2020 Ford Explorer. The contact stated that while driving at 35 MPH, the contact heard an abnormal sound coming from the engine. The vehicle was taken to a dealer, where it was diagnosed that the Right-Hand and Left-Hand Exhaust Fl | The contact owns a 2020 Ford Explorer. The contact stated while driving 40 MPH, there was an abnormally loud sound coming the rear end of the vehicle. No warning light was illuminated. The contact returned to the residence and inspected underneath th | The contact owns a 2020 Ford Explorer. The contact stated that while idling at a stop light or while the vehicle was parked, the vehicle was shaking abnormally. The check engine warning light was illuminated. The failure was intermittent at first but

STRUCTURE

The Driver's side pillar along the door and windshield blew off and almost hit the car behind me. On 10/22/24, the exact same thing happened but on the passenger side that time. Our Ford Dealer said the 2020 Ford Explorer model was not a recall item | See attached document for potential defect petition | exterior review side mirrors cause loud whistle noise when driving.

Reportado presuntamente: 4 lesiones (según lo reportado a NHTSA).

SERVICE BRAKES

Electronic brake booster has failed. Ford has issued a customer service bulletin to address however ended the program in 2022. This needs to be turned into a recall as it could easily lead to a fatality if not addressed and replaced. Speaking with fo | We turned the vehicle on and a parking brake error came up on the dashboard followed by the dashboard lighting up with a lot of warnings. The vehicle was turned off and back on but continued with the error. Because we were out at a store and not home | Was at a complete stop heading Westbound on State Road 200 at Amelia Island Parkway (rd name?) at approximately 9:35 AM. I was behind a semi truck in the right hand lane. No one was ahead of him. There were two cars in the left hand lane, no one i

Reportado presuntamente: 1 lesión (según lo reportado a NHTSA).

POWER TRAIN,BACK OVER PREVENTION

The contact owns a 2020 Ford Explorer. The contact stated that while driving at various speeds, the vehicle hesitated while accelerating, and the message "Power Train Malfunction" was displayed. The vehicle was taken to the local dealer who diagnosed | The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) and 23V675000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was cont

POWER TRAIN,FORWARD COLLISION AVOIDANCE,BACK OVER PREVENTION

SUMMARY OF FACTS FOR LEGAL CONSULTATION Bad Faith Redhibition Claim — Louisiana Civil Code Art. 2545 Prepared for Attorney Consultation 1. Vehicle & Transaction Information Vehicle2020 Ford Explorer ST — AWDPurchase DateMarch 2025Purchase Structure1 | I have had the blue screen sensors replaced 3 times. This has been a recall. Now my front camera is having an error code. Yeh blue screen came on while backing up and I hit a rock. They say it has been fixed but now it is still occurring with the rad

POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

While vehicle was driving in motion, all system error messages began to sequence on the dashboard (Steering Assist Fault Service Required, Check Park Aid, See Manual, Service AdvanceTrac, Front Camera Fault Service Required, Full Accessory Power Acti | When the car starts all warning lights come on. Hill start assistance, pre collision assistance, all assistance. There is no cruise, no safety collision assistance at all. First appeared on June 13 2023. Ford Dealer is currently trying to fix the pro

VISIBILITY/WIPER

I had a really disappointing experience at Delta Sonic Car Wash in [XXX] and feel like other customers should be aware. During my visit, an employee used a pressure washer on my windshield before I entered the wash. This caused small debris to stic | Sunroof liner is sagging, blocking rear vision. Currently unable to use sunroof unless I pay 4k for repairs. | My Right windshield wiper dose not working properly . When I turn on the wipers the right one don't move . Sometimes it will come up but the only one that's works right is the left one . This is a safety hazard for driving

POWER TRAIN,LANE DEPARTURE

The contact owns a 2020 Ford Explorer. The contact stated that after parking the vehicle, upon releasing the brake pedal, the vehicle started to roll backwards. There was no warning light illuminated. The contact stated that upon depressing the brake | PREVIOUS COMPLAINT OF 11394378, THEY TRIED TO FIX IT BY CHANGING VALVE BODY FOR TRANSMISSION. THAT DIDN'T WORK SO NOW I'M NEEDING A NEW TRANSMISSION. BEEN WITH THEM FOR OVER A MONTH. THEY ARE WORKING ON IT, BUT STILL AN ISSUE AT THIS TIME.

ENGINE,FUEL/PROPULSION SYSTEM

This problem started about 2 months ago and it happened 3 different times so far. While driving, when pressing the gas, the vehicle will all of a sudden not go. You just drift as if the car is not getting gas. On 2 of the occasions, a shift error mes | This is my third complaint regarding the same issue, driving on the freeway today the gas pedal was not responsive leading to a drop of speed almost getting hit from behind, don't know what to do, I'm getting nervous to use my car because the problem | Previously filed reports 11521566 and 11494044, stating problem with no response from the accelerator pedal, it happened several times again, at different speeds and different driving modes, should I wait to be involved in an accident to sue the com

POWER TRAIN,ENGINE,FORWARD COLLISION AVOIDANCE

Bought my car 2020 and every year I have been on and off the shop to fix it. Last year I just paid them to fox my transmission gearing, clutch and axle. The other dY I have them service it again due to power train malfunction. And sent me an invoice | Vehicle would suddenly slam on breaks when breaking and stalled changing gears. We have had it looked at and it is in engine failure - the vehicle is only 3 years old.

ELECTRICAL SYSTEM,SEATS,UNKNOWN OR OTHER

Various electrical issues GPS not working also drivers seat electrical | Multiple warnings lights from advanced drivers assistance 4x4 went accelerate and could not error code u0102 also rattling from right second row seat.

STEERING

The contact owns a 2020 Ford Explorer. The contact stated that upon taking the vehicle for regular service, he was made aware that the driver’s side CV axle was leaking. The contact was informed that the driver’s side CV axle needed to be replaced. T | The contact owns a 2020 Ford Explorer. The contact stated while driving at approximately 65 MPH and driving over a slight deformation in the road surface, the vehicle was swaying to the left and right with the Electronic Stability Control warning lig | The car pulls on the left when driving. And ticking noise

Reportado presuntamente: 2 lesiones (según lo reportado a NHTSA).

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

Put vehicle in reverse camera camera on then went black and the backup lights went out while trying to move resulting in hitting a pole. | The top brake light bar on the wing over the trunk consistently fails. I have had to replace almost yearly. Water gets into the light bar causing the LEDs to short out and fail. This makes my brake activity difficult to see for truckers and other tal | While driving my Explorer at night on an unlit road in north western New Jersey the instrument cluster in my car displayed a warning message stating, “Check Headlight System, See Manual”. I pulled over and inspected my cars exterior lights for abnorm